LG RDV33\40 - Manuals

LG RDV33\40 – Manual in PDF format online.

Manuals:

Manual

Manual LG RDV33\40

Summary

Page 3 - Table of Contents

3 Table of Contents C autions & s afety ..................................................................................... 2 o rifiCe s ize / a ltitude a djustment .................................................................... 4 f ireplaCe r equirements ....................................

Page 4 - WARNING; IMPORTANT: When installing these appliances into a fac-; Smoke Detectors

4 Orifice Size/Altitude Adjustment For altitudes above 2,000 feet (In Canada 4,500 FT/1370 M),the orifice should be de-rated by 4% for every 1,000 feet to maintain the proper ratio of gas to air. Improper orifice sizing may result in damage and unsafe conditions. Chang- ing the orifice should only b...

Page 5 - The following requirements reference various Massachusetts

5 Inspection The state or local gas inspector of the side wall horizontally vented gas fueled equipment shall not approve the installation unless, upon inspection, the inspector observes carbon monoxide detectors and signage installed in accordance with the provisions of 248 CMR 5.08(2)(a)1 through ...

Page 6 - RATINGS

Pre-Installation f eatures Installation Options Manufactured (Mobile) Home Natural Gas Or Propane (LP) Bedrooms Optional Wall-mounted Or Remote Thermostat Electrical The standard fan motor requires 120 Volts AC for operation. The fireplace is not dependent on the fan or an outside elec- trical suppl...

Page 7 - * Top air duct will need to be removed for short ZC applica-; Width of insert behind Surround Panels; CAUTIONS

7 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. i nsert d imensions m inimum f ireplaCe o pening r equired A = 29-3/4” (756mm) Front Opening B = 19-1/2” (495mm) Height C = 19” (483mm) Rear Width D = 16” (406mm) Fireplace Depth * Top air duct will need to be removed for short ZC applica- tions...

Page 8 - Clearances to Combustibles

8 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Note: Hearth protection to be min. 3/8” (10mm) thick non-combustible or equivalent, with a k factor of .84. i nsert l eveling At each front and rear corner of the insert is an adjustable leg provided to level the insert should the hearth of the ...

Page 9 - Direct-Vent Fireplace Insert Vent Requirements - Use liner; FKDVI; Installation; Figure

9 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. v ertiCal v enting The vent pipes must be connected to the proper collars on the unit and the exhaust vent pipe must be connected to the termination cap or the unit will not operate. The combustion air vent pipe can be connected to the terminati...

Page 11 - NEVER; Packaging List

11 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. 4. Install a light layer of rockwool directly over the ports. - A light layer will give a more constant rear flame. - A heavy layer will give more glow, but will need to be adjusted after light up. 5. Install front logs on retainer slots. f aCe...

Page 12 - Gas Line Installation; lp; Air Shutter Adjustment; Robertshaw Millivolt Gas Valve

1 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Gas Line Installation After leveling, position the insert in the fireplace - holding it about six inches out from its final location. Caution: Specific hearth requirements apply (see Clear- ances to Combustibles). The Ravenna™ gas insert must be...

Page 13 - Operating Instructions; Lighting Instructions; WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS

13 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Operating Instructions p re -l ighting C heCklist Be sure to check these items before the initial lighting of the insert: c The insert gas label corresponds to the gas supply avail- able - that is "natural gas" for natural gas or "L...

Page 14 - WARNINGS

14 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. WARNINGS • Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. For assistance or additional information, consult a qualified installer, service agency or your gas supplier. • Operation of t...

Page 15 - Flame Color & Behavior; Burner Flame Appearance; Paint Curing

15 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Flame Color & Behavior Your Ravenna™ gas insert is designed for maximum heat- ing efficiency. Therefore, upon lighting of the main burner the flames will be semi-transparent or “bluish.” After 10-20 minutes of operation the logs will heat u...

Page 16 - Millivolt Control; Thermostat Wire

1 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. o perating o ptions The rocker switch on your Ravenna™ gas insert is used to turn the burner on and off while the pilot is on. The rocker switch can be installed in the hole in the right side of the top surround panel or in the hole in the panel...

Page 17 - Maintenance & Servicing

17 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Maintenance & Servicing m aintenanCe C heCklist The following should only be performed by a qualified service technician. Caution: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerou...

Page 19 - INTAKE OR OUTLET VENTS.; Troubleshooting

19 SYMPTOM PROBABLE CAUSE CORRECTIVE ACTION Thin black coating (soot) forms on the viewing glass, logs, or firebox Improper log or ember placement Improper air shutter setting Not enough combus- tion air See Brick Panel and Log Set Installation on Pages 10 & 11. If there is soot in one specific ...

Page 22 - HOT WHILE IN OPERATION. DO NOT TOUCH. SEVERE BURNS MAY RESULT. KEEP; MINIMUM CLEARANCES; SAFETY / LISTING LABEL

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. MINIMUM CLEARANCES TO COMBUSTIBLES RDV40 RDV33 E = Top Facing to Bottom of Insert 35.5”(902mm) 31.5”(800mm) F = Center of Glass to Side Facing or Side Wall 25.5”(648mm) 25.5” (648mm) *J = 10.5” (267mm) Mantel to Bottom of Insert 43”(1092mm) 39”(99...

Page 23 - Lighting Label

3 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. CAUTION: YOUR COUNTRY GAS APPLIANCE MUST ALWAYS BE OPERATED WITH GLASS DOOR IN PLACE. STOP! Read the safety information above before proceeding. 1. Open the lower door. Make sure gas supply shut-off cocks are open and ON/OFF Rocker Switch is “OF...

Page 24 - WARRANTY; Natural Gas

Printed in U.S.A. © Lennox Hearth Products 007 P/N 775,18M REV. B 1/007 Lennox™ reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code informat...