Page 2 - TABLE OF CONTENTS
SECTION ONE Safety Instructions………………………….. Placement of the grill……………………….. SECTION TWO Side Burner & Side Shelf Assembly………. Side Burner Handle Assembly…………….. Battery Assembly…………………………… Side Burner Gas Hose Assembly………… Propane Tank Assembly…………………… SECTION THREE Gas Hook Up……………………………….. L...
Page 3 - RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS; WARNING
PRECAUTIONS SAFETY INSTRUCTIONS WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM . This can severely upset combustion air flow or trap excessive heat in the control ar...
Page 4 - ROTISSERIE DRIVE MOTOR
PRECAUTIONS SAFETY INSTRUCTIONS WARNING: IMPORTANT! USING THE SIDE BURNER: Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present. Keep a spray bottle of soa...
Page 5 - SAFETY INSTRUCTIONS
*** WARNING *** FOR YOUR SAFTY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call your gas supplier or your fire department. FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the ...
Page 7 - PLACEMENT OF THE GRILL
When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place of potholders....
Page 8 - SIDE SHELF & SIDE BURNER ASSEMBLY; INSTALLATION OF
SIDE SHELF & SIDE BURNER ASSEMBLY INSTALLATION OF • The screws used to attach the side shelf and side burner are already screwed into the two- side panels (see the figure below). Remove the screws from the two-side panel, align with the holes in the left side shelf, and then re-screw into the ho...
Page 9 - SIDE BURNER HANDLE ASSEMBLY
SIDE BURNER HANDLE ASSEMBLY • To assemble the side burner lid handle, open the lid first, cut off the plastic tie tied in thescrew hole. Install the handle in the lid as shown in figure below. • Take four of the side burner handle screws from hardware bag. Align the side burnerhole in the side shelf...
Page 10 - BATTERY ASSEMBLY
BATTERY ASSEMBLY • In order to install the battery, remove the ignition button housing. Please keep the positive pole of the battery facing toward you. Insert the battery into the housing. Replace the ignition button housing after battery is installed. 8
Page 11 - SIDE BURNER GAS HOSE ASSEMBLY
SIDE BURNER GAS HOSE ASSEMBLY • The side burner PVC gas hose is attached on the valve manifold inside the grill cart. Insert the gas hose to the hole on right panel of the grill. Secure it on the gas hose connector under the side burner as shown in figure below. 9
Page 12 - PROPANE TANK ASSEMBLY
PROPANE TANK ASSEMBLY • Attach propane gas tank to regulator inlet fitting by turning the regulator clockwise as shown in figure below. O P E N C LO S E g 10
Page 14 - LEAK TESTING; Adjustment Bolt
GENERAL Although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. Periodically check the w...
Page 15 - INSTALLER FINAL CHECK
INSTALLER FINAL CHECK Specified clearance maintained 24” from combustibles. All internal packaging removed. Knobs turn freely. Burners are tight and sitting properly on orifices. Pressure regulator connected and set for 11.2” W.C. LP gas. Gas connections to grill using hose & regulator assembly ...
Page 16 - OPERATING INSTRUCTIONS
2 General use of the grill and rotisserie Each main burner is rated at 15,000 BTU/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel radiant (flame tamers). The igniter knobs are ...
Page 17 - LIGHTING INSTRUCTIONS
LIGHTING INSTRUCTIONS WARNING: IMPORTANT! BEFORE LIGHTING… Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. Do not use the grill if the odor of gas is present. Only the pressure regulator and hose assembly s...
Page 18 - TO MATCH LIGHT THE GRILL
TO MATCH LIGHT THE GRILL TO MATCH LIGHT THE GRILL: If the burner will not light after several attempts then the burner can be match lit. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from...
Page 19 - LIGHTING ILLUSTRATION
LIGHTING ILLUSTRATION Main & Side Burner Lighting Illustration Rotisserie Burner Lighting Illustration 1. Make sure the lid is open 1. Push and turn the rotisserie knob to HI. 2. Push and turn one of main or side burner knobs 2. Press the electric igniter 3 to 4 seconds to to HI position light t...
Page 20 - USING THE SIDE BURNER
WARNING: IMPORTANT! USING THE SIDE BURNER: Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present. WARNING: Always keep your face and body as far away from t...
Page 21 - CHECK LIST
CARE & MAINTENANCE OF SIDE BURNER BURNER CLEANING: Clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off and clog the port. STAINLESS STEEL: There are man...
Page 22 - EXPLODED VIEW
Page 27 - GRILL RECIPE SUGGESTIONS; SALMON
25 GRILL RECIPE SUGGESTIONS BBQ SALMON 2 large salmon steaks 2 tbs. oil Salt & pepper 2 oz. thin bacon slices 2 tbs. butter 1 tbs. lemon juice Sprig of parsley Lemon wedges Note: Substitute catfish, halibut or cod for salmon. Preheat the BBQ Brush the steaks with oil and season with salt and pep...