NorthStar 157394 - Manuals - manualsarea.com

Page 2 - NORTH STAR; Pressure Washer; Congratulations on your purchase of the; The time you take now will prolong the life of your; . Enjoy the exceptional performance of your; This symbol means CAUTION, WARNING OR DANGER!; TABLE OF CONTENTS

- 3 - NORTH STAR R ANGER Pressure Washer HOT- COLD Congratulations on your purchase of the R ANGER 157394 Pressure Washer! Your pressure washer is made of high quality components to ensure the top performance you demand. Take the time to read this entire manual so you better understand the machine, ...

Page 3 - SAFETY INSTRUCTIONS; injury or product damage.; ELECTRICAL SAFETY; Never

- 4 - SAFETY INSTRUCTIONS ! Read and understand these instructions because they have to do with safety. Pay particular attention to the safety symbol throughout this manual. Failure to comply with these instructions may result in personal injury or product damage. ELECTRICAL SAFETY 1. Properly groun...

Page 4 - GENERAL SAFETY; Do not; DETERGENT SAFETY; UNPACKING

- 5 - GENERAL SAFETY 17. Always wear safety glasses or goggles when operating the unit. 18. Always point the wand away from people and animals. High pressure streams will penetrate the skin. Seek medical attention immediately if fluid penetrates skin. Do not treat as a simple cut. 19. Always release...

Page 5 - ELECTRICAL REQUIREMENTS; are protected; GROUNDING INSTRUCTIONS; whether an outlet is properly grounded. Do not modify the product

- 6 - ELECTRICAL REQUIREMENTS “The supply and internal wiring of portable high pressure spray washing machines shall have ground-fault-circuit- interpreter (GFCI) which is designed to protect people from line-ground shock hazards”, National Electric Code (NEC) 1987, 422, 8 (d) (3). - All equipment a...

Page 6 - INSTALLATION INSTRUCTIONS; CLOTHING; Be sure all connections are securely tightened.

- 7 - INSTALLATION INSTRUCTIONS If installing the R ANGER 157394 indoors or in an enclosed area, observe the following guidelines: - Operate the unit on a level surface to ensure proper lubrification to the water pump.- Be certain the ambient temperature of the environment does not exceed 100°F. Thi...

Page 7 - OPERATING INSTRUCTIONS; STARTING THE PRESSURE WASHER; Do not allow the unit to operate in bypass mode (with trigger

- 8 - OPERATING INSTRUCTIONS STARTING THE PRESSURE WASHER BEFORE STARTING THE PRESSURE WASHER 1. Read all safety instructions throughout this manual. 2. Be sure the motor switch is in the “OFF” position, red button pushed. 3. Ensure outlet is the proper voltage (120 volts). 4. Insert the male power ...

Page 8 - HOT WATER OPERATION; EXPOSED METAL EXHAUST OUTLET AND HOSE

- 9 - HOT WATER OPERATION 1. Fill fuel tank with 1.8 gallons of #l or #2 Diesel. 2. Be sure trigger gun is locked in the “OFF” position and remove the nozzle/wand assembly. 3. Turn the unit on by pushing the pump switch on the control panel. Once the unit starts, squeeze the trigger gun “ON” for 2 m...

Page 9 - STOPPING THE PRESSURE WASHER; To protect your safety and the service of your; USING THE DETERGENT INJECTOR

- 10 - STOPPING THE PRESSURE WASHER ! To protect your safety and the service of your R ANGER 157394, you must follow the procedure for stopping the pressure washer outlined below: 1. Run one gallon of clean water through the used detergent lines. (If detergent has been used during this operation run...

Page 10 - MAINTENANCE; Use only

- 11 - MAINTENANCE 1. Inspect and clean the water intake screen on the unit before each use. 2. Always be sure the unit is receiving the proper 120 volts. Be certain the cord is equipped with the appropriate ground prong plug to ensure proper grounding. Electrical cords and connections should not co...

Page 11 - TROUBLESHOOTING

- 12 - TROUBLESHOOTING SYMPTOMS CAUSES REMEDIES The water pump will not start The motor thermic protection is open Check the mains voltage (+/- 5% tolerance). Check the phases in the plug are connected well. The water pump will not enter The no-return valve does not seal Replace the valve or the gas...

Page 12 - FRAME, COWLING ASSEMBLY EXPLODED VIEW

- 13 - FRAME, COWLING ASSEMBLY EXPLODED VIEW N° Code Description Note Qty Model N° Code Description Note Qty Model 1 0477 0096 Cover 1 2 2416 0104 Roll-bar 2 3 3208 0800 Copper Hose Ø4 1 4 2803 0322 Coupling Ø4 GC1/8” 1 5 2803 0258 “T” Coupling G1/8 1 6 3200 0017 Plug G1/8x8 1 7 3002 0322 Diesel Pum...

Page 13 - PUMP, MOTOR ASSEMBLY EXPLODED VIEW

- 14 - PUMP, MOTOR ASSEMBLY EXPLODED VIEW N° Code Description Note Qty Model N° Code Description Note Qty Model 1 1211 0021 By-Pass Elbow Coupling 1 2 3208 0726 By-Pass Hose 1 3 3208 0728 H.P. Hose 1 4 2803 0244 Detergent Coupling 1 5 1210 0227 O-Ring 1 6 3003 0011 Detergent Ball 1 7 1802 0155 Deter...

Page 14 - Suction / Delivery Valve Kit; Kit

- 15 - PUMP, MOTOR ASSEMBLY EXPLODED VIEW Suction / Delivery Valve Kit (5025 0007) Seal Kit (5019 0025) N° Code Description Note Qty Model N° Code Description Note Qty Model N° Cod. Qty N° Cod. Qty 47 1201 0124 Motor Gasket 1 48 0001 0464 Rotor Shaft 1 49 3041 0152 Stator 1 50 1201 0124 Motor Gasket...

Page 15 - UNLOADER VALVE EXPLODED VIEW

- 16 - UNLOADER VALVE EXPLODED VIEW N° Code Description Note Qty Model N° Code Description Note Qty Model 1 1817 0031 Knob 1 2 2803 0262 Coupling 1 3 1802 0119 Unloader Spring 1 4 3002 0334 Spacer 1 5 0015 0118 Rod 1 6 0009 0096 Ring 1 7 1210 0039 O-Ring Ø1,78x 7,66 1 8 1227 0022 Ring Nut 1 9 3622 0...

Page 16 - ELECTRIC SYSTEM EXPLODED VIEW

- 17 - ELECTRIC SYSTEM EXPLODED VIEW N° Code Description Note Qty Model N° Code Description Note Qty Model 1 3625 0003 Special Screw M6x6 2 2 0460 0030 Switch Cover 1 3 2416 0095 Switch Protection 1 4 1410 0066 Switch 1 5 0456 0100 Electrical 3 6 1817 0039 Burner Knob 1 7 3625 0035 Screw Ø3,5x19 6 8...

Page 17 - BURNER, BOILER EXPLODED VIEW

- 18 - BURNER, BOILER EXPLODED VIEW N° Code Description Note Qty Model N° Code Description Note Qty Model 1 3208 0800 Copper Diesel Hose 1 2 2803 0320 Helbow Coupling 90° 1 3 3625 0013 Screw 4,2x9,5 3 4 3200 0074 Plug 1 5 3019 0035 Outer Seeger Ø22 1 6 0602 0047 Electrode Holder Disc 1 7 0602 0048 A...