Sears 200.7144- Manuals

Page 3 - – SAVE THESE INSTRUCTIONS –; Important Safety Instructions; WARNING; Help us help you

2 Sears 440 - Sch 516 9/16/95 – SAVE THESE INSTRUCTIONS – w •Read all instructions and cautions printed on the battery charger, battery, and vehicle or equipmentusing battery. •Use charger only on lead-acid type rechargeable batteries, such as those used in cars, trucks, trac-tors, airplanes, vans, ...

Page 4 - Parts; Wiring diagram

3 Sears 440 - Sch 516 9/16/95 Parts This section shows an illustration of your battery charger. Use it to become familiar with where all the parts arelocated, and what they look like. Replacement Parts List Sears 71440 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Part Number 3599000286 3899000396 389...

Page 5 - Before Using Your Battery Charger; Assembling your charger

4 Sears 440 - Sch 516 9/16/95 Before Using Your Battery Charger It is important to prepare your charger for use. This section will tell you how to assemble the charger, groundand connect the power cord, and prepare to charge a battery. Assembling your charger It is important to fully assemble your c...

Page 6 - Plugging it in

5 Sears 440 - Sch 516 9/16/95 3. Tap the other axle cap onto the opposite end of theaxle and place the axle assembly onto the bottom ofthe charger. Place one end of the bracket into slot,then place the axle assembly under each bracket.Fasten the other side of the brackets using the two10-32 screws p...

Page 7 - Using an extension cord; Preparing your battery to be charged

6 Sears 440 - Sch 516 9/16/95 A TEMPORARY adapter may be used to connect the charger to a two-pole outlet if a properly groundedoutlet is not available. Use the adapter ONLY until a properly grounded outlet can be installed by a qualifiedelectrician. DANGER: Before using an adapter as illustrated, b...

Page 8 - Setting the controls; OUTPUT SELECTOR SWITCHES; AMMETER

7 Sears 440 - Sch 516 9/16/95 To obtain the best results from your battery charger, you must know how to use it properly. This section will tellyou how to set the controls. And how you can charge a battery while it is still in the vehicle, or you can remove itand then charge it. Follow the instructi...

Page 9 - Charging Your Battery; Charging your battery in the vehicle:

8 Sears 440 - Sch 516 9/16/95 Charging Your Battery Charging your battery in the vehicle: 1. Arrange the power cord and charging leads carefully in order to avoid damage that could becaused by the hood, door, or moving engine parts. 2. Keep clear of the fan blades, belts, pulleys, and other parts th...

Page 10 - Charging your battery outside the vehicle:

9 Sears 440 - Sch 516 9/16/95 Charging your battery outside the vehicle: 1. Remove the battery from vehicle, making sure to disconnect grounded terminal first with all powerturned off to the vehicle. 2. Check the polarity of the battery posts as indicated on the battery case: POSITIVE (POS, P, +) an...

Page 11 - Calculating charge time; The Chart Method

10 Sears 440 - Sch 516 9/16/95 Calculating charge time The Chart Method Use the following table to more accurately determinethe time it will take to bring a battery to full charge.First, identify where your battery fits into the chart.• Small batteries — motorcycles, garden tractors, etc. — are usua...

Page 13 - Troubleshooting

12 Sears 440 - Sch 516 9/16/95 Circuit breaker incharger cycles on andoff with a clickingsound. Short start cyclewhen crankingengine. Ammeter reads lessthan selected chargerate when charging adischarged battery. Charger makes a loudbuzz or hum. Troubleshooting Performance problems often result from ...

Page 14 - OWNER’S; For information about troubleshooting; REPAIR SERVICES

When requesting service orordering parts, always providethe following information: • Product Type • Model Number • Part Number • Part Description OWNER’S MANUAL Model No. 200.71440 40/2 AMP MANUAL BATTERY CHARGER 200 AMP ENGINE STARTER For information about troubleshooting Call toll-free from anywhe...