Page 2 - TABLE OF CONTENTS; Page
TABLE OF CONTENTS Page WARRANTY................................................................ 3 SAFETY GUIDELINES AND CHART...................................... 3 WARNING CHART........................................................ 4 SPECIFICATION CHART..............................................
Page 3 - SAFETY GUIDELINES; DANGER
FULL ONE YEAR WARRANTY ON AIR COMPRESSORS If this air compressor fails due to a defect in material or workmanship within one year from the date of purchase, return it to the nearest Sears Service Center/Department throughout the United States and Sears will repair it, free of charge. If this air com...
Page 4 - HAZARDS CAN OCCUR IF EQUIPMENT IS NOT USED PROPERLY.
W A R N I N G 1 HAZARDS CAN OCCUR IF EQUIPMENT IS NOT USED PROPERLY. READ THE FOLLOWING CHART WHAT TO LOOK FOR WHAT COULD HAPPEN HOW TO PREVENT IT Hot Parts When operated continuously the air hose gets hot, especially near the compressor. If you maintain contact by grasping you may suf fer minor bu...
Page 5 - Air Compressor Pump:
SPECIFICATION CHART Model No. 919.15026 Horsepower 3/4 SCFM (w 40 psig 3.0 SCFM @ 90 psig 2.2 Displacement CFM 4.0 Bore 13/4" Stroke 1 V4" Voltage-Single Phase 110-120 Minimum Branch Circuit Requirement 15 AMPS ‘Fuse Type Time Delay Amperage at Max. Pressure 10 *A circuit breaker is preferre...
Page 6 - Location of the Air Compressor; Grounding Instructions; ADANGER
UNPACKING INSTRUCTIONS Grasp the handle and lift the air compressor out of the carton. Remove the styrofoam and discard. INSTALLATION AND START-UP PROCEDURES Location of the Air Compressor Your compressor comes to you completely assembled and ready for use. Operate the air compressor in a dry, clean...
Page 7 - Air Hose; OPERATING PROCEDURES; MAINTENANCE
Air Hose The air hose attached to your compressor has an integ ral pressure adjusting valve at the working end of the hose. Should service or replacement be required make sure that the pressure adjusting valve is present in the air hose line - Do not replace hose with standard hose that is not equi...
Page 8 - STORAGE; ACCESSORIES
Motor Replacement - Wiring Diagram STORAGE FROM SWITCH TO MOTOR BLACK m Connect ^ to ON-OFF Switch Figure 3 When you have finished using the air compressor: 1. Set the "ON-OFF” switch to “OFF” and unplug the cord. 2. Relieve all pressure from the air compressor head and air hose by turning the a...
Page 9 - TROUBLESHOOTING GUIDE
TROUBLESHOOTING GUIDE WARNING ] VOLTAGE SOURCES, MOVING PARTS, OR COMPRESSED AIR SOURCES ARE EXPOSED WHEN REPAIRING THE COMPRESSOR. PERSONAL INJURY CAN OCCUR. UNPLUG THE COMPRESSOR BEFORE ATTEMPTING ANY REPAIRS. PROBLEM CAUSE CORRECTION Air Leaks Hose fitting loose. Tighten fitting. Compressor is no...
Page 10 - AIR COMPRESSOR DIAGRAM
AIR COMPRESSOR DIAGRAM *POWER CORD (GREEN) GROUND WIRE 10
Page 11 - AIR COMPRESSOR PARTS LIST; NOT ILLUSTRATED
AIR COMPRESSOR PARTS LIST KEY NO. PART NUMBER DESCRIPTION 1 SSF-995 Screw #10-24 X Vs LG. hex head thd forming (4 used) 2 CAC-1196 Cylinder head 3 CAC-1212 Tube seal 4 CAC-1199 Head gasket 5 CAC-4323 Valve plate assembly % 6 SSG-8169 “0” ring 7 CAC-1194 Outlet tube + 8 CAC-4325 Rod assembly \/> 9...
Page 12 - SERVICE; CRAFTSMAN
OWNERS MANUAL SERVICE MODEL NO. 919.150260 HOW TO ORDER REPAIR PARTS CRAFTSMAN COMPACT AIR COMPRESSOR Now that you have purchased your Sears Air Compressor, should a need ever exist for repair parts or service, simply contact any Sears Service Center and most Sears, Roebuck and Co. stores. Be sure t...