Porter-Cable CFFC350C - Manuals

7 - ENG A09770 Review and understand all instructions and warnings in this manual. Become familiar with the operation and controls of the air compressor. Keep operating area clear of all persons, pets, and obstacles. Keep children away from the air compressor at all times . Do not operate the produc...

8 - ENG A09770 GLOSSARY DUTY CYCLE Accessories for this unit are available at the store the unit was purchased. ACCESSORIES Become familiar with these terms before operating the unit. CFM : Cubic feet per minute. SCFM: Standard cubic feet per minute; a unit of measure of air delivery. PSIG: Pounds p...

9 - ENG A09770 ASSEMBLY Unpacking 1. Remove unit from carton and discard all packaging. IMPORTANT: The outlet being used must be installed and grounded in accordance with all local codes and ordinances. 2. Make sure the outlet being used has the same configuration as the grounded plug. DO NOT USE AN...

10 - ENG A09770 Extension Cords Using extension cords is not recommended. The use of extension cords will cause voltage to drop resulting in power loss to the motor and overheating.Instead of using an extension cord, increase the working reach of the air hose by attaching another length of hose to i...

11 - ENG A09770 OPERATION Know Your Air Compressor READ THIS OWNER’S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR UNIT. Compare the illustrations with your unit to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. Tank Pressure Gauge ...

Drain Valve: The drain valve is located at the base of the air tank and is used to drain condensation at the end of each use. Check Valve: When the air compressor is operating, the check valve is "open", allowing compressed air to enter the air tank. When the air compressor reaches "cut-...

13 - ENG A09770 Before Each Start-Up: 1. Place On/Auto/Off lever to "Off".2. Turn the regulator knob counter- clockwise to set the outlet pressure to zero. 3. Attach hose and accessories. NOTE: The hose or accessory will require a quick connect plug if the air outlet is equipped with a quick...

6. Unscrew elbow fitting from the check valve (turn counter- clockwise) using an adjustable wrench. Note the orientation of the elbow fitting for reassembly. 7. Using a screwdriver, carefully push the valve disc up and down. NOTE: The valve disc should move freely up and down on a spring which holds...

16 - ENG A09770 6. Assemble the regulator and orient as shown. NOTE : Arrow indicates flow of air. Make sure it is pointing in the direction of air flow. 7. Reapply pipe sealant to outlet pressure gauge and quick connect. 8. Reassemble outlet pressure gauge and quick connect. Orient outlet pressure ...

17 - ENG A09770 STORAGE Before you store the air compressor, make sure you do the following:1. Review the "Maintenance" section on the preceding pages and perform scheduled maintenance as necessary. 2. Set the On/Auto/Off lever to "Off" and unplug unit. 3. Turn the regulator counterc...

18 - ENG A09770 TROUBLESHOOTING Risk of Unsafe Operation. Unit cycles automatically when power is on. When performing maintenance, you may be exposed to voltage sources, compressed air, or moving parts. Personal injuries can occur. Before performing any maintenance or repair, disconnect power source...

19 - ENG A09770 PROBLEM CAUSE CORRECTION It is normal for "some" pressure drop to occur. If there is an excessive amount of pressure drop when the accessory is used, adjust the regulator following the instructions in the "Description of Operation" paragraph in the "Operation Sect...

22 - ENG A09770 LIMITED WARRANTY PORTER-CABLE CORPORATION warrants to the original purchaser that all products covered under this warranty are free from defects in material and workmanship. Products covered under this warranty include air compressors, air tools, service parts, pressure washers, and ...