Poulan PRO 271490 - Manuals

6 UNASSEMBLED PARTS Steering Wheel (1) Washer 17/32 x 1-3/16 x 12 Gauge Steering Wheel Insert Seat (1) Large Flat Washer Steering Boot SteeringExtensionShaft Steering Wheel Adapter (2) Keys Slope Sheet Keys (1)Knob (1) Oil Drain Tube For Future Use (1) Hex Bolt 1/4-28 x 1-1/4 (1) Locknut 1/4-28 (1) ...

7 02 599 Your new tractor has been assembled at the factory with the exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you as sem ble must be tightened securely. Use the correct tools as nec es sary to in sure ...

8 02464 02466 Seat Pan Shoulder Bolt Adjustment Knob Flat Washer Seat INSTALL SEAT Adjust seat before tightening adjustment knob.1. Remove adjustment knob and fl at washer securing seat to cardboard packing and set aside for assembly of seat to tractor. 2. Pivot seat upward and remove from the cardb...

9 CHECK TIRE PRESSURE The tires on your tractor were over in -fl ated at the factory for shipping pur pos es. Correct tire pressure is important for best cutting performance.• Reduce tire pressure to PSI shown in “PRODUCT SPEC I FI CA TIONS” section of this manual. CHECK FOR PROPER POSITION OF ALL B...

10 OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED REVERSE NEUTRAL...

11 KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. Our tractors conform to the safety standar...

12 TO ADJUST MOWER CUTTING HEIGHT The position of the attachment lift lever determines the cutting height.• Grasp lift lever.• Press plunger with thumb and move lever to desired position. The cutting height range is ap prox i- mate ly 1-1/2 to 4". The heights are mea- The op er a tion of any tra...

13 01931 AttachemntLift LeverHigh Position Attachment Clutch Lever “Engaged” Position “Disengaged” Position Low Position Defl ector Shield TO TRANSPORT • Raise attachment lift to highest position with at tach ment lift control. • When pushing or towing your trac tor, be sure gearshift lever is in ne...

14 ADD GASOLINE • Fill fuel tank to bottom of fi ller neck. Do not overfi ll. Use fresh, clean, regular un lead ed gasoline with a minimum of 87 octane. (Use of leaded gasoline will increase carbon and lead oxide deposits and reduce valve life). Do not mix oil with gasoline. Purchase fuel in quan- t...

15 MOWING TIPS • Tire chains cannot be used when the mower hous ing is attached to tractor. • Mower should be properly leveled for best mowing performance. See “TO LEVEL MOWER HOUSING” in the Service and Adjustments sec tion of this manual. • The left hand side of mower should be used for trim ming....

16 MAINTENANCE BEFORE EACH USE T R A C T 0 R Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil (with oil filter) Replace Air Filter Paper Cartridge Replace Spark Plug Check Battery Level Check Tire Pressure Clean Battery and Terminals FILL IN D...

17 TRACTOR Always observe safety rules when per- form ing any main te nance. BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in high est gear, then brake must be ad just ed. (See “TO ADJUST BRAKE” in the Ser vice and Ad just ments section of this manual). T...

18 CLEAN AIR SCREEN Air screen must be kept free of dirt and chaff to prevent engine dam age from overheating. Clean with a wire brush or compressed air to re move dirt and stub- born dried gum fi bers. V-BELTS Check V-belts for deterioration and wear after 100 hours of operation and replace if nece...

19 MUFFLER Inspect and replace corroded muffl er and spark arrester (if equipped) as it could cre-ate a fi re hazard and/or dam age. SPARK PLUG(S) Replace spark plug(s) at the beginning of each mowing season or after every 100 hours of operation, whichever occurs fi rst. Spark plug type and gap sett...

20 WARNING: TO AVIOD SERIOUS INJURY, BEFORE PERFORMING ANY SER- VICE OR AD JUST MENTS: 1. Depress clutch/brake pedal fully and set parking brake.2. Place gearshift lever in neutral (N) position.3. Place attachment clutch in “DISENGAGED” position.4. Turn ignition key to “STOP” and remove key.5. Make ...

22 With Parking Brake “Engaged” TO ADJUST BRAKE Your tractor is equipped with an ad just able brake system which is mounted on the right side of the transaxle.If tractor requires more than six (6) feet stopping distance at high speed in high- est gear on a level dry concrete or paved surface, then b...

23 00663 Retaining Ring Washers Square Key(Rear Wheel Only) Axle Cover FRONT WHEEL TOE-IN/CAM BER The front wheel toe-in and camber are not adjustable on your tractor. If dam age has occurred to affect the front wheel toe-in or camber, contact your nearest authorized service center/de part ment. TO ...

24 TO REPLACE HEADLIGHT BULB 1. Raise hood.2. Pull bulb holder out of the hole in the backside of the grill. 3. Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill. 4. Close hood. INTERLOCKS AND RELAYS Loose or damaged wiring may cause your tractor to...

25 STORAGE Immediately prepare your tractor for stor- age at the end of the season or if the trac-tor will not be used for 30 days or more. CAUTION: Never store the trac tor with gas o line in the tank inside a building where fumes may reach an open fl ame or spark. Allow the engine to cool before s...

26 Will not start • Out of fuel. • Fill fuel tank. • Engine not “CHOKED” • See “TO START ENGINE” properly. in Operation section. • Engine fl ooded. • Wait several minutes before attempting to start. • Bad spark plug. • Replace spark plug. • Dirty air fi lter. • Clean/replace air fi lter. • Dirty fue...

46 giving the model number, serial number and date of purchase of your product and the name and address of the authorized dealer from whom it was pur chased.THIS WARRANTY DOES NOT APPLY TO INCIDENTAL OR CONSEQUENTIAL DAMAGES AND ANY IMPLIED WAR RAN TIES ARE LIMITED TO THE SAME TIME PERIODS STATED HE...

47 15 DEGREES MAX. FOLD ALONG DOTTED LINE THIS IS A 15 DEGREE SLOPE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes great...