Ice-O-Matic IOD16022 - Manuals

Page 2 - Keep this manual for future reference.

IOD16022 Introduction IOD22030 Page 1 To the owner or user: This product manual is a source of information about the installation, start up,cleaning, maintenance and repair of the product. The IOD16022 and IOD22030 are ice only counter top dispensers designed to use 22 inch wide and30 inch wide resp...

Page 3 - Specifications IOD22030; air cooled

IOD16022 Specifications IOD22030 Page 2 Limitations: Must meet the same limitations as the cuber installed on top of it: 50 ° F. air minimum 100 ° F. air maximum Must be installed indoors. Must allow at least 6 inch clearance at the rear and both sides when using an air cooled ice machine. Must allo...

Page 5 - Installation: General IOD22030; Equipment Description

IOD16022 Installation: General IOD22030 Page 4 Equipment Description The IOD16022 and IOD22030 are counter top mounted ice only dispensers. These units aredesigned to dispense cube ice only and have ice storage capacities of 160 lb. and 220 lb.respectively. Site Preparation The site chosen for the d...

Page 6 - Dispenser Installation

IOD16022 Installation: General IOD22030 Page 5 Drain Line Installation (Dispenser) Connect a ¾” ID flexible drain hose to the drain nipple located under the ice storage bin. Clamp the hose in placeand insulate the hose to prevent condensation. Connect a ¾” ID flexible drain hose to the drain tube at...

Page 7 - Final Preparation; section of the instructions.

IOD16022 Installation: General IOD22030 Page 6 Final Preparation Install the drain pan on the dispenser by engaging the slots in the metal backplate of the drain panonto the brackets protruding from the lower left and right hand corners of the dispenser front. Pushdown on the drain pan to lock it in...

Page 8 - Ice Machine Installation; 2 inch wide ice machine on a 22-inch wide dispenser.; Completion; Make a final check for any leaks and correct as necessary.

IOD16022 Installation: General IOD22030 Page 7 Ice Machine Installation Make sure the counter the dispenser is place on is structurally able to hold the combined weight of thedispenser, ice and ice machine. Remove the dispenser cover. (Retain for future use) Place the appropriate stainless steel KBT...

Page 9 - Cleaning and Sanitizing IOD22030; The dispenser; must; Lift up and remove the grill from the sink.; Do not use abrasive type cleaners.

IOD16022 Cleaning and Sanitizing IOD22030 Page 8 The dispenser must be cleaned and sanitized periodically as prescribed by local health authority or the product supplier, which ever has jurisdiction. Ice-O-Matic recommends the dispenser be cleanedand sanitized at least monthly if not specified by lo...

Page 10 - Sanitize the ice storage system; Disconnect power to the dispenser and ice machine.

IOD16022 Cleaning and Sanitizing IOD22030 Page 9 Monthly And Initial Start-Up: Sanitize the ice storage system Disconnect power to the dispenser and ice machine. Remove the dispenser front cover plate in front of the ice machine and discard all remaining ice, Mix a solution of 1 ounce of household b...

Page 11 - Service Diagnosis/Electrical Sequence IOD22030

IOD16022 Service Diagnosis/Electrical Sequence IOD22030 Page 10 Service Diagnosis PROBLEM PROBABLE CAUSE CORRECTION Will not dispense No ice in hopper Fill bin with ice ice Vend switch does not close Check vend switch, replace if open Drive motor not working Check drive motor, replace if not working...

Page 12 - TABLE OF CONTENTS

IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Page 11 This parts list contains the service parts available for the IOD16022 and IOS22030 ice only dispenser. Check the model number on the data plate and refer to the correct column listing for the specificdispenser. These two models share many ...

Page 13 - Cabinet

IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Page 12 Cabinet

Page 15 - Cabinet Front

IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Page 14 Cabinet Front

Page 17 - Control Box

IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Page 16 Control Box

Page 19 - Ice Door and Solenoid Assembly

IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Page 18 Ice Door and Solenoid Assembly

Page 20 - Ice Door And Solenoid Assembly

IOD16022 IOD16022 and IOD2230 Service Parts IOD22030 Page 19 Ice Door And Solenoid Assembly IOD16022 IOD22030 Item Number Part Number Part Number Description 1 3A34801001 3A34801001 Ice Door 2 1061400000 1061400000 Cotter Pin (6 Req.) 3 3002308902 3002308902 Solenoid Link 3000463000 3000463000 Solen...