Poulan PRO 413420 - Manuals

5 CONTENTS OF HARDWARE PACK (2) Keys Slope Sheet Key (1) Oil Drain Tube Steering Wheel Steering Extension Shaft Steering Wheel Adapter Steering Boot Steering Extension Shaft (2) Keys Slope Sheet Key (1) Oil Drain Tube 3TEERING 7HEEL Steering Extension Shaft Steering Wheel Adapter Steering Boot Steer...

6 ASSEMBLY TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier. Stan dard wrench sizes are listed. (1) 1/2" wrench Utility knife (2) 3/4" wrench Tire pres sure gauge Pliers When right or left hand is mentioned in this man ual, it means when you are in the operating po s...

7 ASSEMBLY NOTE: You may now roll or drive your tractor off the skid. Follow the ap pro pri ate instruction below to remove the tractor from the skid. WARNING: Before start ing, read, un der stand and fol low all in struc tions in the Op er a tion section of this man u al. Be sure tractor is in a we...

8 ASSEMBLY CHECK TIRE PRESSURE The tires on your tractor were overinflated at the factory for shipping purposes. Correct tire pressure is important for best cutting performance.• Reduce tire pressure to PSI shown on tires. CHECK DECK LEVELNESS For best cutting results, mower housing should be proper...

9 OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean- ing. DANGER, KEEP HANDS AND FEET AWAY FREE WHEEL (Automatic Models only) OVER TEMP LIGHT KEEP AREA CLEAR SLOPE HAZARDS 15 15 (SEE SAFETY RULES SECTION) BATTERY REVERSE FO...

10 OPERATION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. ATTACHMENT CLUTCH LEVER - Used t...

11 NOTE: Under certain conditions when tractor is standing idle with the engine running, hot engine exhaust gases may cause “brown ing” of grass. To eliminate this possibility, al- ways stop engine when stopping tractor on grass areas. OPERATION The operation of any tractor can result in foreign obj...

13 OPERATION TO START ENGINE (See Fig. 5) When starting the engine for the first time or if the engine has run out of fuel, it will take extra cranking time to move fuel from the tank to the engine.• Sit on seat in operating position, depress clutch/brake pedal and set parking brake. • Place gear sh...

14 MOWING TIPS • Mower should be properly leveled for best mowing per- for mance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trim- ming. • Drive so that clippings are discharged onto the area that has b...

15 MAINTENANCE LUBRICATION CHART d SPINDLE ZERK d FRONT WHEEL BEARING ZERK c SAE 30 OR 10W30 MOTOR OIL d GENERAL PURPOSE GREASE e REFER TO MAINTENANCE “ENGINE” SECTION IMPORTANT: DO NOT OIL OR GREASE THE PIVOT POINTS WHICH HAVE SPECIAL NYLON BEARINGS. VISCOUS LU BRI CANTS WILL ATTRACT DUST AND DIRT ...

16 MAINTENANCE TO SHARPEN BLADE (See Fig. 11) NOTE: We do not recommend sharpening blade - but if you do, be sure the blade is balanced.Care should be taken to keep the blade balanced. An un- bal anced blade will cause excessive vibration and even tual dam age to mower and engine.• The blade can be ...

17 FIG. 11 BATTERY Your tractor has a battery charging system which is suf fi cient for normal use. However, periodic charging of the battery with an automotive charger will extend its life.• Keep battery and terminals clean.• Keep battery bolts tight.• Keep small vent holes open.• Recharge at 6-10 ...

18 MAINTENANCE CLEANING • Clean engine, battery, seat, finish, etc. of all foreign matter. • Keep finished surfaces and wheels free of all gasoline, oil, etc. • Protect painted surfaces with automotive type wax.We do not recommend using a garden hose or pressure washer to clean your tractor unless t...

19 SERVICE AND ADJUSTMENTS WARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUST- MENTS: • Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment clutch in “DISENGAGED” position. • Turn ignition key to “STOP...

21 SERVICE AND ADJUSTMENTS • If adjustment is necessary, see step in Visual Adjust- ment instructions above. • Recheck measurements, adjust if necessary until both sides are equal. FRONT-TO-BACK ADJUSTMENT (See Figs. 22 and 23) IMPORTANT: Deck must be level side-to-side. To obtain the best cutting r...

22 SERVICE AND ADJUSTMENTS TO REPLACE MOTION BELT DRIVE (See Fig. 25) Park the tractor on level surface. En gage parking brake. For as sis tance, there is a belt installation guide decal on bottom side of left footrest.BELT REMOVAL - • Remove mower (See “TO RE MOVE MOWER” in this section of manual)....

23 ADJUSTMENT BOLT NEUTRAL LOCK GATE GEARSHIFT LEVER FIG. 26 SERVICE AND ADJUSTMENTS TO ADJUST STEERING WHEEL ALIGN- MENT If steering wheel crossbars are not horizontal (left to right) when wheels are positioned straight forward, remove steer- ing wheel and reassemble per instructions in the Assembl...

25 STORAGE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the trac tor with gas o line in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before stori...

26 TROUBLESHOOTING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly. 2. See “TO START ENGINE” in Operation section. 3. Engine flooded. 3. Wait several minutes before attempting to start. 4. Bad spark plug. 4. Replace spark plug. 5. Dirty air filter. 5. Clean/r...

28 REPAIR PARTS TRACTOR - - MODEL NUMBER PB19542LT (96042003401), PRODUCT NO. 960 42 00-34 DECALS NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm KEY PART NO. NO. DESCRIPTION 6 2 1 5, 8 4 ,1 0 3 , 9 11 7 WHEELS AND TIRES KEY PART NO. NO. DESCRIPTION KEY PART NO. NO. DESCRIPTION ...

29 BATTERY FUSE AMMETER (OPTIONAL) RED RED RED RED WHITE BLACK BLUE BLACK BLACK BLACK/WHITE BLACK BLACK BLUE BLUE BROWN BLACK BLACK GRAY GRAY BLACK SOLENOID M A STARTER CLUTCH / BRAKE (PEDAL UP) SEAT SWITCH (NOT OCCUPIED) IGNITION UNIT HOUR METER FUELLINE FUEL SHUT-OFF SOLENOID HEADLIGHTS S M B G A1...

30 REPAIR PARTS TRACTOR - - MODEL NUMBER PB19542LT (96042003401), PRODUCT NO. 960 42 00-34 ELECTRICAL 30 33 34 22 79 21 41 42 26 43 27 40 71 16 87 25 T02S 90 28 55 With 12V Outlet Option 59 103 With Service Minder Option 46 46 94 92 29 93 2

31 REPAIR PARTS TRACTOR - - MODEL NUMBER PB19542LT (96042003401), PRODUCT NO. 960 42 00-34 ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 163465 Battery 2 74760412 Bolt Hex Hd 1/4-20 unc x 3/4 8 193228 Box Battery 16 176138 Switch Interlock 21 183759 Harness Socket Light 22 4152J Bulb, Light #1156 25 401...

32 37 181 181 194 194 36 36 236 183 152 159 2 159 230 230 180 162 196 68 222 159 chassis-tex_52-elite sv pro_r1 197 138 182 176 175 5 177 130 151 14 18 208 207 15 25 186 176 176 176 150 137 219 194 219 235 REPAIR PARTS TRACTOR - - MODEL NUMBER PB19542LT (96042003401), PRODUCT NO. 960 42 00-34 CHASSI...

34 REPAIR PARTS TRACTOR - - MODEL NUMBER PB19542LT (96042003401), PRODUCT NO. 960 42 00-34 DRIVE ª ª ª ª ª ª ª ª ª ª ª ª DRIVETEX?$?&ENDER?

38 6 55 5 13 13 53 8 9 8 7 62 50 50 70 65 68 69 67 54 67 66 54 65 15 15 14 14 61 55 2 steering-tex_15-lt 9 8 7 16 28 13 22 64 71 21 26 1 20 45 33 72 74 74 74 4 35 19 63 57 57 60 59 58 6 74 63 REPAIR PARTS TRACTOR - - MODEL NUMBER PB19542LT (96042003401), PRODUCT NO. 960 42 00-34 STEERING

40 REPAIR PARTS TRACTOR - - MODEL NUMBER PB19542LT (96042003401), PRODUCT NO. 960 42 00-34 MOWER DECK 113 30 42 43 60 38 63 46 147 55 64 47 192 56 56 57 62 188 189 1 69 21 69 69 20 40 145 42_D_man-Tex_LT_10_r3 21 21 24 25 26 27 29 23 189 188 144 36 113 113 40 57 19 19 6 6 68 30 30 32 38 195 122 123 ...

42 2 6 1 40 10 37 37 21 21 3 41 7 8 7 8 seat-tex_7-vgt 44 43 1 197514 Seat 2 180166 Bracket Pivot Fender 3 140675 Strap, Asm Fender 6 73800600 Nut, Lock w/Ins. 3/8-16 unc 7 124181X Spring, Seat Cprsn 8 171877 Bolt 5/16-18 unc x 3/4 w/Sems 10 196977 Pan, Seat 21 171852 Bolt, Shoulder 5/16-18 37 73800...

43 7 3 87 10 88 2 89 90 87 98 97 97 lift-tex_5 91 89 87 100 2 195223 Shaft Asm., Lift 3 195231 Lever Asm., Lift RH 7 196492X421 Grip, Lever 10 196314 Spring Torsion 87 194209 Pin Cotter 7/16 Bow Tie Lock 88 410710 Spring Lift Assist 89 19191912 Washer Clear Zinc 90 194208 Pin Cotter 5/16 Bow Tie Loc...

48 LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi- als and work man ship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, ...