Pride Mobility Jazzy 600 XL - Manuals

Jazzy 600 XL www.pridemobility.com 5 I . I N T R O D U C T I O N PRIDE OWNERS CLUB As an owner of a Pride product, you are invited to register your product’s warranty and enroll in the Pride Owners Club.You may do so by filling out and returning your enclosed product registration card or by visiting...

6 www.pridemobility.com Jazzy 600 XL I I . S A F E T Y Corrosive chemicals contained in battery. Use only AGM or Gel-Cell batteries to reduce the risk of leakage or explosive conditions. EMI-RFI - This product has been tested and passed at an immunity level of 20 V/m. Read and follow the information...

8 www.pridemobility.com Jazzy 600 XL I I . S A F E T Y SAFETY MANDATORY! Do not operate your new power chair for the first time without completely reading and understanding this owner’s manual. Your power chair is a state-of-the-art life-enhancement device designed to increase mobility. Pride provid...

Jazzy 600 XL www.pridemobility.com 9 I I . S A F E T Y Weight Limitations Your power chair is rated for a maximum weight capacity. Please refer to the specifications table for this limit. WARNING! Exceeding the weight capacity voids your warranty and may result in personal injury and/or damage to yo...

10 www.pridemobility.com Jazzy 600 XL I I . S A F E T Y Figure 1. Maximum Safe Slope (Ascending and Descending) WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines or any other ...

Jazzy 600 XL www.pridemobility.com 11 I I . S A F E T Y Freewheel Mode Your power chair is equipped with two manual freewheel levers to allow for manual maneuverability by a trained attendant.For more information about how to place your power chair into and out of freewheel mode, see III. “Your Powe...

12 www.pridemobility.com Jazzy 600 XL I I . S A F E T Y Transfers Transferring onto and off of your power chair requires agood sense of balance. Always have an attendant or health-care professional present while learning to properly trans-fer yourself. To eliminate the possibility of injury, Pride r...

Jazzy 600 XL www.pridemobility.com 13 I I . S A F E T Y Inclement Weather Precautions Exposure of your power chair to inclement weather conditions should be avoided whenever possible. If suddenly caughtup in rain, snow, severe cold or heat while operating your power chair proceed to shelter at the e...

Jazzy 600 XL www.pridemobility.com 15 I I I . Y O U R P O W E R C H A I R THE JAZZY 600 XL The Jazzy 600 XL has two main assemblies: the seat assembly and the power base assembly. See figure 5. Typically, theseat assembly includes the armrests, seatback, and seat base. The power base assembly includ...

Jazzy 600 XL www.pridemobility.com 17 I I I . Y O U R P O W E R C H A I R ELECTRICAL COMPONENTS The electrical components are located inside the power base. The ammeter and the charger power cord receptacle arelocated on the right side of the power base. The main circuit breaker is located on the fr...

18 www.pridemobility.com Jazzy 600 XL I I I . Y O U R P O W E R C H A I R Battery Connector: This is where the controller connects to the batteries. Controller Connector (FLIGHT Only): This is where the controller connects to the power module. Main Circuit Breaker: The main circuit breaker is a safe...

Jazzy 600 XL www.pridemobility.com 19 MANUAL FREEWHEEL LEVERS The Jazzy 600 XL has a manual freewheel lever on each motor. Manual freewheel levers enable you to disengage the drivemotors from the gearboxes and maneuver the chair manually. WARNING! Do not use the power chair while the drive motors ar...

20 www.pridemobility.com Jazzy 600 XL INITIAL ASSEMBLY Your power chair may require some assembly either before initial use or after transportation. It may also require disassemblyto make some comfort adjustments. Figure 10 details those parts of the power chair that are designed to be disassembled ...

Jazzy 600 XL www.pridemobility.com 21 I V . A S S E M B L Y SEAT INSTALLATION It may be necessary to install the seat either prior to initialoperation or after transporting your power chair. Most seatsare attached to the power base with the Universal Mount-ing System (UMS). The UMS consists of unive...

22 www.pridemobility.com Jazzy 600 XL V . C O M F O R T A D J U S T M E N T S COMFORT ADJUSTMENTS After becoming familiar with your power chair’s operation, you may find the need to make some adjustments to increaseyour comfort, such as seat height and angle, armrest angle, foot platform height and ...

Jazzy 600 XL www.pridemobility.com 23 ARMREST KNOB JAM NUTS ARMRESTANGLEADJUSTINGSCREW Figure 16. Seatback Angle Adjustment Figure 15. Seat Position Adjustment V . C O M F O R T A D J U S T M E N T S 12. Reinstall each screw into the trapeze bars and tighten.13. Reinstall the seat.14. Reconnect the ...

24 www.pridemobility.com Jazzy 600 XL Armrest Width Adjustment You can change each armrest’s width independently of the other. NOTE: Changing the armrest width may increase theoverall width of your power chair. To change the armrest width:1. Locate the two armrest knobs on each side of the armrest r...

Jazzy 600 XL www.pridemobility.com 25 V . C O M F O R T A D J U S T M E N T S two states: clamped and unclamped. When the lever is open,the quick release fastener is unclamped. When the lever isclosed, the quick release fastener is clamped. To clamp the quick release fastener:1. Make sure the lever ...

26 www.pridemobility.com Jazzy 600 XL V . C O M F O R T A D J U S T M E N T S Swing-away Footrests Swing-away Footrests (SFRs) enable you to rotate the foot-rests to the side before you transfer onto or off or your powerchair. See figure 20. To rotate the SFRs:1. Push in the release lever.2. Rotate ...

Jazzy 600 XL www.pridemobility.com 27 Multi-Axis Foot Plates The multi-axis foot plate assembly can be installed on eithera swing-away footrest or an elevating leg rest. The multi-axis foot plate has four adjustments: leg rest length (A), po-sition (B), tilt (C), and angle (D). See figure 23. To cha...

28 www.pridemobility.com Jazzy 600 XL V I . B A T T E R I E S A N D C H A R G I N G BATTERIES AND CHARGING The Jazzy 600 XL uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free.Since they are sealed, there is no need to check the electrolyte (fluid) l...

Jazzy 600 XL www.pridemobility.com 29 V I . B A T T E R I E S A N D C H A R G I N G NOTE: If it is a Pride off-board charger, then there are two lights in it. The red light indicates that power tothe off-board charger is on. The green light indicates that the batteries are fully charged. If it is no...

30 www.pridemobility.com Jazzy 600 XL V I . B A T T E R I E S A N D C H A R G I N G NOTE: Keep your batteries fully charged and avoid deeply discharging your batteries. Do not charge thebatteries for more than 24 hours at a charging cycle. How can I get maximum range or distance per charge?Rarely do...

32 www.pridemobility.com Jazzy 600 XL Figure 24. FLIGHT Controller 2 3 4 5 1 V I I . O P E R A T I O N FLIGHT CONTROLLER The electronic controller is what you use to operate your power chair. It takes the battery voltage and sends it to theappropriate system. The electronic controller enables you to...

Jazzy 600 XL www.pridemobility.com 33 Figure 25. FLIGHT Controller Keypad V I I . O P E R A T I O N On/Off Key The on/off key turns the FLIGHT on and off. WARNING! Unless faced with an emergency situation, do not use the on/off key to stop the chair. This will cause the power chair to stop abruptly....

34 www.pridemobility.com Jazzy 600 XL V I I . O P E R A T I O N Speed Keys There are two keys that control the speed. Press the hare key to increase the speed. Press the tortoise key to decrease thespeed. The speed setting is displayed on the speed indicator. If your power chair was programmed with ...

Jazzy 600 XL www.pridemobility.com 35 V I I I . C A R E A N D M A I N T E N A N C E CARE AND MAINTENANCE Your Jazzy 600 XL is a sophisticated power chair. Like any motorized vehicle, it requires routine maintenance checks. Youcan perform some of these checks, but others require assistance from your ...

36 www.pridemobility.com Jazzy 600 XL V I I I . C A R E A N D M A I N T E N A N C E ! Check all electrical connections. Make sure they are tight and are not corroded. Batteries must sit flat within the batterytray, with the battery terminals facing inward, toward each other. Refer to the battery wir...

Jazzy 600 XL www.pridemobility.com 37 V I I I . C A R E A N D M A I N T E N A N C E WARNING! If you fail to store the unit properly, the frame can rust and the electronics can be damaged. Cleaning Instructions WARNING! Never hose off your power chair or place it in direct contact with water. Your po...

38 www.pridemobility.com Jazzy 600 XL V I I I . C A R E A N D M A I N T E N A N C E Battery Replacement A battery wiring diagram is printed on a decal located on the front battery tray. See VI. “Batteries and Charging” forcorrect battery specifications. WARNING! Prevent injury. Do not replace batter...

Jazzy 600 XL www.pridemobility.com 39 BATTERY WIRING DIAGRAM LABEL V I I I . C A R E A N D M A I N T E N A N C E Figure 28. Battery Installation REAR SHROUD FASTENERS REAR SHROUD FRONT BATTERY REAR BATTERY DWR1234L804 REV 50

40 www.pridemobility.com Jazzy 600 XL V I I I . C A R E A N D M A I N T E N A N C E When to See Your Authorized Pride Provider for Service The following symptoms could indicate a serious problem with your power chair. If necessary, contact your authorizedPride Provider. When calling, have the model ...

Jazzy 600 XL www.pridemobility.com 41 I X . W A R R A N T Y LIFETIME LIMITED WARRANTY For the lifetime of your power chair from the date of purchase, Pride will repair or replace at our option to the originalpurchaser, free of charge, any of the following parts found upon examination by an authorize...

42 www.pridemobility.com Jazzy 600 XL I X . W A R R A N T Y RECONDITIONED UNITS WARRANTY All reconditioned units are covered by a six-month warranty from Pride effective from the date of purchase. WARRANTY EXCLUSIONS This warranty does not extend to those items which may require replacement due to n...

Q u a l i t y C o n t r o l - M o d e l 1 400 Quality Control - Jazzy 600 XL Thank you for making the Jazzy 600XL your choice in power chairs. We have thoroughly inspected your power chair. The following checkmarks indicate that it hasbeen test driven and inspected. Fit and Finish Performance Inclus...