Infinity Bass Link - Manuals

Infinity Bass Link – Manual in PDF format online.

Manuals:

Manual

Manual Infinity Bass Link

Summary

Page 2 - Contents; ALL MODELS BASSLINK

Contents ALL MODELS BASSLINK SPECIFICATIONS …………………………………………..……………2 CONNECTIONS/APPLICATIONS ………………………………………3 TUNING BASSLINK…………………………………………………….…6 TROUBLESHOOTING ……………………………………………………7 TEST SETUP PROCEDURE ……………..………..……………………8 BASSLINK (Original version without Remote Level Control jack) SERVICE...

Page 3 - Basslink; Specifications

Basslink /Basslink X Specifications BASSLINK/BASSLINK w/ Remote Level Control/BASSLINK X Amplifier Power: 200W RMS @10% THD120W RMS @1% THD Frequency Response: 20Hz – 120Hz THD @ 30W 1.0% Input Sensitivity: 50mV – 4V Line-Level Input 1V – 16V Universal Interface Maximum Input Sensitivity 7mV Line-Le...

Page 4 - OWER; BassLink

3 Connect power to BassLink, as shown in Figure 5.Also observe these installation tips: • Use at least #12 AWG wire for the +BATT (+12 Vdc) and GND (ground) connections. Ifneeded, use at least a #20 AWG wire for theREM (remote) connection. • Route all power wires through a grommet in the vehicle’s f...

Page 7 - ONTROLS AND

6 BassLink provides several controls and indicatorsthat simplify sonic integration with virtually anyvehicle’s unique acoustic properties. They arelocated on the front and side panels, as shown inFigures 11 and 12. Figure 11. BassLink controls on the front panel. POWER LED: This indicator will glow ...

Page 8 - TROUBLESHOOTING; POWER LED is lit but there is no bass.; JACK

Basslink /Basslink X TROUBLESHOOTING • PROBLEM: POWER LED not lit. CAUSES and SOLUTIONS:1. Fuse is blown and needs replacement.2. Head unit not functioning properly. Checkremote voltage, and power, ground orremote connections. • PROBLEM: POWER LED is lit but there is no bass. CAUSES and SOLUTIONS:1....

Page 9 - BassLink/BassLink X; Sweep Function; Test Set Up Procedure

BassLink/BassLink X 8 Equipment needed:• Function/signal generator/sweep generator• Integrated/Power Amplifier (capable of driving 2 ohm loads)• 14 volt DC power supply 20A or greater with current-limit protection• Multimeter• RCA cable, Universal Interface molex connector, Speaker cables General Un...

Page 10 - (Original version without remote

Basslink (Original version without remote level control jack) 9

Page 11 - Service Bulletin; only; Models

Infinity Systems Inc. 250 Crossways Park Dr. W oodbury, New York 11797 (516) 496-3400 Service Bulletin Service Bulletin INF2000-03 - October 2000 W arranty labor rate: MINOR repair To: All Infinity Service Centers Model: Basslink (version w/o AUTO-ON switch or REMOTE GAIN) Subject: Unit will not tur...

Page 23 - Power Amp PCB

Page 25 - Reference Designator

BassLink 24 Electrical Parts List Main PCBResistors11016472j26 R212,R217,R281,R282,R283,R284 8 RES,CB 4.7K 1/6W ±5% R260,R288 11016103j26 R117,R118,R119,R122,R123,R124 22 RES,CB 10K 1/6W ±5% R132,R133,R137,R138,R140,R166R167,R168,R201,R204,R208,R213R265,R266,R269,R270 11016470j26 R165 1 RES,CB 47 Ω ...

Page 26 - Pin spk Wires conn Asy

BassLink 25 Electrical Parts List (Cont.) 1353476m16 C123,C124 2 CAP, E 47U 16V ±20% 1302b221k503 C202,C204,C219 3 CAP, CA Disc 220p 50V ±10% 132103ja03 C155,C156 2 CAP, MY 0.01V 100V ±5% Semiconductors19006m45581 U201 1 I.C. NJRC NJM4558LD Dual Op-Amp 19510204gd LD1 1 LED, 3mm Green 192027c1815gr Q...

Page 27 - GAIN

BassLink 26 Electrical Parts List (Cont.) 11016104j26 R114,R150 2 RES, CB 100K 1/6W ±5% 11016100j26 R109 1 RES, CB 10 Ω 1/6W ±5% 11016123j26 R104 1 RES, CB 12K 1/6W ±5% 11016562j26 R100 1 RES, CB 5.6K 1/6W ±5% 11016183j26 R152 1 RES, CB 18K 1/6W ±5% 11016471j26 R153 1 RES, CB 470 Ω 1/6W ±5% Capacito...

Page 29 - Semiconductors

BassLink Electrical Parts List (Cont.) Part# Reference Designator Qty Description Semiconductors 19016t1072dts IC1 1 I.C TL072CDT DualOp-Amp SMD 19209124126qs Q1,Q4,Q5 3 TRANS, NPN 50V 0.15A 2SC2412K 19209139066qs Q2,Q8 2 TRANS, NPN 120V 005A 2SC3906K 19209210376qs Q7,Q9 2 TRANS, PNP 50V 0.15A 2SA10...

Page 34 - W arranty labor rate: MINOR repair; used for solder removal), or a short piece of 14 or 12 gauge buss wire.

33 Service Bulletin Service Bulletin INF2003-01 - January 2003 W arranty labor rate: MINOR repair To: All Infinity Service Centers Model: Basslink (version w/ LC - Remote Level Control); Basslink X Subject: Dead or No Power In the event you receive a Basslink subwoofer with the complaint: “The unit ...

Page 37 - Block Diagram

Page 40 - Main PCB

Page 45 - LED Green 3mm FOR ON

BASSLINK (w Level Control jack) ELECTRICAL PARTS LIST BASSLINK X Part# Description Qty Description Main PC Board Assembly Resistors 11016000j26 R170,171,172 3 RES, 0 ohms 1/6W ±5% CF 26mm 11016101j26 R129,131 2 RES, 100 ohms 1/6W ±5% CF 26mm 11016102j26 R136 1 RES, 1K 1/6W ±5% CF 26mm 11016103j26 R1...

Page 48 - 2Pins Multi Wires Connector Ass'y

Part# Description Qty Description 11016333j26 R253,277 2 RES, 33K 1/6W ±5% CF 26mm 11016392j26 R224 1 RES, 3.9K 1/6W ±5% CF 26mm 11016393j26 R223 1 RES, 39K 1/6W ±5% CF 26mm 11016432j26 R279 1 RES, 4.3K 1/6W ±5% CF 26mm 11016472j26 R275,276 2 RES, 4.7K 1/6W ±5% CF 26mm 11016473j26 R257,273,290 3 RES...

Page 49 - Inductor 35uH

Part# Description Qty Description 11812062701j R10 1 RES, 2.7K 1206 5% 11812063000j R24 1 RES, 300 ohms 1206 5% 11812063301j R14,15,27,28 4 RES, 3.3K 1206 5% 11812063902j R3 1 RES, 39K 1206 5% 11812064700j R8 1 RES, 470 ohms 1206 5% 11812064701j R1,5,12 3 RES, 4.7K 1206 5% 11812064702j R17 1 RES, 47...

Page 50 - CERAMIC ISOLATOR

Part# Description Qty Description 162a600d001 1 ACESSRY WIRE 6000mm 162a600d002 1 ACESSRY WIRE 6000mm 193201815t2 Q10,1 2 CERAMIC ISOLATOR 600n8402000 T/C TO L/C-13 13 SCREW 4*20 602p8300800 R/P TO PS-1 1 SCREW M3*8 602p8301200 R/P TO T/L COVER-6 6 SCREW M3*12 602p8301600 H/S TO DS-100 PCB-1 1 SCREW...

Page 52 - Schematics; Main/Tone Control/Switching Controller Part1

Schematics Main/Tone Control/Switching Controller Part1 51

Page 53 - Main/Tone Control/Switching Controller Part2

Page 56 - Integrated Circuit Diagrams

55 Integrated Circuit Diagrams TRANS NPN, PNP 2SD669A, 2SB649AQ117, 118 E C B TRANS, NPN 2SC2412K, 2SC3906K PNP, 2SA1514K, 2SA1037K 2SC1815GR, 2SA965YQ1, 2, 3, 4, 5, 6, 7, 8, 9 OPAMP, DUAL 8 PIN, TLO72IC1 BEVEL MOSFET IRFZ44/STP55NE06 Q111, 112 1. G 2. D3. S 1 2 3 1 2 3 MOSFET, TO220 IRF640, 9640 Q1...