Page 3 - DANGER; READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE USING
©2021 Hestan Commercial Corporation 2 EN IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH. Do not try lighting this appliance without reading the LIGHTING INSTRUCTIONS section of this manual. For outdoor use ...
Page 4 - TABLE OF CONTENTS
©2021 Hestan Commercial Corporation 3 EN 4 MODEL NUMBERS 5 RATING LABELS 5 PRECAUTIONS 7 REGULATORY / CODE REQUIREMENTS 7 PORTABLE LP CYLINDERS 8 LOCATION AND ASSEMBLY 10 INSTALLATION 13 GAS CONNECTIONS 18 ELECTRICAL CONNECTIONS 20 LIGHTING INSTRUCTIONS 22 USING YOUR GRILL 23 CLEANING AND MAINTENANC...
Page 5 - FREESTANDING MODELS; Description; MODEL NUMBERS
©2021 Hestan Commercial Corporation 4 EN BUILT-IN MODELS Model No. Description EABR30-NG / -LP 30” BUILT-IN (ALL U-BURNERS w/ ROTISSERIE) EAB30-NG / -LP 30” BUILT-IN (ALL U-BURNERS) EMBR30-NG / -LP 30” BUILT-IN (SEAR AND U-BURNERS w/ ROTISSERIE) EMB30-NG / -LP 30” BUILT-IN (SEAR AND U-BURNERS) EABR3...
Page 6 - PRECAUTIONS - BEFORE YOU USE YOUR GRILL; Grill rating label; RATING LABEL
©2021 Hestan Commercial Corporation 5 EN The rating label contains important information about your appliance such as the model and serial number, gas type and manifold pressure, the BTU rating for each burner type, and the minimum installation clearances. PRECAUTIONS - BEFORE YOU USE YOUR GRILL Whe...
Page 8 - Natural Gas and Propane Installation code; WARNING; PORTABLE LP GAS CYLINDERS
©2021 Hestan Commercial Corporation 7 EN 29. Never use charcoal, pellets, wood, or any other solid fuel in the grill. Wood chips for smoking are to be used with the smoker accessory only. See the SMOKER section of this manual. 30. Only certain types of glass, heatproof glass-ceramic, earthenware, or...
Page 9 - LOCATING AND ASSEMBLING THE GRILL; LOCATION
©2021 Hestan Commercial Corporation 8 EN LOCATING AND ASSEMBLING THE GRILL LOCATION When determining a suitable location for your grill, take into account concerns such as exposure to wind, rain, sprinklers, proximity to traffic paths, and keeping any gas supply line runs as short as possible. Locat...
Page 10 - COOKING GRATES
©2021 Hestan Commercial Corporation 9 EN Ensure that the burners are positioned correctly on their orifices, and are fully seated onto their rear hanger brackets (see Fig. 2). The burners should not move side-to-side or front-to-back if properly seated. Above each U-burner is a stainless steel radia...
Page 11 - NON-COMBUSTIBLE CONSTRUCTION; CLEARANCES; TO NON-COMBUSTIBLE CONSTRUCTION; ISLAND VENTILATION OPENINGS; SIDE VIEW
©2021 Hestan Commercial Corporation 10 EN INSTALLATION - NON-COMBUSTIBLE CONSTRUCTION CLEARANCES TO NON-COMBUSTIBLE CONSTRUCTION A minimum of 4” [10 cm] clearance from the back of the grill to non-combustible construction is required to allow the hood to be opened fully. Note: The diagrams on the fo...
Page 12 - LAYOUT FOR; TOP VIEW; FRONT VIEW
©2021 Hestan Commercial Corporation 11 EN W H D LAYOUT FOR NON-COMBUSTIBLE ENCLOSURE (ISLAND) 36.0 91.4 REF. 3.5" [8.9] SQUARE OPENING FOR ELECTRICAL 2.5 6.4 MIN. OPENING FOR ACCESS DOORS 3.5" [8.9] SQUARE OPENING FOR GAS SUPPLY 18.8 47.8 1.2 3 1.5 3.8 0.8 2.1 6.50 REF. 16.5 TOP VIEW TYPICAL...
Page 13 - COMBUSTIBLE CONSTRUCTION; TO COMBUSTIBLE CONSTRUCTION
©2021 Hestan Commercial Corporation 12 EN INSTALLATION - COMBUSTIBLE CONSTRUCTION CLEARANCES TO COMBUSTIBLE CONSTRUCTION This appliance should NOT be installed over, under or next to unprotected combustible construction. If your enclosure (island) is combustible, then an insulated jacket manufacture...
Page 15 - VENTILATION AND OVERHEAD CONSTRUCTION; The vent hood is wall-mounted and must NOT be; THE VENT HOOD MUST BE TURNED ON AT ALL TIMES WHEN THE GRILL IS ON.
©2021 Hestan Commercial Corporation 14 EN INSTALLATION - VENTILATION AND OVERHEAD CONSTRUCTION In certain installations, such as an island located against your home or other structure, or perhaps a short roof overhang above your grill, a “range-hood” style ventilation unit may be desirable to direct...
Page 16 - GAS SUPPLY; CONVERSION KITS; GAS CONNECTIONS
©2021 Hestan Commercial Corporation 15 EN GAS SUPPLY The local gas authority or supplier should be consulted at the installation planning stage in order to establish the availability of an adequate supply of gas (NG or LP). If it is a new installation, have the gas authorities or supplier check the ...
Page 17 - To connect the regulator / hose; CYLINDER
©2021 Hestan Commercial Corporation 16 EN 1/2” ID FLEX HOSE & NIPPLE (SUPPLIED BY CUSTOMER) NAT GAS REGULATOR (SHIPPED LOOSE) INCOMING NAT GAS SUPPLY SHUTOFF VALVE (SUPPLIED BY CUSTOMER) TYPICAL ASPIRE GRILL (36” MODEL SHOWN) Your Aspire grill for use with Natural Gas is supplied with its own re...
Page 18 - To connect the regulator / hose assembly follow these steps:; GAS CONNECTION - LP PIPED SYSTEMS; LEAK TESTING; GENERAL
©2021 Hestan Commercial Corporation 17 EN GAS CONNECTIONS (continued) To connect the regulator / hose assembly follow these steps: 1. Locate the regulator and gas connection point in the rear right side of your grill (in cart-mounted models, remove the rear panel to gain access). 2. Connect the 3/8”...
Page 19 - BEFORE TESTING; TO TEST; U-BURNER FLAME ADJUSTMENT
©2021 Hestan Commercial Corporation 18 EN BEFORE TESTING BEFORE TESTING• Do not smoke while leak testing.• Never leak test with an open flame.• Make a soap solution of one part liquid detergent and one part water for leak testing purposes.• Apply the solution to the gas fittings by using a spray bot...
Page 20 - AIR SHUTTER ADJUSTMENT; Light the burner and adjust as follows:; VALVE ADJUSTMENTS
©2021 Hestan Commercial Corporation 19 EN U-BURNER LOCK SCREW AIR SHUTTER AIR SHUTTER ADJUSTMENT Remove the control panel to gain access to the orifice area and air shutters on the burners. A metal cap at the inlet of the burner called the “AIR SHUTTER” regulates the amount of air that enters into t...
Page 21 - NEVER ADJUST THE BURNER SO LOW THAT IT MAY GO OUT DURING USE.; ADJUSTMENT STEPS; ELECTRICAL SUPPLY
©2021 Hestan Commercial Corporation 20 EN NEVER ADJUST THE BURNER SO LOW THAT IT MAY GO OUT DURING USE. DO NOT OPERATE THE GRILL WITH THE LOW HEAT SCREW REMOVED. GAS CAN ESCAPE AND CAUSE A POTENTIALLY HAZARDOUS CONDITION. ADJUSTMENT STEPS 1. Remove the control knobs, drip tray, and control panel fro...
Page 22 - approved for outdoor use with a W-A marking.; ELECTRICAL BOX; IMPORTANT - READ ALL INSTRUCTIONS BEFORE YOU BEGIN
©2021 Hestan Commercial Corporation 21 EN ELECTRICAL SUPPLY (continued) KEEP ANY ELECTRICAL CORD AND FUEL SUPPLY HOSE AWAY FROM ANY HEATED SURFACES. KEEP ANY ELECTRICAL CORD AND FUEL SUPPLY HOSE AWAY FROM ANY HEATED SURFACES.1. To protect against electric shock, do not immerse cord or plugs in water...
Page 23 - YOU MUST HOLD IN THE KNOB; to make the hot-surface igniters light the burners.; CONTROL KNOB LAYOUT
©2021 Hestan Commercial Corporation 22 EN ELECTRICAL SUPPLY (continued) LIGHTING INSTRUCTIONS Aspire grills feature hot-surface igniters for all U-burners, and infrared Rotisserie and Sear Burners. YOU MUST HOLD IN THE KNOB to make the hot-surface igniters light the burners. All burners can be manua...
Page 24 - PUSH & HOLD SELECTED KNOB; LIGHTING ROTISSERIE BURNER; LIGHTING INSTRUCTIONS
©2021 Hestan Commercial Corporation 23 EN LIGHTING GRILL BURNERS (U-burner or Sear Burner) 1. Read Use & Care Manual before lighting. Open lid during lighting. Stand as far away as possible when lighting. 2. PUSH & HOLD SELECTED KNOB for 5 seconds, then turn to “HIGH”. Burner should light. O...
Page 25 - USING YOUR GRILL
©2021 Hestan Commercial Corporation 24 EN PREHEATING A typical preheat time for the U-burner is about 10-15 minutes on “HIGH”. The infrared Rotisserie and Sear Burners also require 10-15 minutes pre-heat time. TEMPERATURE GAUGE The large temperature gauge in your Aspire grill hood indicates when you...
Page 26 - foods during cooking.; THE ROTISSERIE BURNER; INSTRUCTIONS section of this manual.; WOOD CHIP SMOKER; The smoker accessory is sold separately by your Hestan dealer.; CLEANING AND MAINTENANCE; STAINLESS STEEL CARE; service life of the grill.
©2021 Hestan Commercial Corporation 25 EN With the food secured to the spit, slowly roll the spit in the palms of your hands to check for balance. It should rotate smoothly. If you find it has a heavy side, adjust where the spit pierces the meat. An unbalanced spit will cause uneven rotation and une...
Page 28 - CARE & MAINTENANCE OF GRILL COMPONENTS; GRILL GRATE AND WARMING RACK
©2021 Hestan Commercial Corporation 27 EN To clean your powder-coated surface: 1. Carefully remove any loose deposits with a wet sponge.2. Use a soft brush (non abrasive) or cloth, and a mild household detergent solution to remove dust, salt and other deposits. Never use any solvent-based cleaners, ...
Page 30 - LIGHT BULB REPLACEMENT
©2021 Hestan Commercial Corporation 29 EN Figure 10 Figure 11 LIGHT BULB REPLACEMENT LIGHT BULB REPLACEMENT1. Disconnect the power to your grill before any service or light bulb replacement. Be sure the grill and the lights are completely cool. Halogen lights get extremely hot. 2. Open hood and remo...
Page 31 - TROUBLESHOOTING GUIDE; Symptom
©2021 Hestan Commercial Corporation 30 EN TROUBLESHOOTING GUIDE Symptom Check Burner will not light Not holding in control knob long enough to make igniter glow Gas supply not on / shutoff valve closed LP gas cylinder empty Power cord not plugged in, or no power to receptacle, or blown fuse Low gas ...
Page 32 - WIRING SCHEMATIC
©2021 Hestan Commercial Corporation 31 EN WIRING SCHEMATIC 12VA C, 4.17A X F M R 50V A N ( WH T) L (B LK) 120VA C 12VA C, 4.17A X F M R 50V A N ( WH T) L (B LK) 120VA C 7 1 2 3 4 5 6 8 L (B L K o r B RN ) N (W H T o r B L U ) G ND ( G RN ) P O W E R C O R D FU SE FU SE N L G A C O U TL E T + B R N M...
Page 33 - HARNESS
©2021 Hestan Commercial Corporation 32 EN WIRING SCHEMATIC (continued) 1 2 3 4 5 6 7 8 HA L OG E N 1 /4 " L O N G S T R IP E N D T O L E F T HA L OG E N T OG E T H E R 2 W IR E E ND S S O L D E R 1 /4 " L O N G T O R IG H T 3 /8 " X 24 " L FI BE R G L AS S S L EEV IN G 120 0 F, B L K...
Page 39 - SERVICE; WHAT THIS LIMITED WARRANTY COVERS
©2021 Hestan Commercial Corporation 38 EN SERVICE All warranty and non-warranty repairs should be performed by qualified service personnel. To locate an authorized service agent in your area, contact your Hestan dealer, local representative, or the manufacturer. Before you call, please have the mode...
Page 40 - LIMITED WARRANTY STATES YOUR EXCLUSIVE REMEDY.; OUTDOOR GAS PRODUCT LIMITED WARRANTY
©2021 Hestan Commercial Corporation 39 EN 4. All other grill components are warranted to be free from defects in material and workmanship, under normal non- commercial use and service, for a period of two (2) years from the original date of purchase. This is limited to replacement of the defective p...
Page 41 - LIRE CE MANUEL ATTENTIVEMENT ET ENTIÈREMENT AVANT
FR ©2021 Hestan Commercial Corporation 1 L’INOBSERVATION DES INFORMATIONS DONNÉES DANS CE MANUEL PEUT ENTRAÎNER UN INCENDIE OU UNE EXPLOSION DE NATURE À CAUSER DES DÉGÂTS MATÉRIELS ET DES BLESSURES GRAVES, VOIRE MORTELLES. Ne pas essayer d’allumer cet appareil sans lire d’abord la section INSTRUCTIO...
Page 42 - MODÈLES ENCASTRÉS; MODÈLES AMOVIBLES; NUMÉROS DE MODÈLE
FR ©2021 Hestan Commercial Corporation 2 MODÈLES ENCASTRÉS Numéro de Modèle Description EABR30-NG / -LP 30 po ENCASTRÉ (TOUS BRÛLEUR EN U avec LE TOURNEBROCHE) EAB30-NG / -LP 30 po ENCASTRÉ (TOUS BRÛLEURS EN U) EMBR30-NG / -LP 30 po ENCASTRÉ (BRÛLEURS DE SAISIE ET BRÛLEURS EN U avec LE TOURNEBROCHE)...
Page 43 - PLAQUE SIGNALÉTIQUE; les dégagements minima d’installation.; PRÉCAUTIONS À PRENDRE AVANT D’UTILISER CE GRIL; section RACCORDEMENTS DE GAZ de ce manuel.; La plaque
FR ©2021 Hestan Commercial Corporation 3 PLAQUE SIGNALÉTIQUE La plaque signalétique donne des informations importantes sur cet appareil Aspire telles que les numéros de série et de modèle, le type de gaz et la pression d’admission, la cote BTU pour chaque type de brûleur et les dégagements minima d’...
Page 44 - pas bloquer les ouïes d’aération du chariot.
FR ©2021 Hestan Commercial Corporation 4 11. Examiner le tuyau d’alimentation en GPL avant chaque utilisation du gril. Le tuyau doit rester à l’écart des parties chauffées du gril. Si le tuyau présente des signes d’abrasion ou d’usure excessive, ou de coupure, il doit être remplacé avant utilisation...
Page 46 - RESPECT DE LA RÉGLEMENTATION ET DES CODES EN VIGUEUR; COMMUNAUTÉ DE MASSACHUSETTS; BOUTEILLES DE GPL PORTATIVES; sa contenance totale.
FR ©2021 Hestan Commercial Corporation 6 RESPECT DE LA RÉGLEMENTATION ET DES CODES EN VIGUEUR L’installation de cet appareil de cuisson doit être effectuée conformément aux codes locaux. En l’absence de tels codes, installer cet appareil conformément au National Fuel Gas Code ANSI Z223.1/NFPA 54, au...
Page 47 - Hestan Commercial Corporation; LISTE DES PIÈCES; ÉLÉMENTS COUVERTS PAR LA PRÉSENTE GARANTIE LIMITÉE
FR ©2021 Hestan Commercial Corporation 7 SERVICE Toutes les réparations dans le cadre ou en dehors de la garantie doivent être effectuées par du personnel d’entretien qualifié. Pour localiser un réparateur agréé dans la région, s’adresser au concessionnaire Hestan, au représentant local ou à l’usine...
Page 48 - ALLONGEMENTS AU-DELÀ DE LA PÉRIODE DE GARANTIE LIMITÉE D’UN AN:; GARANTIE LIMITÉE
FR ©2021 Hestan Commercial Corporation 8 ALLONGEMENTS AU-DELÀ DE LA PÉRIODE DE GARANTIE LIMITÉE D’UN AN: ALLONGEMENTS AU-DELÀ DE LA PÉRIODE DE GARANTIE LIMITÉE D’UN AN: En plus de la Garantie limitée d’un an, les composants qui suivent bénéficient d’un prolongement de la garantie comme indiqué expre...
Page 49 - LIMITATION DE RESPONSABILITÉ:; GARANTIE LIMITÉE FORMULE VOTRE RECOURS EXCLUSIF.; auxquels peuvent s’en ajouter d’autres qui varient selon le lieu.
FR ©2021 Hestan Commercial Corporation 9 LIMITATION DE RESPONSABILITÉ: LIMITATION DE RESPONSABILITÉ: La présente Garantie limitée constitue l’accord définitif, intégral et exclusif entre HCC et l’Acheteur eu égard au Produit. IL N’EXISTE AUCUNE GARANTIE EXPRESSE AUTRE QUE CELLES ÉNUMÉRÉES ET DÉCRITE...
Page 50 - RETAIN THIS MANUAL FOR FUTURE REFERENCE
Hestan Commercial Corporation 3375 E. La Palma Ave. Anaheim, CA 92806 (888) 905-7463 RETAIN THIS MANUAL FOR FUTURE REFERENCE CONSERVEZ CE MANUEL POUR UNE RÉFÉRENCE FUTURE ©2021 Hestan Commercial Corporation P/N 014824 REV E
Hestan GABR30-LP
User Manual