State Water Heaters PCE 6-120 - Manuals

Page 3 - INSULATION BLANKETS; WARNING; the water heater or nearby for future reference.; EXTENDED NON-USE PERIODS; CAUTION; CAUTION; WARNING; REQUIRED ABILITY; • Sensors mounted in the drain pan that trigger an alarm or turn

3 FOREWORD Thank you for buying this energy efficient water heater fromState. We appreciate your confidence in our products. Detailedinstallation diagrams are in this manual. These diagrams willserve to provide the installer with a reference for the materialsand method of piping suggested. IT IS NEC...

Page 4 - CLEARANCES; FLOOD WARNING; CHEMICAL VAPOR CORROSION; DO NOT; BRANCH CIRCUIT

4 • Sensors mounted in the drain pan that turn off the water supply to the entire home when water is detected in the drain pan. • Water supply shut-off devices that activate based on the water pressure differential between the cold water and how waterpipes connected to the water heater. • Devices th...

Page 5 - WIRING DIAGRAMS; FOR SINGLE; A-8 CIRCUIT FOR DUAL ELEMENT HEATER

5 WIRING DIAGRAMS C-2 CIRCUIT FOR SINGLE ELEMENT HEATERS EQUIPPED WITH HIGH LIMIT CONTROL Size Temperature Rating of Conductor See Table 310-13 in Code AMG 60° C 75° C MCM (140° F) (167° F) TYPES: TYPES: RUW RH, RHW, RUH, (14-2), (14-2), THW T, TW, THWN, XHHW, UF USE 18 - - - - - - 16 - - - - - - 14...

Page 6 - TYPICAL PIPING CONNECTIONS; TEMPERATURE AND PRESSURE RELIEF VALVE

6 TYPICAL PIPING CONNECTIONS This page shows typical water heater installations by model designations. † OVER CURRENT PROTECTION MUST BE SUPPLIED IN WATER HEATER CIRCUIT.CONSULT LOCAL CODE OR NFPA 70 FOR PROPER INSTALLATION. * INSTALL IN ACCORDANCE WITH ALL LOCAL CODES. TEMPERATURE AND PRESSURE RELI...

Page 7 - OPERATION; FILLING; TEMPERATURE REGULATION; Temperature; TEMPERATURE ADJUSTMENT; DANGER; Turn off the heater electrical supply. Do not attempt to adjust

7 OPERATION CAUTION DO NOT OPERATE THE HEATER WITHOUT INSTALLING ANAPPROVED TEMPERATURE AND PRESSURE RELIEF VALVEIN THE OPENING PROVIDED IN THE TANK. GROUND THEHEATER TO GUARD AGAINST ELECTRIC SHOCK FROM THEHEATER OR WATER SYSTEM. NEVER OPERATE THE HEATERW I T H O U T F I L L I N G W I T H WAT E R P...

Page 8 - BECAUSE THE HIGH LIMIT OPERATES ONLY WHEN; DRAINING; ANODE INSPECTION AND REPLACEMENT; TROUBLESHOOTING; CHECKLIST

8 3. Using a flat tip screwdriver, rotate the adjusting knob to the desired temperature setting. 4. Replace the covers and access panels, and turn on heater electrical supply. Valves for reducing point-of-use temperature by mixing cold andhot water are available, see Figure 5 . Also available areine...

Page 9 - NOTES

9 WATER IS TOO HOT 1. Refer to TEMPERATURE REGULATION section. WATER HEATER MAKES SOUNDS 1. See MAINTENANCE WATER LEAKAGE IS SUSPECTED 1. Check to see if the heater drain valve is tightly closed. 2. The apparent leakage may be condensation which forms on cool surfaces of the heater and piping. 3. If...

Page 10 - LEAKAGE CHECKPOINTS; Instructions; NOTE: Cover and Insulation shown removed to reveal tank top; To Open Drain

10 LEAKAGE CHECKPOINTS Instructions : Use this illustration as a guide when checking for sources of water leakage. You or your dealer may be able to correct what appears to be a problem. NOTE: Cover and Insulation shown removed to reveal tank top Relief Valve To Open Drain Condensation and dripping ...

Page 11 - REPAIR PARTS LIST

11 REPAIR PARTS LIST Now that you have purchased this water heater, should a needever exist for repair parts or service, simply contact the companyit was purchased from or direct from the manufacturer listed onthe rating plate on the water heater. Selling prices will be furnished on request or parts...

Page 12 - Item

12 1A ......... Anode, Alum... ...................................... 9003942 .............. 9003942 ............. 9003943 .............. 90039441B ......... Anode, Mag. .......................................... 9002110 .............. 9002110 ............. 9004302 .............. 90037212 .............

Page 14 - COPPER SHEATH ELEMENT AND WATTAGE CHART

14 1A ......... Anode, Alum... .................................. 9003888 ................ 9003889 ................ 9003889 .............. 9003944 .....1B ......... Anode, Mag. ..................................... 9003721 ................ 9003922 ................ 9001834 .............. 9003721 .......

Page 15 - INCOLOY SHEATH ELEMENT AND WATTAGE CHART

15 .... 9003889 ......................... 9003889 ........................ 9000029 ........................ 9003892 ...................... 9003893.... 9003483 ......................... 9003487 ........................ 9003465 ........................ 9003650 ...................... 9000734.... 900007...