Kawasaki 78410 - Manuals

Parts C Not Shown: Literature Bag 6-VOLT CHARGER Small Parts Bag Hubcap – 2 Battery Retainer 6 If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather than return this product to the store. Please save all packaging material until assembly is co...

Parts Diagram FOR MODEL 78410 6 VOLT 8 Kawasaki ® ZX-7 44 45 46 48 6 21 12 19 CHARGER 18 15 17 16 49 43 42 41 14 13 12 9 8 39 38 40 37 12 36 52 10 35 34 33 32 2 31 30 1 29 28 22 4 51 20 27 26 25 5 7 23 24 17 11 50 ASSEMBLY A MOTOR/GEARBOX ASSEMBLY SEEASSEMBLY A

Parts List E I tem No. Description Part No. Qty. 1 Battery 80008-0110 1 2 25 amp Fuse 80014-0070 1 3 Wheel Driver Screw 80006-0017 1 4 Foot Switch 80014-0022 1 5 Motor/Gearbox Assembly 74780-0640 1 6 Wiring Harness 80064-0083 1 7 Driver 80001-0247 1 8 Windshield 80063-0068 1 9 Lens Cover Set 80030-0...

10 First-Time Batter y Charging F WARNING • The battery must be handled by adults only. • Never allow children to charge the battery. Battery charging must be done by adults only. A child could be injured by the electricity involved in charging the battery. • Use of the wrong type battery, fuse or c...

Assembly Do Not Omit Any Steps. Please set aside at least 30 minutes for assembly. • Position a handlebar plug against the top end of a handlebar. • Moisten a hand grip with warm water. • Slide the hand grip onto the end of the handlebar. • Repeat this procedure to attach the other handlebar plug an...

• Lift the seat to access the battery compartment. 1 Batter y Installation H • Place the battery upright in the battery compartment. Make sure the battery connector extendstowards the rear of the vehicle. • Make sure a Power Wheels ® 25 amp fuse in good condition isinstalled in the battery. 2 Import...

Charging the Batter y I WARNING • The battery must be handled by adults only. • Never allow children to charge the battery. Battery charging must be done by adults only. A child could beinjured by the electricity involved in charging the battery. • Use of the wrong type battery, fuse or charger coul...

Batter y Handling/Care/Disposal J WARNING • The battery must be handled by adults only. • Never permit a child to handle the battery. The battery is heavy and contains sulfuricacid (electrolyte), and if dropped, couldresult in a serious injury. Read the cautionson the back panel of the battery. • Ne...

• Adult supervision is required. Children do not have the judgement necessary toavoid many accidents. Be sure that children operating this vehicle can do sosafely and that they are supervised at alltimes. • Never use on or dangerously close to steps, inclines greater than 10˚, roadways,bodies of wat...

29 STOP GO How to Operate your Vehicle L • Press down on the foot pedal to drive. • Lift your foot from the foot pedal to stop. Your Kawasaki ® ZX-7 has a patented, electronic braking system that automaticallystops the vehicle when yourchild’s foot if lifted from thepedal. • Help your child practice...

? Questions and Answers M Q. How often do I need to charge the battery? A. Charge the battery for a minimum of 18 hours after each use of the vehicle or whenever the vehicle beginsto slow down. When the vehicle is not in regular use, charge the battery at least once a month until normaluse is resume...

Problems and Solutions Guide N Problem Possible Cause Solution Vehicle does not run Undercharged battery Charge the battery. A new battery should have been charged for at least 18 hours before using the vehicle forthe first time. After first-time use, recharge battery for atleast 18 hours after each...

Authorized Ser vice Centers COLORADO COLORADO SPRINGS - Nelson Appliance Repair, Inc., 1220 E. Fillmore, 80907, (719) 635-1928 DENVER - Appliance Service, 4262 Lowell Blvd., 80211, (303) 458-1109, (800) 631-0941 (CO, WY only) DENVER (ENGLEWOOD) - Appliance Service, 3932 S. Broadway, 80110, (303) 781...