John Deere PC20235 - Manuals

Page 3 - Introduction; IMPORTANT: Read through this instruction; Installation Time; Installation Instructions

Installation Instructions OUO6084,0001B83 –19–08SEP03–1/1 Introduction IMPORTANT: Read through this instruction thoroughly and familiarize yourself withprocess before performing procedure. This instruction covers installation of Real Time Kinematic(RTK) on your STARFIRE system. OUO6043,00016F9 –19–3...

Page 4 - Parts List; PF90259 Base Station with Tripod and STARFIRE

Installation Instructions OUO6043,00016FB –19–30MAY03–1/1 Parts List PF90258 Vehicle Bundle • PF11579 Screws, Phillips #8-32, 7/16 in. (2 Used) • PF80608 Radio • PF80611 Harness, STARFIRE RTK Rover • PF80623 Bracket STARFIRE • PF80631 Antenna, Low Gain • PF80677 Cable, Antenna Extension PF90259 Base...

Page 5 - Radio Installation

Installation Instructions OUO6050,0000501 –19–16DEC03–1/11 Radio Installation N64437 –UN–12DEC03 Without TCM N64436 –UN–12DEC03 With TCM A—Screws (Four Used) B—Shroud 1. Remove four screws (A) and lower shroud (B). OUO6050,0000501 –19–16DEC03–2/11 N64438 –UN–12DEC03 Without TCM N64439 –UN–12DEC03 Wi...

Page 9 - together using care not to pinch any of the harnesses.

Installation Instructions OUO6050,0000501 –19–16DEC03–8/11 N64453 –UN–16DEC03 A—ReceiverB—BracketC—TCMD—Screw (2 Used)E—Radio HarnessF—Harness 14. Receivers with TCM:Attach receiver (A), bracket (B), and TCM (C) with screws (D). 15. Route radio harness (E) in upper receiver shroud as shown. 16. Rout...

Page 11 - Vehicle; Attach bracket on receiver to bracket on vehicle.; Set RTK Operating Mode to VEHICLE.

Installation Instructions OUO6050,00004F6 –19–03DEC03–1/2 Vehicle PC7866 –UN–26SEP03 N64444 –UN–12DEC03 1. Attach radio to receiver. (See RADIO INSTALLATION section.) 2. Attach bracket on receiver to bracket on vehicle. 3. Connect STARFIRE harness to GREENSTAR  harness. 4. Calibrate TCM. See AutoTr...

Page 13 - JOHN DEERE; IMPORTANT: Base station coordinates are stored in

Installation Instructions OUO6050,00004FA –19–10DEC03–2/3 N64444 –UN–12DEC03 CAUTION: Always attach harness to powersource before connecting STARFIRE receiverharness. Make sure power inverter has aminimum capacity of 3 amps. A smaller invertercould overheat or cause operational problems.If a battery...

Page 14 - Quick Survey Base Station; down to fully lock each leg.

Installation Instructions OUO6050,00004FB –19–10DEC03–1/4 Quick Survey Base Station N64460 –UN–16DEC03 N64459 –UN–16DEC03 A—Tripod B—Latch CAUTION: If tripod latches are loose, tightenhardware to ensure positive locking of tripodlegs. Movement of tripod can causeunexpected vehicle motion. 1. Attach ...

Page 16 - Connect STARFIRE harness to power harness.

Installation Instructions OUO6050,00004FB –19–10DEC03–3/4 N64466 –UN–18DEC03 N64444 –UN–12DEC03 4. Attach receiver to bracket. 5. Connect STARFIRE harness to power harness. CAUTION: Always attach harness to powersource before connecting STARFIRE receiverharness. It is recommended to permanentlyattac...

Page 17 - Repeater

Installation Instructions OUO6050,00004FC –19–10DEC03–1/1 Repeater N64465 –UN–18DEC03 SETUP JOHN DEERE RTK Operating Mode RTK RadioChannel (1-14) RTK Network ID(1-4000) ConfigureRepeater Radio VEHICLE GPS A B C D E F G PAGE 3 1 1 PC7983 –19–04NOV03 1. Go to either RTK vehicle or base station. 2. Pro...