Robin-Subaru EH65D - Manuals

CONTENTS 1. SAFETY PRECAUTIONS ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ 1 2. COMPONENTS ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ 4 3. PRE-OPERATION CHECKS ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・ ・...

Read the owner's manual. Stay clear of the hot surface. Exhaust gas is poisonous.Do not operate in an unventilated area. Stop the engine before refueling. Fire, open flame and smoking prohibited. On (Run) Plus ;positive polarity Off (Stop) Battery Engine oil Engine start (Elec-tric start) Add oil SY...

EXHAUST PRECAUTIONS ■ Never inhale exhaust gas.It contains carbon monoxide, a color-less, odorless and extremely danger-ous gas which can cause uncon-sciousness or death. ■ Never operate the engine indoors orin a poorly ventilated area, such astunnel, cave, etc. ■ Exercise extreme care when operat-i...

3. PRE-OPERATION CHECKS − 5 − CHECK ENGINE OIL (DAILY) Before checking or refilling engine oil, be sure the engine is not running and is located on a stable, level surface. ■ If the oil level is below the lower levelline on the oil gauge, refill with theproper oil (see table) to the upperlevel.OIL C...

4. BATTERY INSTALLATION − 7 − CABLE LENGTH CABLE DIA. WIRE GAUGE AWG (BS) BWG SAE JIS Less than 1.5 m 7.3 mm 1 6 AV15 1.5 m to 2.5 m 8.5 mm 0 4 AV20 2.5 m to 4.0 m 10.8 mm 3/0 2 AV30 PARTS NEEDED ■ Use a battery rated 12V-30AH orlarger. ■ Use a proper cable and ground wireto connect battery and key ...

− 8 − WIRING ■ Connect positive terminal of theelectric starter and positive termi-nal of the battery with batterycable. ■ Ground negative terminal of thebattery to the body of engine ormachine with ground wire. NOTE Tighten bolts and nuts on terminalssecurely so they will not be loosenedby vibratio...

5. OPERATING YOUR ENGINE − 9 − Pull the choke knob. ■ If the engine is cold or the ambienttemperature is low, pull the chokeknob fully. ■ If the engine is warm or the ambienttemperature is high, pull the chokeknob half-way, or keep it fully open. CHOKE KNOB STARTING 1 (Provided by the equipment manu...

− 10 − ■ After starting the engine, gradu-ally open choke by pushing thechoke knob and finally keep itfully opened. ■ Do not fully open the chokeimmediately when the engine iscold or the ambient temperatureis low, because the engine maystop. CHOKE KNOB After the engine starts, set thespeed control l...

− 11 − STOPPING Set the speed control lever at thelow speed position and allow theengine to run at low speed for 2 or3 minutes before stopping. SPEED CONTROL LEVER 2 Turn the key switch to the "STOP"position. ELECTRIC STARTER 3 Close the fuel valve. FUEL VALVE STOPPING ENGINEWITH THE FUEL VA...

6. EASY TROUBLESHOOTING − 12 − WHEN ENGINE WILL NOT START: ■ Perform the following checks before you take the engine to your Robin dealer. ■ If you still have trouble after completing the checks, take the engine to yournearest Robin dealer. Is there enough compression? If the spark plug is loose, ti...

− 13 − Is your battery well charged ? Check the battery, it may be dischargedand unable to operate the electricstarter. Consult your nearest dealer or serviceshop. EH63-65 EPA/CARB 取説EU1728 02.7.31 10:30 AM ページ13

− 14 − 7. MAINTENANCE SCHEDULE DAILY INSPECTION Before running the engine, check the following service items. PERIODIC MAINTENANCE Periodic maintenance is vital to safe and efficient operation of your engine.Check the table below for periodic maintenance intervals. IT IS ALSO NECESSARY FOR THE USER ...

8. "HOW-TO" MAINTENANCE − 16 − INSPECTING THE SPARKPLUG ■ Clean off carbon deposits on thespark plug electrode using a plugcleaner or wire brush. ■ Check electrode gap.Adjust gap to : 0.03 inches(0.7mm to 0.8mm) ■ Use a proper spark plug :NGK BP6ES 0.03 in(0.7 to 0.8 mm) ENGINE OIL CHANGE ■ ...

− 17 − ENGINE OIL FILTER REPLACEMENT ■ Initial engine oil filter replacement shouldbe performed after 20 hours of operation.Thereafter replace the engine oil filterevery 200 hours. ■ When installing a new oil filter, apply oilto O-ring, attach the oil filter in positionand tighten 2/3 turns by hand ...

− 19 − HIGH ALTITUDE ENGINE OPERATION ■ Please have an authorized Robin America service dealer modify this engine if it is to be run continuously above 5,000 feet (1,500 meters). Failure to do so,may result in poor engine performance, spark plug fouling, hard starting, andincreased emissions. ■ Carb...

ENGINE OIL ■ Change the engine oil with fresh oil. ■ Remove the spark plug, pour about 5cc of engine oil into the cylinder,slowly start the engine for 2 or 3seconds, and re-install the sparkplug. CLEAN AND STORE ■ Remove the spark plug wires fromthe spark plugs. ■ Slowly turn the crankshaft until re...