Pride Mobility 614 2S - Manuals

Jazzy 614 Series www.pridemobility.com 5 I I . S A F E T Y PRODUCT SAFETY SYMBOLS The symbols below are used on the power chair to identify warnings, mandatory actions, and prohibited actions. It is veryimportant for you to read and understand them completely. Read and follow the information in the ...

Jazzy 614 Series www.pridemobility.com 9 I I . S A F E T Y GENERAL GUIDELINES MANDATORY! Do not operate your new power chair for the first time without completely reading and understanding this owner’s manual. Your power chair is a state-of-the-art life-enhancement device designed to increase mobili...

10 www.pridemobility.com Jazzy 614 Series I I . S A F E T Y Weight Limitations Your power chair is rated for a maximum weight capacity. Please refer to the specifications table for this limit. MANDATORY! Stay within the specified weight capacity of your power chair. Exceeding the weight capacity voi...

Jazzy 614 Series www.pridemobility.com 11 I I . S A F E T Y Figure 1. Maximum Safe Slope (Ascending and Descending) 6 (10.5%) WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines...

12 www.pridemobility.com Jazzy 614 Series I I . S A F E T Y Public Streets and Roadways WARNING! You should not operate your power chair on public streets and roadways. Be aware that it may be difficult for traffic to see you when you are seated on your power chair. Obey all local pedestrian traffic...

Jazzy 614 Series www.pridemobility.com 13 I I . S A F E T Y WARNING! Do not attempt to have your power chair climb or descend an obstacle that is higher than 2 in. (5 cm) unless you have the assistance of an attendant. WARNING! Do not attempt to have your power chair proceed backward down any step, ...

14 www.pridemobility.com Jazzy 614 Series I I . S A F E T Y Batteries In addition to following the warnings below, be sure to comply with all other battery handling information. For moreinformation about your power chair’s batteries, see VI. “Batteries and Charging.” MANDATORY! Battery posts, termin...

Jazzy 614 Series www.pridemobility.com 15 I I . S A F E T Y Figure 4. Ideal Transfer Position Transfers Transferring onto and off of your power chair requires agood sense of balance. Always have an attendant or health-care professional present while learning to properly transferyourself. To eliminat...

Jazzy 614 Series www.pridemobility.com 17 I I I . Y O U R P O W E R C H A I R THE JAZZY 614 SERIES Your power chair has two main assemblies: the seat assembly and the power base assembly. See figure 5. Typically, theseat assembly includes the armrests, seatback, and seat base. The power base assembl...

18 www.pridemobility.com Jazzy 614 Series Figure 6. The Jazzy 614 Series Power Base TRAPEZE BARS FRONT COVER I I I . Y O U R P O W E R C H A I R ELECTRICAL COMPONENTS The electrical components are located on or inside the power base. The main circuit breaker is located on the front of thepower base....

Jazzy 614 Series www.pridemobility.com 19 REAR SHROUD REMOVAL FRONT SHROUD REMOVAL I I I . Y O U R P O W E R C H A I R Main Circuit Breaker: The main circuit breaker is a safety feature built into your power chair. When the batteries and the motors are heavily strained (e.g., from excessive loads), ...

20 www.pridemobility.com Jazzy 614 Series Manual Freewheel Levers Your power chair has a manual freewheel lever on each motor. Manual freewheel levers enable you to disengage the drivemotors from the gearboxes and maneuver the chair manually. WARNING! Do not use the power chair while the drive motor...

Jazzy 614 Series www.pridemobility.com 21 INITIAL ASSEMBLY Your power chair may require some assembly either before initial use or after transportation. It may also require disassemblyto make some comfort adjustments. Figure 10 details those parts of the power chair that are designed to be disassemb...

22 www.pridemobility.com Jazzy 614 Series I V . A S S E M B L Y Seat Installation It may be necessary to install the seat either prior to initialoperation or after transporting your power chair. Most seatsare attached to the power base with the Universal MountingSystem (UMS). The UMS consists of uni...

Jazzy 614 Series www.pridemobility.com 23 V . C O M F O R T A D J U S T M E N T S COMFORT ADJUSTMENTS After becoming familiar with your power chair’s operation, you may find the need to make some adjustments to increaseyour comfort, such as seat height and angle, armrest angle, foot platform height ...

24 www.pridemobility.com Jazzy 614 Series V . C O M F O R T A D J U S T M E N T S 10. Reinstall the retaining clips from step 9.11. Remove each screw from the trapeze bars and apply thread lock. 12. Reinstall each screw into the trapeze bars and tighten.13. Tighten the setscrew in each seat tower. S...

Jazzy 614 Series www.pridemobility.com 25 Seatback Angle Adjustment If your power chair is equipped with an adjustable seatback,you can adjust it to four (4) different angles: 90°, 102°,105°, or 107°. To adjust the seatback angle: 1. Remove the adjusting screws from each seat hinge. See figure 15. 2...

26 www.pridemobility.com Jazzy 614 Series V . C O M F O R T A D J U S T M E N T S Controller Position You can move the controller in toward or out away from thearmrest, or change the position of the controller for either left-hand or right-hand use. WARNING! Do not place the controller cable so that...

Jazzy 614 Series www.pridemobility.com 27 V . C O M F O R T A D J U S T M E N T S Foot Platform Depth Adjustment To adjust the foot platform depth: 1. Remove the hardware from the foot platform bracket. See figure 17. 2. Move the foot platform in or out to the desired depth.3. Reinstall the hardware...

28 www.pridemobility.com Jazzy 614 Series V I . B A T T E R I E S A N D C H A R G I N G BATTERIES AND CHARGING Your power chair uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free.Since they are sealed, there is no need to check the electrolyte (flui...

Jazzy 614 Series www.pridemobility.com 29 V I . B A T T E R I E S A N D C H A R G I N G To charge the batteries using the off-board charger: 1. Position the front of your power chair next to a standard electrical outlet. 2. Be certain the controller power is turned off.3. Plug the off-board charger ...

30 www.pridemobility.com Jazzy 614 Series V I . B A T T E R I E S A N D C H A R G I N G How often must I charge the batteries? Many factors come into play when deciding how often to charge the batteries. You may use your power chair all day on adaily basis or you may not use it for weeks at a time. ...

32 www.pridemobility.com Jazzy 614 Series V I I . C A R E A N D M A I N T E N A N C E CARE AND MAINTENANCE Your Jazzy 614 Series is a sophisticated power chair. Like any motorized vehicle, it requires routine maintenance checks. You canperform some of these checks, but others require assistance from...

Jazzy 614 Series www.pridemobility.com 33 V I I . C A R E A N D M A I N T E N A N C E ! The body shroud has been sprayed with a clear sealant coating. You can apply a light coat of car wax to help it retainits high-gloss appearance. ! Check all electrical connections. Make sure they are tight and ar...

34 www.pridemobility.com Jazzy 614 Series V I I . C A R E A N D M A I N T E N A N C E Storage Your power chair should be stored in a dry place, free from temperature extremes. When storing, disconnect the batteriesfrom the power chair. See VI. “Batteries and Charging.” WARNING! If you fail to store ...

Jazzy 614 Series www.pridemobility.com 35 V I I . C A R E A N D M A I N T E N A N C E Figure 21. Jazzy 614 Series Drive Wheel Disassembled Figure 20. Jazzy 614 Series Drive Wheel DRIVE WHEEL NUT DRIVE WHEEL WASHER AXLE SLOT AXLE KEY TIRE SCREWS REAR RIM HALF TUBE FRONT RIM HALF F ollow these easy st...

36 www.pridemobility.com Jazzy 614 Series V I I . C A R E A N D M A I N T E N A N C E Figure 22. Battery Installation REAR SHROUD REAR BATTERY FRONT BATTERY BATTERYSTRAP PULL POINTSFOR REARSHROUDREMOVAL DISCONNECTRELEASE BUTTON BATTERY WIRING DIAGRAM

Jazzy 614 Series www.pridemobility.com 37 V I I . C A R E A N D M A I N T E N A N C E To replace the batteries: 1. Turn off the power to the controller.2. Make sure that the power chair is in drive mode. See III. “Your Power Chair.”3. Pull to remove the rear shroud. See figure 22.4. Push down on the...

38 www.pridemobility.com Jazzy 614 Series V I I I . W A R R A N T Y FIVE-YEAR LIMITED WARRANTY For five (5) years from the date of purchase, Pride will repair or replace at our option to the original purchaser, free ofcharge, any of the following parts found upon examination by an authorized represe...

Jazzy 614 Series www.pridemobility.com 39 V I I I . W A R R A N T Y SERVICE CHECKS AND WARRANTY SERVICE Warranty service must be performed by an authorized Pride Provider. Do not return faulty parts to Pride without priorwritten authorization. All transportation costs and shipping damage incurred wh...

40 www.pridemobility.com Jazzy 614 Series A P P E N D I X I - S P E C I F I C A T I O N S ¹ Varies with base model, user weight, terrain type, battery amp hour rating (Ah), battery charge, battery condition, motors, controllertype, tire type, and tire condition. This specification can be subject to ...

42 www.pridemobility.com Jazzy 614 Series N O T E S

Pride keeps a more detailed report on file at the factory. Date Inspected Inspector Quality Control - Jazzy 614 Series Inclusion of all Parts Joystick Serial Number Controller Serial Number Left Motor Serial Number Right Motor Serial Number Fit and Finish Performance *INFMANU3677* Product Serial #