Robin-Subaru EH64 - Manuals

Robin-Subaru EH64 – Manual in PDF format online.

Manuals:

Manual

Manual Robin-Subaru EH64

Summary

Page 2 - Year Limited Engine Warranty

3 Year Limited Engine Warranty (Special Term for Welder Application) (Effective with engines purchased from Robin America, Wood Dale, IL, after November 15, 1993) Robin America, Inc., a division of Fuji Heavy Industries, Ltd. (herein “Robin”), warrants that each new engine sold by it will be free, u...

Page 3 - NOTICE; Safety Precautions; cient operation; • Provide appropriate

NOTICE FEDERAL EMISSION COMPONENT DEFECT WARRANTY and CALIFORNIAEMISSION CONTROL WARRANTY are applicable to only those enginescomplied with EPA (Environmental Protection Agency) and CARB (CaliforniaAir Resources Board) emission regulations in the U.S.A. AIR INDEX To show compliance with California e...

Page 5 - Introduction; ABOUT THIS MANUAL

9 10 Introduction ABOUT THIS MANUAL This manual covers the operation and maintenance of the horizontal- shaft Robin Subaru EH64 engines for welder applications (OHV220 Performer Series). Each operator of the power equipment should study this engine manual carefully and observe all of its instruction...

Page 6 - Description; FEATURES; Speci

Description FEATURES • Overhead valve arrangement enables high power, and low fuel and oil consumption • V-Twin, four stroke design• Air-cooled and gasoline fueled• The light weight and compact design makes it easy to install and utilize for many applications.• A steel crankshaft and high-load beari...

Page 7 - Installation

13 14 Installation LOCATING Locate the engine at least 1 meter (3.0 ft) away from buildings or other structures. Provide proper exhaust routing. Refer to EXHAUST SYS-TEM below. Do not use the engine near fl ammables or other hazard- ous materials such as trash, rags, lubricants, or explosives.When d...

Page 8 - Filling and Change Interval; STARTING BATTERIES; WIRE GAUGE

ENGINE OILRecommendations Use premium quality motor oil, Class SE or higher. Look for the SAE (Society of Automotive Engineers) or API viscosity grade. Referring to the table below, choose the viscosity grade appropriate for the ambient temperatures expected during the period of time until the next ...

Page 9 - BATTERY CABLES; STARTER SWITCH; WIRING

17 18 BATTERY CABLES Installation STARTER SWITCH A customer supplied starter switch or key switch is recom-mended for the starter motor. See table below for switch cable recommendations. WIRE GAUGE CABLE LENGTH CABLE DIA. AWG (BS) BWG SAE JIS Less than 1.5 m (4.5ft) 1.5mm (1/16in) 14 16 AV1.25 1.5-3...

Page 10 - Wiring Diagram; POWER TRANSMISSION; Belt Drive; Flex Coupling

19 20 ENGINE WIRING DIAGRAM (6 PIN)Engine Speci fi cation Numbers: EH650DB2332 EH650DB2341 EH650DB2390 ENGINE WIRING DIAGRAM (4 PIN)Engine Speci fi cation Number: EH650DB2332 Wiring Diagram POWER TRANSMISSION Belt Drive If using a belt drive application, consider the following notes: • V-belts are p...

Page 11 - Operation; EXHAUST GAS IS DEADLY!

22 21 Operation EXHAUST GAS IS DEADLY! Exhaust gases contain carbon monoxide, an odorless and color-less gas. Carbon monoxide is poisonous and can cause uncon-sciousness and death. Symptoms of carbon monoxide poisoning include: • Dizziness • Throbbing in Temples • Nausea • Muscular Twitching • Heada...

Page 12 - STOPPING; Maintenance; OPERATING IN DUSTY CONDITIONS; HOT AND COLD WEATHER PRECAUTIONS; Cold Weather

23 24 In colder weather, the engine will take longer to begin running smoothly with the choke open. Do not operate the equipment until the choke is fully open. STOPPING To stop the engine turn the switch to the STOP position. ENGINE BREAK-IN For top engine performance, new or rebuilt engines require...

Page 13 - RETURNING THE ENGINE TO SERVICE

25 26 ! WARNING EXHAUST GAS IS DEADLY! Never operate engine-powered equipment indoors without a proper exhaust system, ample fresh air ventilation and an operable carbon monoxide detector. 2. Use fresh gasoline and fi ll the fuel tank after each day’s use to reduce problems with moisture condensatio...

Page 14 - Periodic Maintenance

27 28 Periodic Maintenance MAINTENANCE, REPLACEMENT, OR REPAIR OF THE EMISSION CONTROL DEVICES AND SYSTEMS MAY BE PERFORMED BY NON-ROAD ENGINE REPAIR ESTABLISHMENTS OR INDIVIDUALS. Periodic maintenance is essential for top engine performance. See the Table below as a guide for normal periodic mainte...

Page 15 - CHANGING OIL AND FILTER

Crankcase pressure can blow hot engine oil out the fi ll tube causing severe burns. Always stop the engine before removing the oil fi ll cap. If the engine is equipped with the long oil fi ll tube, turn the oil fi ll cap counterclockwise and lift it up. Wipe the dip stick clean, push it back into th...

Page 17 - Adjustments; speed control solenoid; Governor and Speed Control Assembly

33 34 ! WARNING ! WARNING SPARK PLUG MAINTENANCE AND REPLACEMENT Refer to the Speci fi cations for spark plug type and gap speci fi cations. Check and clean spark plugs every 200 hours. Replace plugs every 500 hours. To prevent cross threading the spark plug, always thread it in by hand until it sea...

Page 18 - Engine speed adjustment must be attempted only by a quali

Troubleshooting The table below provides basic troubleshooting guidance. If you fail to resolve the problem after taking the corrective actions suggested, contact the equipment manufacturer or a Robin Subaru dealer. Many troubleshooting procedures present hazards that can result in severe personal i...

Page 19 - Engine Support Material; IMPORTANT INFORMATION FOR CALIFORNIA ENGINE USERS; cations or replacement of fuel, exhaust, air intake, or speed; TABLE 1-1 EMISSION CONTROL INFORMATION

37 38 Robin America has established the Robin Subaru Ful fi llment Center to take and ship orders to anyone wanting Robin Subaru reference material. This allows for the prompt ful fi llment of Robin Subaru part and service manuals, counter catalogs, price books and other support material to dealers ...

Page 20 - FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY

FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY EMISSIONS COMPONENT DEFECT WARRANTY COVERAGE - This emission warranty is applic-able in all States, except the State of California Fuji Heavy Industries Ltd. and Robin America Inc., Wood Dale Illinois, (herein "ROBIN AMERICA")warrant(s) to the init...

Page 24 - INDUSTRIAL PRODUCTS DIVISION; Robin Distribution Method; How to Select a Robin Service Dealer

INDUSTRIAL PRODUCTS DIVISION 4-410 Asahi, Kitamoto-shi Saitama, 364-8511, Japan Phone +81(48) 593-7798 Fax +81(48) 593-7946 Web site http://www.fhi.co.jp/robin/ / 940 Lively Blvd. Wood Dale, IL 60191 U.S.A. Phone: 630-350-8200 Fax: 630-350-8212 Website: http://www.robinsubaru.com 47 48 Robin Distrib...