Page 2 - DANGER; which could cause property damage, personal injury, or death.; STRUCTURAL PROXIMITY AND SAFETY USAGE RECOMMENDATIONS; Before using smoker check wind direction and; HOSE IS A TRIP HAZARD; WARNING
2 Burning wood chips gives off carbon monoxide, which has no odor and can cause death. DO NOT burn wood chips inside homes, vehicles, tents, garages or any enclosed areas. USE ONLY OUTDOORS where it is well ventilated. CARBON MONOXIDE HAZARD DANGER IF YOU SMELL GAS: 1. Shut off gas to the appliance....
Page 3 - GENERAL WARNINGS AND SAFETY INFORMATION; READ ALL INSTRUCTIONS; WARNINGS & IMPORTANT SAFEGUARDS CONTINUED ON PAGE 4
3 GENERAL WARNINGS AND SAFETY INFORMATION • Always use unit in accordance with all applicable local, state and federal fire codes. • Before each use check all nuts, screws and bolts to make sure they are tight and secure. • Never operate unit under overhead construction such as roof coverings, carpo...
Page 5 - SMOKER OPERATION - READ & FOLLOW ALL INSTRUCTIONS CAREFULLY; GETTING STARTED; Restart smoker and burn for 20 minutes.; ADDING WOOD CHIPS OR CHUNKS; open the door to check the flame and follow the; and; DRY AREA; CHECK OUT MASTERBUILT.COM FOR MORE TIPS AND RECIPE VIDEOS.
5 SMOKER OPERATION - READ & FOLLOW ALL INSTRUCTIONS CAREFULLY GETTING STARTED • Pre-season unit prior to first use. See PRE-SEASON INSTRUCTIONS . • Before starting the unit, see ADDING WOOD CHIPS OR CHUNKS . CAUTION - All surfaces are HOT and may cause burns. Use protective gloves or long, sturd...
Page 6 - SOAPY WATER TEST WARNINGS & PROCEDURES; WARNINGS; • Never use an open flame to test for gas leaks.; PERFORM “SOAPY WATER TEST” BEFORE EACH USE. SEE “SOAPY WATER TEST”; FUMES TO DIMINISH BEFORE LIGHTING SMOKER.; DURING ANY PORTION OF SOAPY WATER TEST IF BUBBLES CONTINUE TO
6 Apply solution to gas cylinder valve Apply solution to hose regulator and the full length of the hose Failed test will present bubbles as shown below. Apply solution underneath control panel where burner and hose are connected (Smoker shown on back for clarity only) WARNING SOAPY WATER TEST WARNIN...
Page 7 - REGULATOR, BURNER AND GAS VALVE CONNECTION & OPERATION; nests. A clogged tube can lead to a fire beneath unit.; IGNITION INSTRUCTIONS
7 REGULATOR, BURNER AND GAS VALVE CONNECTION & OPERATION • Inspect hose before each use. If there are signs of abrasion, wear, cuts, or leaks, the hose must be replaced. DO NOT USE. • Inspect burner before each use. Check burner and burner venturi tube for insects and insect nests. A clogged tub...
Page 8 - In the event of a gas leak that cannot be stopped, or if a; TROUBLESHOOTING GUIDE; MATCH LIGHT INSTRUCTIONS; Read all instructions and warnings before lighting.
8 Emergency Cause Possible Solution Gas leaking from cracked, cut or burned hose Damaged hose Turn off gas at LP cylinder. Replace hose. Contact Customer Service at 1300 174 876. Gas leaking from LP cylinder Failure due to rust or mishandled equipment Replace LP cylinder. Gas leaking from gas cylind...
Page 9 - • BEFORE ASSEMBLY READ ALL INSTRUCTIONS CAREFULLY.; For assembly assistance, missing or damaged parts
9 TROUBLESHOOTING SOLUTIONS: “CAUSES” LOW OR NO FLOW/VAPOR LOCK/EXCESS FLOW Symptom Cause Possible Solution Burner doesn’t light after pressing ignitor button Low/no gas flow 1. Turn burner control knobs to “OFF” position. 2. Turn gas cylinder valve knob to OFF. 3. Disconnect regulator from cylinder...
Page 10 - PARTS LIST; HARDWARE LIST; Actual product may differ from picture shown.
10 PARTS LIST 3 8 2 12 6 5 22 23 7 13 24 15 28 17 30 32 29 35 14 16 25 31 11 26 27 HARDWARE LIST (A) M6x12 Qty-45 (G) M4x10 Qty-4 (B) #10x3/8 Qty-6 (C) M6x30 Qty-4 (H) M5x10 Qty-4 (D) M6 Qty-3 (F) M6 Qty-16 (I) Wing Nut (packed with temperature gauge) Qty-1 (J) Wing Screw (pre-assembled to tank reta...
Page 12 - ASSEMBLY
12 26 22 25 ASSEMBLY 27 23 22 17 A 8 2 7 23 A F F A 22 26 1 3 2 4 F A A A x12 x12 x4 x12
Page 18 - WARRANTY STATEMENT
18 09/11 WARRANTY STATEMENT GASMATE BARBEQUES AND ACCESSORIES PRODUCT RANGE SITRO GROUP AUSTRALIA (S.G.A.) warrants the purchaser of this product against defects in workmanship and materials for the following periods from the date of purchase: For domestic use, this table applies:- Stainless steel c...
Page 20 - Customer Service; Monday to Friday 8am - 5pm EST
Do not return to place of purchase. For any queries or assistance call Customer Service (Australia Only) 1300 174 876 Hours of operation: Monday to Friday 8am - 5pm EST Keep your purchase receipt. This will be required to make any claims under the 12 month warranty. Rest assured, we’re here to help.
