Pride Mobility SC4001 - Manuals

Pride Mobility SC4001 – Manual in PDF format online.

Manuals:

Manual

Manual Pride Mobility SC4001

Summary

Page 2 - Please fill out the following information for quick reference:; S A F E T Y G U I D E L I N E S; INTENDED USE

WARNING! An authorized Pride Provider or qualified technician must perform the initial setup of this scooter and must perform all of the procedures in this manual. The symbols below are used throughout this owner's manual and on the scooter to identify warnings andimportant information. It is very i...

Page 3 - C O N T E N T S

3 Celebrity X www.pridemobility.com C O N T E N T S I. INTRODUCTION ......................................................................................................................... 4 II. SAFETY ....................................................................................................

Page 4 - I . I N T R O D U C T I O N; SAFETY; safety; , comfort, and styling in mind. We are confident the design features; safely; PURCHASER’S AGREEMENT

4 www.pridemobility.com Celebrity X I . I N T R O D U C T I O N SAFETY WELCOME to Pride Mobility Products Corporation (Pride). The product you have purchased combinesstate-of the-art components with safety , comfort, and styling in mind. We are confident the design features will provide you with the...

Page 9 - MODIFICATIONS

9 Celebrity X www.pridemobility.com GENERAL MANDATORY! Do not operate your new scooter for the first time without completely reading and understanding this owner’s manual. Your scooter is a state-of-the-art life-enhancement device designed to increase mobility. Pride provides anextensive variety of ...

Page 10 - Perform the following inspections prior to using your scooter:; on each tire if equipped with pneumatic tires.; WEIGHT LIMITATIONS

10 www.pridemobility.com Celebrity X I I . S A F E T Y Perform the following inspections prior to using your scooter: Check for proper tire inflation. Maintain but do not exceed the psi/bar/kPa air pressure rating indicated on each tire if equipped with pneumatic tires. Check all electrical connecti...

Page 12 - CORNERING INFORMATION; BRAKING INFORMATION

12 www.pridemobility.com Celebrity X I I . S A F E T Y Figure 2. Increased Stability Driving Position Figure 1. Normal Driving Position When you approach an incline, it is best to lean forward. See figures 1 and 2. This shifts the center ofgravity of you and your scooter toward the front of the scoo...

Page 14 - FREEWHEEL MODE; STAIRS AND ESCALATORS; DOORS

14 www.pridemobility.com Celebrity X INCLEMENT WEATHER PRECAUTIONS Exposure of your scooter to inclement weather conditions should be avoided whenever possible. If sud-denly caught up in rain, snow, severe cold or heat while operating your scooter, proceed to shelter at theearliest opportunity. Thor...

Page 15 - BATTERIES; BATTERY DISPOSAL AND RECYCLING

15 Celebrity X www.pridemobility.com I I . S A F E T Y ELEVATORS Modern elevators have a door edge safety mechanism that, when pushed, reopens the door(s). If you are in the doorway of an elevator when the door(s) begin to close, push on the rubber door edge or allow the rubber door edge to contact ...

Page 16 - GETTING ONTO AND OFF OF YOUR SCOOTER; REACHING AND BENDING

16 www.pridemobility.com Celebrity X I I . S A F E T Y MOTOR VEHICLE TRANSPORT Pride recommends that you do not remain seated in your scooter while traveling in a motor vehicle. The scooter should be stowed in the trunk of a car or in the back of a truck or van with batteries removed and properly se...

Page 19 - I I I . Y O U R S C O O T E R; TILLER CONSOLE; Horn Buttons

19 Celebrity X www.pridemobility.com I I I . Y O U R S C O O T E R TILLER CONSOLE The tiller console houses all of the controls needed to drive your scooter, including the speed adjustment dial,throttle control lever, battery condition meter, lights switch, status LED, and horn buttons. See figure 5...

Page 20 - Lights Switch; To Move Forward use either of the following:; Speed Adjustment Dial

20 www.pridemobility.com Celebrity X I I I . Y O U R S C O O T E R Lights Switch This switch controls your scooter’s lights. Toggle the switch forward to turn on your scooter’s front top light and running lights.Toggle the switch to the middle to turn off the scooter’s lights.Toggle the switch rearw...

Page 21 - REAR SECTION; Batteries

21 Celebrity X www.pridemobility.com I I I . Y O U R S C O O T E R Figure 7. Tiller Console Fuses SPARE RUNNING LIGHTSLOWER HEAD LIGHT RIGHT TURN SIGNAL LEFT TURN SIGNAL Figure 8. Rear Section BATTERY BATTERY MANUAL FREEWHEEL LEVER ANTI-TIP WHEELS MOTOR/TRANSAXLE ASSEMBLY REAR SECTION The batteries,...

Page 22 - Safety Flag Bracket; To install the safelty flag:; Manual Freewheel Lever

22 www.pridemobility.com Celebrity X I I I . Y O U R S C O O T E R Figure 9. Main Circuit Breaker (Reset Button) MAIN CIRCUIT BREAKER (RESET BUTTON) Figure 8A. Safety Flag Bracket HEX KEY SETSCREW CAP Safety Flag Bracket An accessory bracket for installing an optionalsafety flag is mounted near each...

Page 23 - key is turned to the “off” position, then back to the “on” position.

23 Celebrity X www.pridemobility.com I I I . Y O U R S C O O T E R Figure 10A. Front Securement Points Figure 10. Rear Securement Points SECUREMENT POINTS SECUREMENT POINTS NOTE: If the scooter is placed in freewheel mode (manual freewheel lever forward) while the key is in the “on” position, the sc...

Page 24 - I V . B A T T E R I E S A N D C H A R G I N G; BATTERIES AND CHARGING

24 www.pridemobility.com Celebrity X CHARGING YOUR BATTERIES PROHIBITED! Never use an extension cord to plug in your battery charger. Plug the charger directly into a properly wired standard electrical outlet. PROHIBITED! Removal of the grounding prong can create an electrical hazard. If necessary, ...

Page 25 - How does the charger work?; Follow these easy steps to charge your batteries

25 Celebrity X www.pridemobility.com NOTE: The LED lights on the charger indicate different charger conditions at various times: charger power on, charging in progress, and charging complete. Refer to the manual supplied with the charger for a complete explanation of these indicators. NOTE: There is...

Page 26 - How often must I charge the batteries?; NOTE: Sealed batteries are not serviceable. Do not remove the caps.

26 www.pridemobility.com Celebrity X I V . B A T T E R I E S A N D C H A R G I N G How often must I charge the batteries? Two major factors must be considered when deciding how often to charge your scooter’s batteries: All day scooter use on a daily basis. Infrequent or sporadic scooter use. With th...

Page 27 - How do I change a battery in my scooter?; Disconnect the battery cables from the battery terminals.; making sure the strap is positioned over

27 Celebrity X www.pridemobility.com How do I change a battery in my scooter? MANDATORY! Battery posts, terminals, and related accessories contain lead and lead compounds. Wear goggles and gloves when handling batteries and wash hands after handling. WARNING! Always use two batteries of the exact sa...

Page 28 - What about public transportation?; Why do my new batteries seem weak?

28 www.pridemobility.com Celebrity X Follow these steps to properly break in your scooter’s new batteries for maximum efficiency and service life: 1. Fully recharge any new battery prior to its initial use. This charging cycle brings the battery up to about 88% of its peak performance level. 2. Oper...

Page 29 - V . O P E R A T I O N; BEFORE GETTING ONTO YOUR SCOOTER; PRE-RIDE ADJUSTMENTS AND CHECKS

29 Celebrity X www.pridemobility.com V . O P E R A T I O N BEFORE GETTING ONTO YOUR SCOOTER Have you fully charged the batteries? See IV. “Batteries and Charging.” Is the manual freewheel lever in the drive (rearward) position? Never leave the manual freewheel lever pushed forward unless you are man...

Page 30 - GETTING OFF YOUR SCOOTER

30 www.pridemobility.com Celebrity X V . O P E R A T I O N NOTE: Your scooter’s reverse speed is slower than that of the forward speed you preset with the speed adjustment dial. GETTING OFF YOUR SCOOTER 1. Bring your scooter to a complete stop. 2. Remove the key from the key switch. 3. Disengage the...

Page 31 - NOTE: In order to fully lower the tiller, you must first; V I . C O M F O R T A D J U S T M E N T S

31 Celebrity X www.pridemobility.com TILLER ANGLE ADJUSTMENT WARNING! Remove the key from the key switch before adjusting the tiller or the seat. Never attempt to adjust the tiller or the seat while the scooter is in motion. Your scooter is equipped with an adjustable pivoting tiller.1. While suppor...

Page 32 - SEAT HEIGHT ADJUSTMENT; To adjust the mirror:

32 www.pridemobility.com Celebrity X V I . C O M F O R T A D J U S T M E N T S Figure 17. Seat Height Adjustment SEAT HEIGHT ADJUSTMENT The seat can be repositioned to different heights. Seefigure 17.1. Remove the seat and rear shroud from your scooter. See VII. “Disassembly and Assembly.” 2. Loosen...

Page 33 - To adjust the positioning belt for operator comfort:

33 Celebrity X www.pridemobility.com V I . C O M F O R T A D J U S T M E N T S Figure 19. Positioning Belt POSITIONING BELT (OPTIONAL) Your scooter seat may be equipped with an auto-type posi-tioning belt that can be adjusted for operator comfort. Seefigure 19. The positioning belt is designed to he...

Page 34 - is set to the slowest setting.; To operate the power seat:; Press and hold the upper part of the power seat switch (; see figure 4; again before proceeding.

34 www.pridemobility.com Celebrity X POWER SEAT ADJUSTMENT Your scooter may be equipped with a power seat. The power seat actuator is designed to raise or lower theseat with minimal effort on the part of the operator. The power seat switch is located on the tiller console. WARNING! The power seat is...

Page 35 - V I I . D I S A S S E M B L Y A N D A S S E M B L Y; DISASSEMBLY; Place the scooter in drive mode by engaging the freewheel lever.

35 Celebrity X www.pridemobility.com V I I . D I S A S S E M B L Y A N D A S S E M B L Y DISASSEMBLY You can disassemble the scooter into seven pieces:the seat, the front section, the rear section, the rearshroud, the basket, and the batteries. See figure 20.No tools are required to disassemble or a...

Page 36 - Frame Separation

36 www.pridemobility.com Celebrity X UPPER FRAME TUBE LOWER FRAME TUBE FRONT-TO -REAR HARNESS REAR LIGHTING HARNESS FRAME HOOK FRAME RELEASE LEVER FRAME LOCK V I I . D I S A S S E M B L Y A N D A S S E M B L Y Figure 22. Harness Connections Figure 23. Frame Release Figure 24. Frame Separation FRAME ...

Page 37 - V I I I . B A S I C T R O U B L E S H O O T I N G; DIAGNOSTIC FAULT CODES; What if all the systems on my scooter seem to be “dead”?; Make certain that the key is in the “on” position.; FAULT CODE; Battery charge is low.

37 Celebrity X www.pridemobility.com V I I I . B A S I C T R O U B L E S H O O T I N G Any electromechanical device occasionally requires some troubleshooting. However, most of the prob- lems that may arise can usually be solved with a bit of thought and common sense. Many of these problems occur be...

Page 38 - What if the main circuit breaker repeatedly trips?; scooter’s battery type.; the throttle control lever?; Have your authorized Pride Provider load test each battery.

38 www.pridemobility.com Celebrity X What if my scooter does not move when I engage the throttle control lever? When the manual freewheel lever is pushed forward, the brakes are disengaged and all power to the motor/transaxle assembly is cut. Push rearward on the manual freewheel lever, turn the sco...

Page 39 - Avoid using products that may scratch the surface of your scooter.; I X . C A R E A N D M A I N T E N A N C E

39 Celebrity X www.pridemobility.com Your scooter requires a minimal amount of care and maintenance. If you do not feel confident in yourability to perform the maintenance listed below, you may schedule inspection and maintenance at yourauthorized Pride Provider. The following areas require periodic...

Page 40 - WHEEL REPLACEMENT; Follow these easy steps for a quick and safe repair

40 www.pridemobility.com Celebrity X I X . C A R E A N D M A I N T E N A N C E WHEEL REPLACEMENT If your scooter is equipped with pneumatic tires and you have a flat tire, you can have the tube replaced. If your scooter is equipped with a solid tire insert, either the solid insert or the entire whee...

Page 41 - WIRING HARNESSES; To replace a fuse

41 Celebrity X www.pridemobility.com I X . C A R E A N D M A I N T E N A N C E Figure 26. Working Fuse Figure 26A. Blown Fuse (Replace) WIRING HARNESSES Regularly check all wiring connections. Regularly check all wiring insulation, including the charger power cord, for wear or damage. Have your auth...

Page 42 - STORING YOUR SCOOTER

42 www.pridemobility.com Celebrity X I X . C A R E A N D M A I N T E N A N C E STORING YOUR SCOOTER If you plan on not using your scooter for an extended period of time, it is best to:1. Fully charge its batteries prior to storage. 2. Disconnect the batteries from the scooter. 3. Store your scooter ...

Page 43 - A P P E N D I X I - S P E C I F I C A T I O N S; Battery weight may vary based on battery manufacturer.

43 Celebrity X www.pridemobility.com Model Numbers 3-wheel: SC4001, 4-wheel: SC4401 Maximum Allowable Incline 6° (10.5%) Maximum Obstacle Climbing Ability 2 in. (5 cm) Overall Length 3 3-wheel: 46 in. (116.84 cm), 4-wheel: 46.75 in (118.75 cm) Overall Width 3 24 in. (61 cm) Total Weight Without Batt...

Page 44 - A P P E N D I X I - S P E C I F I C A T I O N S

44 www.pridemobility.com Celebrity X A P P E N D I X I - S P E C I F I C A T I O N S Figure 27. Scooter Dimensions 18 in. (45.72 cm) (45.72 cm) 24 in. (61 cm) 3-Wheel: 46 in. (116.84 cm) 4-Wheel: 46.75 in. (118.75 cm) 54 in. (137.16 cm) 41.5 in. (105.41 cm) 3-Wheel Turning Radius 4- Wheel Turning Ra...

Page 45 - N O T E S

Page 48 - CELEBRITY X