Invacare Powered Seating - Manuals

Page 2 - WARNING; WARNING; DOCUMENT

REFERENCE DOCUMENTS Formula™ Powered Seating 2 Part No 1122170 WARNING A QUALIFIED TECHNICIAN MUST PERFORM THE INITIAL SET UP OF THIS WHEELCHAIR. ALSO, A QUALIFIED TECHNICIAN MUST PERFORM ALL PROCEDURES IN THE SERVICE MANUAL.WHEELCHAIR USERS: DO NOT SERVICE OR OPERATE THIS EQUIPMENT WITHOUT FIRST RE...

Page 3 - TABLE OF CONTENTS

TABLE OF CONTENTS Part No 1122170 3 Formula™ Powered Seating TABLE OF CONTENTS REFERENCE DOCUMENTS ................................................................. 2REGISTER YOUR PRODUCT ............................................................... 4SPECIAL NOTES ....................................

Page 4 - Ensuring long-term maintenance and servicing of your product.

TABLE OF CONTENTS Formula™ Powered Seating 4 Part No 1122170 TABLE OF CONTENTS Adjusting the Footplate Angle ...............................................................................................................48 Adjusting the Tension of the Flip Up Footplate .................................

Page 5 - SPECIAL NOTES; definitions of the signal words.; NOTICE; THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO; TRBKTS WARNINGS; SIGNAL WORD

SPECIAL NOTES Part No 1122170 5 Formula™ Powered Seating SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. Refer to the table below for definitions of the signal words. NOTICE THE INFORMATION CONTAINE...

Page 7 - LABEL LOCATIONS; All Wheelchairs; WA R N I N G; NOTE: Auto style seat

LABEL LOCATIONS Part No 1122170 7 Formula™ Powered Seating LABEL LOCATIONS NOTE: Refer to Owner’s Manual shipped with wheelchair base for additional labels located on wheelchair base. All Wheelchairs Refer to Service Manual to reposition the seat - otherwise serious personal injury and damage will r...

Page 8 - Wheelchairs with Elevate

LABEL LOCATIONS Formula™ Powered Seating 8 Part No 1122170 Wheelchairs with Elevate Wheelchairs with Ventilator Trays

Page 9 - TYPICAL PRODUCT PARAMETERS; Formula Powered Seating Systems; CONTOURA BACKS

TYPICAL PRODUCT PARAMETERS Part No 1122170 9 Formula™ Powered Seating TYPICAL PRODUCT PARAMETERS Formula Powered Seating Systems CONTOURA BACKS CONVENTIONAL BACKS SEAT WIDTH RANGE: 16 - 24 inches in 2-inch increments 16 - 24 inches in 1-inch increments SEAT DEPTH RANGE SMALL FRAME: LARGE FRAME: EXTR...

Page 11 - SECTION 1—GENERAL GUIDELINES; operation and use of this product.; Repair or Service Information; surrounding property.

SECTION 1—GENERAL GUIDELINES Part No 1122170 11 Formula™ Powered Seating SECTION 1—GENERAL GUIDELINES WARNING SECTION 1 - GENERAL GUIDELINES contains important information for the safe operation and use of this product. DO NOT use this product or any available optional equipment without first comple...

Page 13 - Invacare shall not be liable and the limited warranty is void.

SECTION 1—GENERAL GUIDELINES Part No 1122170 13 Formula™ Powered Seating ALWAYS turn the wheelchair power Off and engage the motor locks/clutches to prevent the wheels from moving before attempting to transfer in or out of the wheelchair. Also make sure every precaution is taken to reduce the gap di...

Page 14 - Weight Training

SECTION 1—GENERAL GUIDELINES Formula™ Powered Seating 14 Part No 1122170 Weight Training Invacare DOES NOT recommend the use of its wheelchairs as a weight training apparatus. Invacare wheelchairs have NOT been designed or tested as a seat for any kind of weight training. If occupant uses said wheel...

Page 15 - SECTION 2—EMI INFORMATION; CAUTION: IT IS VERY IMPORTANT THAT YOU READ THIS INFORMATION

SECTION 2—EMI INFORMATION Part No 1122170 15 Formula™ Powered Seating SECTION 2—EMI INFORMATION WARNING CAUTION: IT IS VERY IMPORTANT THAT YOU READ THIS INFORMATION REGARDING THE POSSIBLE EFFECTS OF ELECTROMAGNETIC INTERFERENCE ON YOUR POWERED WHEELCHAIR.Electromagnetic Interference (EMI) From Radio...

Page 16 - CHANCE OF UNINTENDED BRAKE RELEASE OR POWERED WHEELCHAIR

SECTION 2—EMI INFORMATION Formula™ Powered Seating 16 Part No 1122170 WARNING Powered Wheelchair Electromagnetic Interference (EMI)Because EM energy rapidly becomes more intense as one moves closer to the transmitting antenna (source), the EM fields from hand-held radio wave sources (transceivers) a...

Page 17 - SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS; SECTION 3—SAFETY/HANDLING OF; that shipped with the wheelchair base.; Pinch Points; the tilted seat to the full upright position.

SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS Part No 1122170 17 Formula™ Powered Seating SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS NOTE: For more information about safety/handling of the wheelchair, refer to the owner’s manual that shipped with the wheelchair base. Pinch Points WARNING A pinch point exis...

Page 18 - SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING; SECTION 4—SAFETY INSPECTION/; troubleshooting information.; Safety Inspection Checklists; Inspect/Adjust Initially

SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Formula™ Powered Seating 18 Part No 1122170 SECTION 4—SAFETY INSPECTION/ TROUBLESHOOTING NOTE: Every six months take your wheelchair to a qualified technician for a thorough inspection and servicing. Regular cleaning will reveal loose or worn parts and enh...

Page 19 - Inspect/Adjust Weekly

SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Part No 1122170 19 Formula™ Powered Seating ❑ Make sure seating systems with the recline function have the retaining pin in place at the top of each back cane. ❑ Make sure all systems, except Elevate Only, have the retaining pin in place at the back of eac...

Page 20 - Upholstery has no rips.; Troubleshooting; SYMPTOM

SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Formula™ Powered Seating 20 Part No 1122170 ❑ Upholstery has no rips. ❑ Armrest pad sits flush against arm tube. ❑ Inspect foam handgrips for damage. If damaged, have them replaced by a qualified technician. ❑ Check that all labels are present and legible....

Page 23 - SECTION 5—WHEELCHAIR OPERATION; SECTION 5—WHEELCHAIR; A Note About Drive Lock-Out; TILT WARNING or

SECTION 5—WHEELCHAIR OPERATION Part No 1122170 23 Formula™ Powered Seating SECTION 5—WHEELCHAIR OPERATION WARNING After ANY adjustments, repair or service and BEFORE use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.Set-up of the Electronic Cont...

Page 24 - Operating Powered Seating Systems; GENERAL WARNINGS

SECTION 5—WHEELCHAIR OPERATION Formula™ Powered Seating 24 Part No 1122170 Operating Powered Seating Systems GENERAL WARNINGS Refer to A Note About Drive Lock-Out on page 23 BEFORE performing this procedure.Pinch points may occur when returning the seat from any tilted position to the full upright p...

Page 25 - Using the Powered Seating Switch; after it has been released for a minimum of three seconds.; Using the Four Way Switch; Release four way switch to neutral position.

SECTION 5—WHEELCHAIR OPERATION Part No 1122170 25 Formula™ Powered Seating Using the Powered Seating Switch NOTE: The powered seating switch will alternate functions (increase tilt angle, decrease tilt angle) after it has been released for a minimum of three seconds. 1. Make sure the wheelchair is o...

Page 26 - Using the MPJ+ joystick; ICON

SECTION 5—WHEELCHAIR OPERATION Formula™ Powered Seating 26 Part No 1122170 FIGURE 5.1 Using the Four Way Switch Using the MPJ+ joystick NOTE: For this procedure, refer to FIGURE 5.2 on page 27. 1. Make sure the wheelchair is on a level surface.2. Select a drive that has the Actuator Control Switch M...

Page 28 - MPJ+ Joystick Switches and Indicators; Drive Select Toggle Switch; versions of DRIVE 1 and DRIVE 2.; Speed Control; programmed max speed.

SECTION 5—WHEELCHAIR OPERATION Formula™ Powered Seating 28 Part No 1122170 MPJ+ Joystick Switches and Indicators NOTE: For this procedure, refer to FIGURE 5.3. Drive Select Toggle Switch The drive select toggle switch is located on the left side, below the LCD. The drive select position is momentary...

Page 29 - Joystick; Splash Screen

SECTION 5—WHEELCHAIR OPERATION Part No 1122170 29 Formula™ Powered Seating 2. Rotate the knob counterclockwise (backward) to decrease the speed of the wheelchair to the programmed max speed. Joystick The joystick has proportional drive control, meaning that the further the joystick is pushed from th...

Page 30 - ITEM

SECTION 5—WHEELCHAIR OPERATION Formula™ Powered Seating 30 Part No 1122170 Refer to LCD Display table on page 30 for descriptions of information shown. LCD DISPLAY ITEM DESCRIPTION DRIVE NAME This field shows the currently selected Drive’s Name. Available choices are as follows: Drive 1* Drive 2* Dr...

Page 31 - LCD Display Screens - Main Screen

SECTION 5—WHEELCHAIR OPERATION Part No 1122170 31 Formula™ Powered Seating FIGURE 5.5 LCD Display Screens - Main Screen Driving Screen NOTE: For this procedure, refer to FIGURE 5.6. This screen is shown when the operator issues a drive command and the Drive Icon on the main screen was highlighted. N...

Page 32 - LCD Display Screens - Connected Devices Screen; Programmable Mono Port 1/2 or External Mode Switch; second programmable function through mono port 2.

SECTION 5—WHEELCHAIR OPERATION Formula™ Powered Seating 32 Part No 1122170 FIGURE 5.7 LCD Display Screens - Connected Devices Screen Programmable Mono Port 1/2 or External Mode Switch The programmable mono port or external mode switch input is located at the rear of the joystick on the left side. Th...

Page 33 - Mode Switch; Preparing the Joystick for Use

SECTION 5—WHEELCHAIR OPERATION Part No 1122170 33 Formula™ Powered Seating Mode Switch The mode switch is used to select the operating mode for the wheelchair. The mode switch is located on the joystick. A mode switch is needed whenever any of the following operating modes are programmed:• Environme...

Page 34 - Repositioning the Joystick

SECTION 5—WHEELCHAIR OPERATION Formula™ Powered Seating 34 Part No 1122170 Repositioning the Joystick NOTE: For this procedure, refer to FIGURE 5.9. 1. Turn the adjustment lock lever to release the joystick mounting tube from the mounting bracket. 2. Remove the joystick from the wheelchair.3. Remove...

Page 35 - SECTION 6—FRONT RIGGINGS; Installing/Removing Footrests; footplate is perpendicular to

SECTION 6—FRONT RIGGINGS Part No 1122170 35 Formula™ Powered Seating SECTION 6—FRONT RIGGINGS WARNING After ANY adjustments, repair or service and BEFORE use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.For the following procedures, make sure t...

Page 36 - NOTE: The footplate will be on the inside of the; Footrest Height Adjustment

SECTION 6—FRONT RIGGINGS Formula™ Powered Seating 36 Part No 1122170 70° Taper NOTE: For this procedure, refer to FIGURE 6.2 1. Turn the footrest to the side (open footplate is perpendicular to wheelchair). 2. Insert footrest mounting pin into mounting tube. 3. Push the footrest towards the inside o...

Page 37 - NOTE: Lay the footrest on a flat surface to simplify this procedure.

SECTION 6—FRONT RIGGINGS Part No 1122170 37 Formula™ Powered Seating 70° and PW93 NOTE: For this procedure, refer to FIGURE 6.4. 1. Remove any accessory from the footrest(s).2. Remove the footrest from the wheelchair. Refer to Installing/Removing Footrests on page 35. NOTE: Lay the footrest on a fla...

Page 38 - frame mounting tubes.; Raising/Lowering Elevating Front Riggings; Raising/Lowering Elevating; Adjusting/Replacing Telescoping Front Rigging Support; damage to the wheelchair and surrounding property may result.

SECTION 6—FRONT RIGGINGS Formula™ Powered Seating 38 Part No 1122170 NOTE: Make sure spacers are positioned properly when reassembling to prevent damage to the frame mounting tubes. 6. Reinstall the footrest(s) onto the wheelchair. Refer to Installing/Removing Footrests on page 35. 7. Reinstall any ...

Page 40 - Installing Adjustable Angle Flip-up Footplate Hinge; NOTE: The footplate hinge will fall to the down; Installing Adjustable Angle

SECTION 6—FRONT RIGGINGS Formula™ Powered Seating 40 Part No 1122170 Installing Adjustable Angle Flip-up Footplate Hinge NOTE: For this procedure, refer to FIGURE 6.8. 1. Position footplate hinge on the footrest support tube at the desired height. 2. Position mounting screw, washers, spacer, and loc...

Page 41 - Adjusting Adjustable Angle Flip-Up Footplates; Depth Adjustment; NOTE: Observe the angle of the footplate for reinstallation.; Angle Adjustment; Perpendicular and/or Inversion/Eversion Adjustment; footplate to perform this adjustment.

SECTION 6—FRONT RIGGINGS Part No 1122170 41 Formula™ Powered Seating Adjusting Adjustable Angle Flip-Up Footplates Depth Adjustment NOTE: For this procedure, refer to FIGURE 6.9 on page 40. 1. Remove the two flat screws, washers and locknuts that secure footplate to the half clamp. NOTE: Observe the...

Page 42 - Composite/Articulating Footplate Heel Loop; Disassembly; Assembly; Composite/Articulating

SECTION 6—FRONT RIGGINGS Formula™ Powered Seating 42 Part No 1122170 Composite/Articulating Footplate Heel Loop Replacement NOTE: For this procedure, refer to FIGURE 6.12. Disassembly Composite 1. Remove the mounting screw and coved washer that secures the lower half of the footrest to the swingaway...

Page 43 - Installing/Removing Elevating Legrests; Installing; Installing/Removing Elevating

SECTION 6—FRONT RIGGINGS Part No 1122170 43 Formula™ Powered Seating Installing/Removing Elevating Legrests NOTE: For this procedure, refer to FIGURE 6.13. Installing 1. Turn legrest to side (open footplate is perpendicular to wheelchair). 2. Install the legrest hinge plates onto the hinge pins on t...

Page 44 - Raising/Lowering Elevating Legrests and/or Adjusting

SECTION 6—FRONT RIGGINGS Formula™ Powered Seating 44 Part No 1122170 Raising/Lowering Elevating Legrests and/or Adjusting Calfpads NOTE: For this procedure, refer to FIGURE 6.14. Raising/Lowering Elevating Legrests 1. Perform one of the following: • Raising - Pull back on the release lever until the...

Page 45 - Removing/Installing the Center Mount Footrest; Removing; Power Center Mount Footrests

SECTION 6—FRONT RIGGINGS Part No 1122170 45 Formula™ Powered Seating Removing/Installing the Center Mount Footrest NOTE: For this procedure, refer to FIGURE 6.15 on page 46. Removing Power Center Mount Footrests 1. Remove the short quick-release pin that secures the center mount rigging to the link ...

Page 46 - bracket of the seat frame.

SECTION 6—FRONT RIGGINGS Formula™ Powered Seating 46 Part No 1122170 2. Reinstall the rigging pivot pin to secure the center mount footrest to the mounting bracket of the seat frame. FIGURE 6.15 Removing/Installing the Center Mount Footrest Release Lever Rigging Pivot Pin Center Mount Footrest Seat ...

Page 47 - Adjusting the Height of the Center Mount Footrest; extension tube housing.

SECTION 6—FRONT RIGGINGS Part No 1122170 47 Formula™ Powered Seating Adjusting the Height of the Center Mount Footrest WARNING While the wheelchair is moving, minimum ground clearance for the front rigging is three inches. If the wheelchair is not moving, the front rigging MUST maintain a minimum of...

Page 48 - Adjusting the Angle of the Manual Center Mount; NOTE: Refer to FIGURE 6.16 for the location; Adjusting the Footplate Angle; Adjusting the Footplate

SECTION 6—FRONT RIGGINGS Formula™ Powered Seating 48 Part No 1122170 Adjusting the Angle of the Manual Center Mount Footrest WARNING While the wheelchair is moving, minimum ground clearance for the front rigging is three inches. If the wheelchair is not moving, the front rigging MUST maintain a mini...

Page 49 - Loosen the footplate mounting screw; Adjusting the Tension of the Flip Up Footplate; NOTE: DO NOT remove the footplate mounting screw.

SECTION 6—FRONT RIGGINGS Part No 1122170 49 Formula™ Powered Seating Before 2/15/07 NOTE: For this procedure, refer to FIGURE 6.19. 1. Loosen the footplate mounting screw and move the footplate to the desired angle. NOTE: DO NOT remove the footplate mounting screw. 2. Tighten the footplate mounting ...

Page 50 - Calf Pad Adjustment for Power Center Mount Footrests; Adjusting the Height of the Center Mount Footrest on page 47.; the carriage assembly.

SECTION 6—FRONT RIGGINGS Formula™ Powered Seating 50 Part No 1122170 Calf Pad Adjustment for Power Center Mount Footrests NOTE: For this procedure, refer to FIGURE 6.21 on page 50.NOTE: Ensure footrest height has been adjusted before performing this procedure. Refer to Adjusting the Height of the Ce...

Page 51 - Height and Width Adjustment; the carriage assembly. If there is interference, readjust calf pad.; Installing/Removing the Power Elevating Legrests; ing and lowering, otherwise damage to the power legrests may occur.; Installing the Power Elevating Legrests; NOTE: Make sure the legrest sits flush on the seat frame.

SECTION 6—FRONT RIGGINGS Part No 1122170 51 Formula™ Powered Seating Height and Width Adjustment 1. Remove the two height/width adjustment screws securing the calf pad to the calf pad mounting bracket. 2. Move the calf pad to the desired position.3. Install the two height/width adjustment screws to ...

Page 52 - Removing the Power Elevating Legrests

SECTION 6—FRONT RIGGINGS Formula™ Powered Seating 52 Part No 1122170 5. Connect power legrest connector to jumper cable (Detail “B” of FIGURE 6.22). Removing the Power Elevating Legrests 1. Disconnect power legrest connector from jumper cable.2. Push legrest release handle and swing legrest to the o...

Page 53 - SECTION 7—ARMS; Installing/Removing Flip Back Armrests; locked position before using the wheelchair.; Installing/Removing Flip Back

SECTION 7—ARMS Part No 1122170 53 Formula™ Powered Seating SECTION 7—ARMS WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result. Installing/Removing Flip Back Armrests WARNING Make sure the...

Page 54 - Adjusting Flip Back Armrests; Positioning Flip Back Armrests for User Transfer; Armrest release lever MUST remain in; Positioning Flip Back Armrests for Use

SECTION 7—ARMS Formula™ Powered Seating 54 Part No 1122170 Adjusting Flip Back Armrests WARNING Make sure the flip back armrest release and height adjustment levers are in the locked position before using the wheelchair. NOTE: For this procedure, refer to FIGURE 7.2. Positioning Flip Back Armrests f...

Page 55 - Removing/Installing Reclining Armrests; Removing Armrests; remove the armrest from the seat; Installing Armrests; Position the armrest on the seat frame

SECTION 7—ARMS Part No 1122170 55 Formula™ Powered Seating Removing/Installing Reclining Armrests NOTE: For this procedure, refer to FIGURE 7.3. Removing Armrests 1. Lift the armrest release lever at the front of the wheelchair to the unlocked (horizontal) position. 2. Lift up on the armrest and rem...

Page 56 - Adjusting Reclining Armrest Height; Powered Seating Systems on page 58.

SECTION 7—ARMS Formula™ Powered Seating 56 Part No 1122170 Adjusting Reclining Armrest Height NOTE: For this procedure, refer to FIGURE 7.4 on page 57. 1. Make sure the seating system is in the full upright position. Refer to Operating Powered Seating Systems on page 58. 2. Remove the socket bolt an...

Page 58 - SECTION 8—SEAT; be replaced immediately.; Adjusting the Back Angle

SECTION 8—SEAT Formula™ Powered Seating 58 Part No 1122170 SECTION 8—SEAT WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.ALWAYS wear your seat positioning strap. The seat positioning...

Page 59 - Replacing Seat Positioning Strap; secure the seat positioning straps to the seat frame.

SECTION 8—SEAT Part No 1122170 59 Formula™ Powered Seating Replacing Seat Positioning Strap NOTE: For this procedure, refer to FIGURE 8.2. 1. Remove the seat cushion from the seat pan.2. Move the flip back armrests out of the way. Refer to Adjusting Flip Back Armrests on page 54. 3. Remove the two m...

Page 60 - SECTION 9—HEADREST; Headrest

SECTION 9—HEADREST Formula™ Powered Seating 60 Part No 1122170 SECTION 9—HEADREST WARNING After ANY adjustments, repair or service and before use, make sure all attaching hardware is tightened securely - otherwise injury or damage may result. CAUTION If using a ventilator, verify headrest support do...

Page 61 - Adjusting Headrest Height; headrest mounting bracket.; Adjusting Headrest Depth/Direction; Replacing Headrest; existing three socket screws.; headrest shown for

SECTION 9—HEADREST Part No 1122170 61 Formula™ Powered Seating Adjusting Headrest Height 1. Loosen the set screw on the headrest stop.2. Loosen, but DO NOT remove, the thumb screw that secures the headrest to the headrest mounting bracket. 3. Position the headrest to the desired height.4. Tighten th...

Page 62 - SECTION 10—ELEVATE BATTERIES; Warnings for Handling and Replacing Batteries; cable mounting screw.

SECTION 10—ELEVATE BATTERIES Formula™ Powered Seating 62 Part No 1122170 SECTION 10—ELEVATE BATTERIES NOTE: This section contains information about batteries in seating systems with elevate. Refer to the owner’s manual supplied with the wheelchair base for other battery information. Warnings for Han...

Page 63 - Using the Proper Batteries; Replacing Batteries; POSITIVE battery terminal.

SECTION 10—ELEVATE BATTERIES Part No 1122170 63 Formula™ Powered Seating Using the Proper Batteries 1. Position battery on ground/flat surface as shown below.2. Visually inspect the battery to ensure proper polarity: WARNING 22NF Batteries with terminal configuration (POSITIVE on the left and NEGATI...

Page 64 - battery post of the battery

SECTION 10—ELEVATE BATTERIES Formula™ Powered Seating 64 Part No 1122170 6. Remove the locknut that secures the NEGATIVE battery cable to the NEGATIVE(-) battery post of the battery 7. Discard the existing battery.8. Position battery connector bracket or wiring harness onto the new 22NF or GP24 batt...

Page 65 - NOTE: Only battery cable

SECTION 10—ELEVATE BATTERIES Part No 1122170 65 Formula™ Powered Seating FIGURE 10.1 Replacing Batteries 22NF Batteries BATTERY COVER AND TIE-WRAP DETAIL Seating System with Elevate BLACK Battery Terminal Cover BLACK Battery Terminal Cover RED Battery Terminal Cover RED Battery Terminal Cover Tie-Wr...

Page 66 - Cleaning Battery Terminals; Carefully dust off all metal particles.; Removing/Installing the Batteries From/Into the; Removing the Battery Door and Rear Shrouds; out risking damage to carpeting or floor covering.

SECTION 10—ELEVATE BATTERIES Formula™ Powered Seating 66 Part No 1122170 Cleaning Battery Terminals WARNING Most batteries are not sold with instructions. However, warnings are frequently noted on the cell caps. Read them carefully.DO NOT allow the liquid in the battery to come in contact with skin,...

Page 67 - support bracket to the battery box.

SECTION 10—ELEVATE BATTERIES Part No 1122170 67 Formula™ Powered Seating 7. TRBKTS Options Only - Perform the following steps (Detail “B”): A. Remove the four screws and four locknuts (if applicable) that secure the battery support bracket to the battery box. B. Remove the battery support bracket. 8...

Page 68 - Removing the Batteries; Installing Batteries; battery box as shown.; cables not shown for

SECTION 10—ELEVATE BATTERIES Formula™ Powered Seating 68 Part No 1122170 Removing the Batteries NOTE: For this procedure, refer to FIGURE 10.3. 1. Grasp and pull the YELLOW battery connector tab to unplug the front battery.2. Slide the front battery FORWARD and remove it from the battery box.3. Gras...

Page 69 - Installing the Battery Door and Rear Shroud; battery door are fully engaged into the side of the battery box.; troller connector - otherwise serious personal injury may result.

SECTION 10—ELEVATE BATTERIES Part No 1122170 69 Formula™ Powered Seating FIGURE 10.4 Installing Batteries Installing the Battery Door and Rear Shroud WARNING Wheelchairs with TRRO or TRBKTS Only - Battery support brackets MUST be installed at all times. Otherwise, the wheelchair will not be WC/19 co...

Page 70 - When to Charge Batteries; As the battery becomes discharged, the; Charging Batteries; explosive in the right concentration with air.; CAUTION; wheelchair will not be used for a long period of time.

SECTION 10—ELEVATE BATTERIES Formula™ Powered Seating 70 Part No 1122170 4. Connect the controller to the batteries at the rear of the wheelchair.5. Wheelchairs with TRBKTS Only - Reinstall the top controller shroud using the two thumb screws (Detail “B” of FIGURE 10.2 on page 67). 6. Reinstall the ...

Page 71 - Description and Use of Battery Chargers; when full charge is obtained.; may need to be replaced. Contact an Invacare dealer for service.

SECTION 10—ELEVATE BATTERIES Part No 1122170 71 Formula™ Powered Seating The range per battery charge using recommended batteries should be approximately 5 to 9 hours of typical operation. Extensive use on inclines may substantially reduce per charge mileage. Description and Use of Battery Chargers ...

Page 73 - SECTION 11—VENTILATOR TRAY; Preparing the Ventilator Tray for Use; capacity for vent tray - otherwise, injury or damage may occur.; additional requirements.

SECTION 11—VENTILATOR TRAY Part No 1122170 73 Formula™ Powered Seating SECTION 11—VENTILATOR TRAY WARNING After ANY adjustments, repair or service and BEFORE use, make sure all attaching hardware is tightened securely - otherwise injury or damage may occur.Before adjusting, repairing or servicing th...

Page 74 - assembly interferes with the ventilator tray.

SECTION 11—VENTILATOR TRAY Formula™ Powered Seating 74 Part No 1122170 7. Connect the ventilator battery harness connector to the ventilator battery harness extension (Detail “A”). 8. Wheelchairs with recline systems only - Perform the following steps: A. Test the recline function of the seating sys...

Page 75 - GLOBAL LIMITED WARRANTY (EXCLUDING CANADA); GLOBAL LIMITED WARRANTY

GLOBAL LIMITED WARRANTY (EXCLUDING CANADA) Part No 1122170 75 Formula™ Powered Seating GLOBAL LIMITED WARRANTY (EXCLUDING CANADA) PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975. This warranty is extended only to the ...

Page 76 - CANADA LIMITED WARRANTY

CANADA LIMITED WARRANTY PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975. This warranty is extended only to the original purchaser who purchases this product within Canada when new and unused from Invacare or a dealer....