Porter-Cable BSI525 - Manuals

6- ENG D26082 RISK OF UNSAFE OPERATION HAZARD WHAT CAN HAPPEN HOW TO PREVENT IT Operation ofgenerator incareless manner All sources of energy include thepotential for injury. Unsafeoperation or maintenance of yourgenerator could lead to seriousinjury or death to you or others. • Review and understan...

7- ENG D26082 RISK OF UNSAFE OPERATION(Continued) HAZARD WHAT CAN HAPPEN HOW TO PREVENT IT Improper raising or suspendingcan cause damage to thegenerator. Always use cables, chains, orstraps rated at 2000 lbs workingload or more to raise or suspendgenerator. Operation ofvoltagesensitive appli-ances ...

8- ENG D26082 NOTE: This manual is a general manual. Information in this manual may ormay not pertain to your model. Please read carefully. NOTE: Left and right describes the location of a part with the operatorfacing the outlet panel. REMOVE GENERATOR FROM CARTON • Open carton from top. • Cut carto...

9- ENG D26082 GROUNDING THE GENERATOR A grounding lug is supplied with the generator foruse when required by local electrical ordinances.Refer to article 250 of the National Electrical Codeto clarify any needed grounding information. Yourlocal electric company or a certified electricianshould be abl...

10- ENG D26082 OPERATION KNOW YOUR GENERATOR Read this General Manual and Safety Rules before operation of your Generator. Compare the illustration in your parts manual with your generator to familiarize yourself withthe location of various controls and adjustments. Save all manuals for future refer...

11- ENG D26082 Engine speed has been factory set to provide safe operation.Tampering with the engine speed adjustment could result in over- heating of attachments and could cause a fire. Never attempt to “speed-up” the en-gine to obtain more performance. Both the output voltage and frequency will be...

12- ENG D26082 STOPPING ENGINE 1. Disconnect all electrical loads. 2. Turn ON/OFF switch to "OFF" position. 3. Close fuel shut-off valve. CONNECTING ELECTRICAL LOADS 1. Let engine run and warm up for five minutes after starting with no electricalload. Connect loads in the following manner to...

13- ENG D26082 Note 1: Change oil after first two (2) operating hours and every 50 operating hours thereafter, more often if operated in extreme dusty or dirty conditions. Note 2: Check oil after 5 hours of operation. CUSTOMER RESPONSIBILITIES TABLE MAINTENANCE TASK Before each use Every 25 Hours of...

14- ENG D26082 If you are going to store your generator for more than 30 days, use thefollowing information as a guide to prepare the generator for storage. Never store generator with fuel in the tank indoors or inenclosed, poorly ventilated areas, where fumes can reach an open flame, spark or pilot...

15- ENG D26082 WATTAGE CALCULATIONS Never exceed the rated capacity of your generator. Serious damage to thegenerator or appliance could result from an overload.1. Starting and running wattage requirements should always be calculated when matching a generators wattage capacity to the appliance or to...

16- ENG D26082 Example 3: 1500 Starting Watts1150 Running Watts TOTAL =2650 Total Watts Generator must have a maximum capacity of at least 2650 watts. STARTING WATTAGE REQUIREMENTS 1. Some appliances and tools will list on the motor nameplate the startingand running voltage and amperage requirements...

17- ENG D26082 APPLIANCE OR LOAD DEVICE* REFRIGERATOR/ FREEZER 800 SMALL REFRIGERATOR AIR COND.(ROOM) SUMP PUMP 1/2 HP 600 TELEVISION CAUTION !! HOT PLATE MICROWAVE SPACE HEATER 2400 1000 3 2 LIGHTING 60 WATT BULBS 75 WATT BULBS 100 WATT BULBS 300 WATT BULBS ELECTRIC LOAD GRAND TOTAL THIS TOTAL MUST...

18- ENG D26082 TROUBLESHOOTING GUIDE PROBLEM CAUSE CORRECTION Engine will notstart 1. Low on fuel or oil. 2. Ignition switch in "Off"position. 3. Faulty spark plug. 4. Choke in wrong position. 5. Fuel shut-off valve inclosed position 6. Unit loaded during start-up. 1. Add fuel or oil. 2. Tur...

19- ENG D26082 LIMITED WARRANTY PORTER-CABLE CORPORATION warrants to the original purchaser that all products covered under this warranty are free from defects in material and workmanship. Products covered under this warranty include aircompressors, air tools, service parts, pressure washers, and ge...

20- ENG D26082 CALL 1-888-559-8550 TO FIND A LOCAL AUTHORIZED SERVICE CENTER NEAR YOU FOR REPAIRS AND SERVICE PART PURCHACES . QUICK FACTS ALWAYS REFER TO THE MANUALS SUPPLIED WITH THIS UNIT ENGINE GAS ENGINE OIL WATTAGE WIRING BATTERY VOLT REG. ENGINE STORAGE OPERATION Use clean, fresh gasoline wit...