Lumex US0208 - Manuals

Lumex US0208 – Manual in PDF format online.

Manuals:

Manual

Manual Lumex US0208

Summary

Page 2 - specifications are subject to change without notice.; Lumex; are registered trademarks, and; Patriot; CONTENTS

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 2 • READ THESE INSTRUCTIONS BEFORE OPERATING THE PATRIOT HOMECARE BED• SAVE THESE INSTRUCTIONS GF Health Products, Inc. is not responsible for typographical errors. Packaging, warranties, products and specifications are subject to change without notice....

Page 3 - SAFETY; could result in death or serious personal injury.; the most from your product.; WARNING / CAUTION SUMMARY; WARNING: Keep hands and feet clear of all moving parts.

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 3 1 SAFETY The safety statements presented in this chapter refer to the basic safety information that the operator of the Patriot ™ Homecare Bed shall pay attention to and abide by. There are additional safety statements in other chapters or sections, w...

Page 4 - THERMAL MOTOR PROTECTION

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 4 2 INTRODUCTION, PATRIOT ™ HOMECARE BED USER MANUAL This manual contains assembly and maintenance instructions for your Model US0208 / US0208PL Semi-Electric and US0458 / US0458PL Full-Electric / Low Patriot ™ bed. Read the entire manual care- fully be...

Page 5 - ASSEMBLY INSTRUCTIONS; HEAD AND FOOT ASSEMBLY; tion’s rivet; on both sides; . Ensure both rivets are completely seated before continuing.; straighten; shown above. Position head wing as shown above.

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 5 3 ASSEMBLY INSTRUCTIONS HEAD AND FOOT ASSEMBLY foot section head section motor cam hook rivet hook rivet Assembly, head and foot sections Note: Grid deck not shown for clarity 1. Lay the head and foot sections on their sides at approximately right ang...

Page 6 - MOTOR ASSEMBLY; WARNING: Assemble motor on bed as follows. While it is possible to; motor; Install Motors; Install motor; foot; sembly into position on the cam.; Head

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 6 MOTOR ASSEMBLY WARNING: Assemble motor on bed as follows. While it is possible to install the motor backwards, avoid it! Incorrect installation could cause the bed to move in unexpected ways. Note that the motor ends are labeled and embossed with head...

Page 7 - Install motor slide caps; Position the caps as shown at right so that; Motor assembly troubleshooting; Problem; Motor is installed backwards; Any full-electric Patriot; Low bed height

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 7 Install motor slide caps 7. Position the caps as shown at right so that the grooves in the slide cap are aligned with the grooves in the motor. 8. Apply straight downward pressure to each end of the cap while sliding into the closed position. 9. Repea...

Page 8 - BED END ASSEMBLY; All bed models: Assemble bed ends; Insert one locking and one non-locking caster into each bed end.; Locking casters must be in-; See previous page for full-electric caster position options.; Attach bed end; Tilt the bed end slightly back toward you as shown above.; Engage lower rivet

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 8 BED END ASSEMBLY Full-electric bed only (US0458/US0458PL): Lock motor spring coupling ROTATE TO UNLOCK coupler Unlocking coupler gearbox coupler SLIDE IN AND ROTATE TO LOCK Locking coupler gearbox Before attaching foot end, ensure that hi/lo motor spr...

Page 9 - After bed ends have been attached, install bed end safety; Route cord under cross-angle; All models: Assemble head bed end; Install bed end safety pins

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 9 7. After bed ends have been attached, install bed end safety pins to act as safety latches. (Bed End Safety Pin Kit part number: 690-1000-100; includes four clevis pins, four hitch pins and four washers). A lan-yard is supplied to attach hardware to t...

Page 11 - All models: Attach HI/LO rod to gearbox or motor shaft pins; gearbox or motor shaft; assembly

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 11 All models: Attach HI/LO rod to gearbox or motor shaft pins Attach hi/lo rod to gearbox or motor shaft slot hi/lo rod gearbox shaft (or motor shaft) pin Both ends of the hi/lo rod assembly have a slot to mount on the foot end motor shaft pins and bed...

Page 12 - BED OPERATION; PENDANT HAND CONTROL OPERATION; Full-electric bed only

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 12 4 BED OPERATION WARNING: Ensure that bed is secure and assembled as instructed on previous pages be - fore operating. Note: In the event of a power failure, use a standard 9V batter y to lower the bed's head and foot sections (the 9V batter y connect...

Page 13 - removing the hi/lo rod from the motor or bed end.; crank

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 13 CRANK OPERATION: SEMI-ELECTRIC BED ONLY (US0208/US0208PL) Use the crank at the center foot of the semi-electric bed (shown at right) to change bed height (raise or lower entire deck). TRENDELENBURG POSITION, ALL MODELS(HEAD END AT LOWER ELEVATION THA...

Page 14 - * Specifications are subject to change without notice.; Bed length; Deck width; * Maximum patient weight

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 14 5 SPECIFICATIONS, ALL MODELS * * Specifications are subject to change without notice. Deck height High position Deck height: High Position US0208/US0208PL: 24.0 inches US0458/US0458PL with cast-ers in low position: 20.0 inches US0458/US0458PL with ca...

Page 15 - ACCESSORIES: BED RAILS; BED RAIL SAFETY; replacement parts and/or bed rails will void the warran; LUMEX; Electrically Operated Hospital Beds; Assist Bar

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 15 6 ACCESSORIES: BED RAILS Patriot ™ Homecare Bed decks are equipped with patent-pending slots specifically for bed rail installation, providing a fixed place to mount GF bed rails. Two styles of Lumex ® bed rails are de- scribed in Section 6: 1) The P...

Page 16 - If you install Lumex; sult in personal injury and damage to the bed rails.; HEADBOARD; FO; Full-Length Side Rail

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 16 GF6590B-1: Half No-Gap Head Rail The Half No-Gap Head Rail, which provides a full head coverage of 31.5 inches, extends to eliminate the gap between the head board and the end of the rail. The GF6590B-1 mount-ed on the bed's head and the GF6580B-1 mo...

Page 17 - No Gap Side Rail; Head end

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 17 LX5088: No-Gap Bed Rail B G3 FO O TB O A RD B HEADBOARD G2 Spring Buttons Spring Buttons LX5088 No Gap Side Rail Position spring-loaded crossbraces #B into slots G2 and G3 on both sides of bed with spring but-tons facing inward as shown above. GF6580...

Page 18 - SERVICE PARTS, ALL MODELS; BED COMPONENTS; HEAD; Part number

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 18 7 SERVICE PARTS, ALL MODELS Service parts for all bed models are shown below and on the following two pages. See pictures and tables for appropriate service parts. Note: To order service parts, contact our Customer Service department at 800-365-2338 ...

Page 19 - BED END COMPONENTS; Item Part number

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 19 BED END COMPONENTS 3 5 6 7 4 1 2 8 HEAD FOOT Item Part number Description Semi-electric Full-electric US0208 US0208PL US0458 US0458PL 1 690-7001-901 Head bed end, semi-electric, walnut panels X 690-7601-901 Head bed end, semi-electric, plastic panels...

Page 20 - BED SERVICE PARTS; Motor slide covers

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 20 BED SERVICE PARTS 1 HEAD FOOT 2 3 4 Item Part number Description Semi-electric, H7920SE Full-electric, H7920FE US0208 / US0208PL US0458 / US0458PL 1 690-2001-913 Motor and pendant, semi-electric X 690-2001-411 Pendant, semi-electric X 690-2001-410 Mo...

Page 21 - MAINTENANCE AND SAFETY CHECKS; Check all cables for damaged or frayed wires.; Cleaning

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 21 8 MAINTENANCE AND SAFETY CHECKS Perform the following as needed or between patient placements, whichever happens sooner: Electronics and Motors Check all controls to ensure that all functions work properly. Foot controlHead controlHi/Lo (if applicabl...

Page 22 - WARRANTY

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 22 9 WARRANTY GF Health Products, Inc. warrants the Patriot ™ US0208 / US0208PL Semi-Electric Homecare Bed Patriot ™ US0458 / US0458PL Full-Electric / Low Bed as follows: ● Two year warranty for defects in workmanship and materials of mechanical compone...

Page 23 - Assembly instructions 5

US0208-INS-LAB-RevB09 • Patriot ™ Homecare Bed 23 10 INDEX A Assembly instructions 5 B Bed end assembly 8Bed end safety pins, install 9Bed extension kit, 84" 14Bed height, low, full-electric 7Bed height, standard, full-electric 7Bed length adjustment 10Bed operation 12Bed rails 15Bed rail safety...