Monessen CSVF30SNV - Manuals

Monessen CSVF30SNV – Manual in PDF format online.

Manuals:

Manual

Manual Monessen CSVF30SNV

Summary

Page 2 - CONTENTS

2 58D6002 CONTENTS Important Safety Information .......................... 3 Product Features .............................................. 5 Dimensions ....................................................... 6 Getting Started .................................................. 7 Product Speciﬁcatio...

Page 3 - National Fuel Gas; INSTALLER; Please leave these instructions with the owner.; OWNER; Please retain these instructions for future reference.; IMPORTANT; IMPORTANT SAFETY INFORMATION; CARBON MONOXIDE POISONING:; burns, explosion or carbon monoxide poisoning.; ARNING

58D56002 3 9. The installation must conform with local codes or, in the absence of local codes, with the National Fuel Gas Code, ANSI Z223.l/NFPA54. 10. This unit complies with ANSI Z21.11.2-2001 Unvented Heaters. 11. Do not install heater in a bathroom or bedroom unless approved for bedroom use. 12...

Page 5 - PRODUCT FEATURES; Figure 1 - Cast Iron Stove

58D56002 5 ON OF F PRODUCT FEATURES Off/Pilot/On Knob Hi/Lo Knob Door Figure 1 - Cast Iron Stove Optional Remote Receiver Optional Thermostat Sensor Piezo Handle On/Off Switch

Page 6 - DIMENSIONS; Figure 2 - Dimensions

6 58D6002 A C B CSVF20S CSVF30S A 21 1 / 4 " 26 3 / 4 " B 23" 28 1 / 2 " C 16 1 / 2 " 19 3 / 4 " DIMENSIONS Figure 2 - Dimensions

Page 7 - GETTING STARTED; MAKE SURE YOU HAVE RECEIVED ALL PARTS:; CAUTION

58D56002 7 GETTING STARTED MAKE SURE YOU HAVE RECEIVED ALL PARTS: Carefully inspect the contents for shipping damage. If any parts are missing or damaged, immediately inform the dealer from whom you purchased the appliance. Do not attempt to install any part of the appliance unless you have all part...

Page 8 - PRODUCT SPECIFICATIONS; NATURAL GAS; systems operating at higher pressure.; IGNITION CONTROLS

8 58D6002 PRODUCT SPECIFICATIONS NATURAL GAS NOTE: An external regulator is required to reduce supply pressure to a maximum of 10 1 / 2 " w.c. on Natural Gas systems operating at higher pressure. MILLIVOLT PRESSURE Regulator Pressure Setting: 3.5" w.c. Pilot Regulator: 3.5" w.c. Gas Inle...

Page 9 - NFPA54 which can be obtained from...; American National Standards Institute, Inc.; or; National Fire Protection Association, Inc.; Batterymarch Park; GENERAL INSTALLATION INFORMATION; adequate combustion and ventilation air.; UNUSUALLY TIGHT CONSTRUCTION IS DEFINED AS CONSTRUCTION WHERE...; ) or less with openings gasketed or sealed

58D56002 9 CODES Adhere to all local codes or, in their absence, the latest edition of THE NATIONAL FUEL GAS CODE ANSI Z223.1 or NFPA54 which can be obtained from… American National Standards Institute, Inc. 1430 Broadway New York, NY 10018 or National Fire Protection Association, Inc. Batterymarch ...

Page 10 - Figure 3 - Example of a Large Room with 1/2 Wall Divider

10 58D6002 ON OFF L 2 L 1 W H GENERAL INSTALLATION INFORMATION The following formula can be used to determine the maximum heater rating per the deﬁnition of unconﬁned space: BTU/Hr = (L 1 + L 2 ) Ft x (W) Ft x (H) Ft 50 Consider two connecting rooms with an open area between, with the following dime...

Page 11 - CLEARANCES / HEIGHT REQUIREMENTS; Figure 4 - Minimum Clearance to Walls and Ceiling; Figure 4

58D56002 11 D Minimum to Either Side Wall E Minimum A G G D Minimum to Either Side Wall F Minimum F Minimum 36" in Front C B Mantel Clearance from Top of Unit Side, Measured from Top Rear Measured from Back Corner Measured From Top Corners Product Min. Ceiling from Floor Max. Protrusion Min. Hei...

Page 12 - CLEARANCES / HEIGHT REQUIRMENTS; Figure 5 - Placing Stove in Alcove; Height From

12 58D6002 ON OF F A C B CLEARANCES / HEIGHT REQUIRMENTS Figure 5 - Placing Stove in Alcove Note: Maintain minimum side and back clearances when placing stove in alcove. Height From Hearth A Width B Depth C VF20 38½" 23" 36" VF30 52" 34" 36" Tested Minimum Alcove Dimensions

Page 13 - REMOVING UNIT FROM CRATE; Open plastic bag and slide to bottom of unit.

58D56002 13 PIL OT OFF REMO TE CO NTROL LOGS ON OF F LOGS PIL OT OFF REMO TE CO NTROL LOGS REMOVING UNIT FROM CRATE 1. Remove two (2) straps. See Figure 6. 2. Open plastic bag and slide to bottom of unit. See Figure 7. 3. Lift up on ash lip and pivot down to open control door. See Figure 8. 4. Lift ...

Page 14 - CONNECTING THE GAS; Figure 9 - Gas Connection

14 58D6002 Pipe Coupling To Heater Valve Gas Supply Inlet CONNECTING THE GAS NOTICE: A qualiﬁed gas appliance installer must connect the heater to the gas supply. Consult all local codes. IMPORTANT: Hold heater valve ﬁrmly with a wrench to prevent movement when connecting to inlet pipe. Manual Shuto...

Page 15 - CHECKING GAS PRESSURE; MILLIVOLT CONTROL; Figure 10 - Pressure Test Point Location; CONNECTING REMOTE RECEIVER; Figure 11 - Installing Remote Receiver; DO NOT USE AN OPEN FLAME.

58D56002 15 ON OFF CHECKING GAS PRESSURE AND CONNECTING REMOTE RECEIVER MILLIVOLT CONTROL (FIGURE 10) The valve regulator controls the burner pressure which should be checked at the pressure test point.If outlet pressure is low, check inlet pressure against data plates or manual. Turn captured slott...

Page 16 - THAT DOES NOT REQUIRE 110 VAC TO OPERATE.; Figure 12 - Wiring Diagram; CONNECTING OPTIONAL WALL SWITCH OR THERMOSTAT

16 58D6002 ELECTRICAL WIRING (MILLI-VOLT) The milli-volt valve is a self-powered combination gas control THAT DOES NOT REQUIRE 110 VAC TO OPERATE. Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after s...

Page 18 - OPERATING THERMOSTAT SENSOR

18 58D6002 PIL OT OFF REMO TE C ONTROL 4. Remove adhesive backing from plastic clip. Press clip to bottom of valve. Clip thermo bulb into plastic clip. See Figure 15. 5. Reattach faceplate or reinstall base.6. Install knob to shaft of t-stat sensor. See Figure 14, page 17. Figure 15 - Clipping Therm...

Page 19 - LOG PLACEMENT; INSTALLING LOGS ON GRATE; Figure 17 - Installing Logs to Grate; Before you begin; After handling the logs, wash your hands gently with

58D56002 19 PIL OT OFF REMO TE C ONTROL Left Bottom Log #2 Back Log #1 Top Left Log #4 LOG PLACEMENT INSTALLING LOGS ON GRATE (See Figure 17) 1. Install back log (#1) on rear log support bracket. 2. Install left bottom log (#2) on left log support bracket in front of back log. 3. Install right botto...

Page 20 - CHECKING PILOT FLAME; It should just touch the top of the ther-; ROCK WOOL INSTALLATION; Figure 18 - Rock Wool Installation; FLAME APPEARANCE

20 58D6002 PIL OT OFF REMO TE C ONTROL Flames from the pilot, front and rear burner should be visually checked as soon as the heater is installed. In addition, periodically check the ﬂames visually during operation. CHECKING PILOT FLAME The pilot ﬂame must always be present when the heater is in ope...

Page 21 - CHECKING BURNER FLAME; not; OPERATING INSTRUCTIONS; Avoid any drafts that alter burner flame patterns.; Do not allow fans to blow directly into the stove. Do not place

58D56002 21 PIL OT OFF REMO TE C ONTROL FLAME APPEARANCE CHECKING BURNER FLAME In normal operation at full rate after 15 minutes, the following ﬂame appearances should be observed: The left and right rear ﬂames should be yellow and extend 1"-2" above middle logs. The yellow ﬂames should not ...

Page 22 - WHAT TO DO IF YOU SMELL GAS:; • Do not attempt to light any appliance.; FOR YOUR SAFETY READ BEFORE LIGHTING

22 58D6002 PIL OT OFF REMO TE C ONTROL Figure 22 - Location of Piezo Ignitor, Control Knobs and Switch on Milli-volt Unit A. This appliance is equipped with an ignition device which automatically lights the pilot. If the piezo is not working properly, see Match Lighting Instructions , page 24. B. BE...

Page 23 - TO TURN OFF GAS TO HEATER; Figure 24 - Control Cover Plate for Milli-Volt; Match Lighting Instructions; THERMOSTAT

58D56002 23 OFF ON OPERATING INSTRUCTIONS Figure 23 - Pilot TO TURN OFF GAS TO HEATER 1. Turn control knob clockwise to OFF position to completely shut off the heater. 2. If applicable: Turn ON/OFF switch to OFF position and/or set thermostat (if present) to lowest setting. 3. If applicable: Turn of...

Page 24 - CLEANING AND SERVICING; air intake holes clean will result in sooting and poor combustion.; MATCH LIGHTING INSTRUCTIONS

24 58D6002 1. Open stove door. Remove any items necessary for easy access to the pilot (for example: logs, screens, etc.). 2. Follow appropriate lighting instructions found previously. Light a match and hold the ﬂame to the end of the pilot and ignite the pilot. 3. After control knob has been releas...

Page 25 - REPLACEMENT PARTS ARE AVAILABLE THROUGH YOUR RETAILER.; Item; REPLACEMENT PARTS LIST

58D56002 25 1 2 3 4 5 REPLACEMENT PARTS ARE AVAILABLE THROUGH YOUR RETAILER. Item Description Qty 1 Back Log 1 58D1901 2 Bottom Left Log 1 58D1902 3 Bottom Right Log 1 58D1903 4 Left Top Log 1 58D1904 5 Right Top Log 1 58D1905 REPLACEMENT PARTS LIST F a i l u r e t o p o s i t i o n t h e p a r t s ...

Page 26 - BURNER ASSEMBLY

26 58D6002 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 REPLACEMENT PARTS F a i l u r e t o p o s i t i o n t h e p a r t s i n accordance with these diagrams or failure to use only parts speciﬁcally approved with this appliance may result in property damage or personal injury. W ARNING BURNER ASSEMBLY

Page 27 - Accessories

58D56002 27 CSVF20 CSVF30 Item Description Qty Natural Propane Natural Propane 1 Piezo Ignition Module 1 45D0077 45D0077 45D0077 45D0077 2 Piezo Switch 1 45D0078 45D0078 45D0078 45D0078 3 Piezo Wire 1 00K0632 00K0632 00K0632 00K0632 4 Front Burner 1 33D0070 33D0071 58D0193 58D0193 5 Rear Burner 1 — ...

Page 28 - Note: All troubleshooting items are listed in order of operation.; TROUBLESHOOTING

28 58D6002 OBSERVED PROBLEM When ignitor button is pressed, there is no spark at ODS/pilot. Appliance produces unwanted odors. Appliance shuts off during use. Gas odor even when control knob is in OFF position. When ignitor button is pressed, there is spark at ODS pilot, but no ignition. POSSIBLE CA...

Page 30 - NOTES

Page 32 - LIMITED LIFETIME WARRANTY; the first five years of ownership and parts only thereafter.

July 2004 P/N 58D6002 • Rev. 1 LIMITED LIFETIME WARRANTY Monessen Hearth Systems warrants its products to be free of defects in material and workmanship and backs each product with a Limited Lifetime Warranty. This warranty is to the original purchaser of a Monessen Hearth Systems product and is not...