Page 2 - WARNINGS AND IMPORTANT SAFEGUARDS; READ ALL INSTRUCTIONS; CARBON MONOXIDE HAZARD; which has no odor and can cause death.; WARNING
WARNINGS AND IMPORTANT SAFEGUARDS READ ALL INSTRUCTIONS CARBON MONOXIDE HAZARD • Burning wood chips, wood chunks, wood pellets, charcoal and propane gives off carbon monoxide, which has no odor and can cause death. • DO NOT burn wood chips, wood chunks, wood pellets, charcoal or propane inside homes...
Page 3 - SAVE THESE INSTRUCTIONS; DO NOT RETURN TO RETAILER; STOP; • Remove all printed labels from the grill.
WARNINGS AND IMPORTANT SAFEGUARDS • DO NOT bump or impact the grill to prevent personal harm, damage to grill, or spillage/splashing of hot cooking liquid. • Do not touch HOT surfaces • Grill is hot during use. To avoid burns, keep face and body away from door(s) and vents. Steam and hot air are exp...
Page 4 - Parts Diagram; Parts List
Parts Diagram 4 1 23 4 5 6 7 8 9 10 11 12 13 14 16 17 18 19 20 21 2223 24 15 NO. QTY. DESCRIPTION 13 1 Lid Handle Liner 14 1 Charcoal Grate 15 1 Grease Tent 16 1 Cooking Grate 17 2 Handles (MODELS MB20040522 and MB20040622) 18 1 Right Shelf 19 1 Metal Shelf Support Rear 20 1 Metal Shelf Support Fron...
Page 5 - Structural Proximity and Safe Usage Recommendations; KEY; Mica Plat
REMINDER: Maintain a minimum distance of 10 feet from rear and sides to walls, rails or other combustible construction. This clearance provides adequate space for proper combustion, air circulation and venting. 10 ft 3 m 10 ft 3 m 10 ft 3 m Charcoal does not come with this product. Batteries do not ...
Page 6 - Assembly
Assembly 1 2 10 21 21 10 11 6 21 17 17 MB20040522, MB20040622 A X8 C X4 MODELS WITH NO CART
Page 7 - Press Down
Assembly 3 4 D X2 7 E E X2 23 D E F 23 E Instructions for raising and lowering the cart are located on page 14. Press Down Unlock
Page 9 - Install Grease Tent First
Assembly 7 8 9 5 5 14 6 15 15 Install Grease Tent First 5
Page 12 - RELOAD; SHUTDOWN; Operating Instructions
START-UP 1. Open charcoal hopper. 2. Place fire starter in fire starter slot under the charcoal grate. Replace the charcoal grate and light the firestarter. • Use a food safe fire starter block or twisted paper towel/paper. • Use caution and wear protective gloves. • Light with match stick or lighte...
Page 13 - REGULATING TEMPERATURE; CONTROL PANEL; Figure 1
REGULATING TEMPERATURE IN YOUR GRILL: Power ON/Off Controller: 1. Rotate control knob clockwise to power controller ON and set temperature (the thermostat inside the grill body controls the fan ON/OFF automatically). 2. Rotate control knob counter clockwise to power controller OFF and lower temperat...
Page 14 - CART; RAISING AND LOWERING THE CART; From the lower position:; From the raised position:; TOW HANDLE
CART RAISING AND LOWERING THE CART From the lower position: 1. Place foot on the bottom leg. 2. Release the latch 3. Using the side shelf, pull the grill up. 4. Raise the top leg in the lock position. Note: Do not remove foot from bottom leg until grill is fully locked in the raised position. From t...
Page 15 - Troubleshooting; Wiring Diagram
Troubleshooting PROBLEM REASONS SOLUTIONS Grill is not getting up to temperature. Charcoal is not lit. Charcoal low. Ash buildup in the charcoal hopper and manifold. Each setting will vary with outside temperature, food qty. and type of charcoal being used. Low or depleted battery. Fan is not workin...
Page 16 - Customer Service
Rest assured, we’re here to help. Customer Service @masterbuilt masterbuilt.com masterbuilt.com/contact-us masterbuilt.com/warranty masterbuilt.com/collections/parts
