Sirius Satellite Radio PMA8000-SR - Manuals

Sirius Satellite Radio PMA8000-SR – Manual in PDF format online.

Manuals:

Manual

Manual Sirius Satellite Radio PMA8000-SR

Summary

Page 3 - Page

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page ii Rev. 13, July 2006 2.11 TEL C HECKOUT ..........................................................................................................................2-14 2.12 ...

Page 4 - Section I GENERAL INFORMATION; Warning; IntelliVox®

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 1-1 Rev. 13, July 2006 Section I GENERAL INFORMATION 1.1 INTRODUCTION The PMA8000-SR represents another evolutionary step in cockpit audio control and intercommunications ut...

Page 5 - TSO Approval; APPLICABLE DOCUMENTS:; ENVIRONMENTAL Qualifications; A1D1CABSMXXXXXXZBABATBXXE2XXX; POWER REQUIREMENTS

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 1-2 Rev. 13, July 2006 controls the intercom level for the pilot and copilot, while the large knob controls the passenger intercom volume. Intercom squelch is automatic. The...

Page 6 - Audio Selector Specifications; places (with individual; MARKER BEACON RECEIVER:; 5 MHz Crystal Controlled

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 1-3 Rev. 13, July 2006 Audio Selector Specifications Audio selector panel input impedance : 510 Ω Input Isolation : -60 dB (min.) Speaker Muting : -60 dB (min.) Speaker Outp...

Page 7 - Description Quantity; EQUIPMENT REQUIRED BUT NOT SUPPLIED

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 1-4 Rev. 13, July 2006 1.6 EQUIPMENT SUPPLIED 1 ea. of the following units: Model Description Part Number PMA8000-SR PMA8000-SR Audio Panel with Marker Beacon and Stereo int...

Page 8 - Record your Radio ID here for future reference.

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 1-5 Rev. 13, July 2006 When you activate online you pay only $5.00 at www.sirius.com . If you choose to activate by phone the charge is $15. You can either call 1.888.539.SI...

Page 9 - Section II - Installation; GENERAL INFORMATION; NOTE; install this equipment in; unairworthy; and violate Federal Aviation regulations.; Unpacking and Preliminary Inspection; Requirements

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-1 Rev. 13, July 2006 Section II - Installation 2.1 GENERAL INFORMATION 2.1.1 SCOPE This section provides detailed installation and interconnection instructions for the PS ...

Page 10 - Audio Panel Mounting Rack Installation; Manufacturer; Table 1 Connector Pin crimping tools; Cable Harness Wiring

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-2 Rev. 13, July 2006 2.3.3 Audio Panel Mounting Rack Installation Remove the unit from the mounting tray by unscrewing the 3/32" hex-head screw that is in the center o...

Page 11 - all; headphone and microphone jacks.; CASE I; Audio Panel interface; receiver

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-3 Rev. 13, July 2006 Radiated signals can be a factor when low level microphone signals are "bundled" with current carrying power wires. Keep these cables physical...

Page 12 - Figure 2-1 Cellular telephone interface; If an external dimmer control is; not

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-4 Rev. 13, July 2006 Connect the speaker output from the unit to the COM 2 Speaker load input on the PMA8000-SR (J1 27 WRT 28). The speaker load is 16 Ω , 3W. 2.4.6 TEL (D...

Page 13 - inputs; to; initialize the PA Mode. On the remote, press; to switch DME or auxiliary audio.; wiring

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-5 Rev. 13, July 2006 lighting system to work. The photocell mounted in the unit face will automatically adjust the intensity of the push-button annunciation LEDs. 2.4.10 U...

Page 14 - 5 SIRIUS Satellite Radio Installation; SIRIUS Satellite Radio Antenna; installation without wiring changes.

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-6 Rev. 13, July 2006 NOTE: The intercom harness can be custom made by PS Engineering, Inc. Simply call the factory or www.ps-engineering.com to obtain a wire harness work ...

Page 15 - Figure 2-2 Sirius Radio Output Jumpers; Entertainment distribution

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-7 Rev. 13, July 2006 Figure 2-2 Sirius Radio Output Jumpers 2.4.16.5 Entertainment distribution The PMA8000-SR has two INDEPENDENT music inputs. Entertainment input number...

Page 16 - N O T E; t h e a u d i o p a n e l . M a x i m u m s i g n a l l e v e l i s; V A C; u s e a s p e a k e r - l e v e l

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-8 Rev. 13, July 2006 Alternate Music InterconnectA 3-position (on-off-on) can be used to switch entertainment completely off, if desired. External #2 Input 24 2325 27 2628...

Page 18 - Marker Antenna Installation; Front of unit

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-10 Rev. 13, July 2006 2.4.19 Playback button Installation (J2, Pin 22- Option 1, ONLY) To activate the Recording System playback, a momentary push button switch is require...

Page 19 - MKR; Figure 2-6 Top Cover Adjustments; Communications Antenna Installation Notes

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-11 Rev. 13, July 2006 MKR VOL MKR SNS Figure 2-6 Top Cover Adjustments • Marker Beacon Volume, turn adjustment counterclockwise to increase marker beacon audio level. • Ma...

Page 20 - PMA8000-SR Pin assignments; J1 Function

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-12 Rev. 13, July 2006 2.8 PMA8000-SR Pin assignments J1 Function J2 Function 1 Mkr Ant 1 Pilot Phones Lo 2 Mkr Ant Lo 2 Copilot Phones Lo 3 Telephone Audio in 3 Copilot Ph...

Page 21 - Required Test Equipment; Unit Installation; C a u t i o n; IntelliVox

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-13 Rev. 13, July 2006 2.9 Post Installation Checkout After wiring is complete, verify power is ONLY on pins 8 and 9 of the J2 and airframe ground on connec-tor pins 10 and...

Page 22 - and; Marker Beacon Checkout

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-14 Rev. 13, July 2006 13. Push the SPR button. Verify that all selected audio is heard in the cockpit speaker. Verify that the au- dio mutes when the mic is keyed. 14. Ver...

Page 23 - SIRIUS Satellite Radio ID number; Inspection

PS Engineering PMA8000-SR Series Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 2-15 Rev. 13, July 2006 2.12.2 SIRIUS Satellite Radio ID number The SIRIUS Satellite Radio identification number can be played back through the annunciation. Have a pencil h...

Page 24 - Section III OPERATION; always

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 3-1 Rev. 13, July 2006 Section III OPERATION GENERAL INFORMATION 3.1 SCOPE This section provides detailed operating instructions for the PS Engineering PMA8000-SR, Audio Selector P...

Page 25 - Swap Mode (Switch from Com 1 to Com 2 remotely); (auxiliary) places those receivers into the

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 3-2 Rev. 13, July 2006 Figure 3-2 PMA8000-SR Operating controls NOTE: Placing the PMA8000-SR in–TEL– The intercom mode pushbutton determines who is on the phone, and who is still o...

Page 26 - N o t e; Split mode, particularly on adjacent frequencies.; Operation; must

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 3-3 Rev. 13, July 2006 hear a beep with each key press, followed by three acknowledgement beeps. This must be accomplished only once and the PMA8000-SR will “remember” that PA is a...

Page 27 - Table 3-1 Mic Muff TM Part Numbers; The “; ICS

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 3-4 Rev. 13, July 2006 For optimum microphone performance, PS Engineering recommends installation of a Microphone Muff Kit from Oregon Aero (1-800-888-6910). This will not only opt...

Page 28 - When in the A; While in the C; Mute; Table 3-2 Intercom Modes

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 3-5 Rev. 13, July 2006 C REW : Pilot and copilot are connected on one intercom channel and have exclusive access to the aircraft radios. They may also listen to Entertainment 1. Pa...

Page 30 - Sirius Signal Dropout

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 3-7 Rev. 13, July 2006 Press the volume up and down ( VOL UP , VOL DN ) buttons to change the satellite radio volume through the audio panel. This will only adjust the SIRIUS Radio...

Page 31 - ing the remote, push the “TEL” and “SPR” buttons at the same time.; LO; ” sensitivity gives you a more accurate location of the Outer

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 3-8 Rev. 13, July 2006 NOTE: To turn OFF the satellite radio from the PMA8000 panel without us- ing the remote, push the “TEL” and “SPR” buttons at the same time. If you believe th...

Page 32 - Section IV- Warranty and Service; of

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Page 4-1 Rev. 13, July 2006 Section IV- Warranty and Service 4.1 Warranty In order for the factory warranty to be valid, the installations in a certified aircraft must be accomplished b...

Page 33 - Appendix; Appendix A External PTT Hook Up; The PTT is built into the pilot and copilot

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Appendix A Rev. 13, July 2006 Appendix A External PTT Hook Up Part of the installation includes the installation of PTT (Push To Talk) switches that allow the use of your aircraft radio...

Page 34 - Appendix B – PMA 8000 Insta; llation Drawings; Viewed from Back

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Appendix B Rev. 13, July 2006 Appendix B – PMA 8000 Insta llation Drawings 475-013-0001 Lock nut (4 ea) 44-pin connector (2 ea) Rack back plate 430-880-0050 475-440-0004 (4 ea) 475-440-...

Page 35 - Figure 6-1 PMA8000-SR Installation Drawing; e n s u r e e v e n s e a t i n g o f t h e u n i t a n d c o n n e c t o r s .; Supplied; Figure 6-2 SIRIUS Antenna Drawing

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Appendix B Rev. 13, July 2006 Figure 6-1 PMA8000-SR Installation Drawing C a u t i o n : A p p l y s t e a d y p r e s s u r e t o t h e b e z e l w h i l e s c r e w i n g t h e u n i ...

Page 36 - Appendix C, J1 Interconnect

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Appendix C Rev. 13, July 2006 Appendix C, J1 Interconnect Com 1 Audio Hi Com 1 Mic Key Com 1 Lo Communications Transceiver #1 Communications Transceiver #2 Nav 1 Audio Hi Nav 1 Audio Lo...

Page 37 - D, J2 Connector Interconnect

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Appendix D Rev. 13, July 2006 Appendix D, J2 Connector Interconnect 22 20 3536 242325 Copilot Phones (R) Copilot Phones (L) Copilot Phones Lo Pass. 1 Mic Jack Pass. Mic Lo Pass. Mic Hi ...

Page 38 - Appendix E- Instructions for FAA; Form 337 and continuing airworthiness; location; Instructions for Continuing Airworthiness, Audio System; Section Item

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Appendix E Rev. 13, July 2006 Appendix E- Instructions for FAA Form 337 and continuing airworthiness 9.1 Instructions for FAA Form 337, Audio Panels One method of airworthiness approval...

Page 39 - Appendix F RTCA; DO160D Environmental Qualification Form

PS Engineering PMA8000-SR Audio Selector Panel and Intercom System Installation and Operator’s Manual 200-880-0000 Appendix G Rev. 13, July 2006 Appendix F RTCA DO160D Environmental Qualification Form Audio Selector Panel/Intercom/Marker Beacon Receiver Part Number: 050- 880 -( ) FAA TSO Number: C50...