Grindmaster 830 - Manuals - manualsarea.com

Page 2 - Electric Models; General Description

Page 1 American Metal Ware Hot Water Boiler Electric Models 815, 830, 850 Equipped with Option 46 Automatic Refill Option 39 Low Water Cut-Off System General Description This unit is a high temperature hot water boiler. It consists of a non-pressure, vented watercompartment into which is installed a...

Page 3 - American Metal Ware Hot Water Boiler; HEATER SIZE

American Metal Ware Hot Water Boiler Page 2 TO CHECK REFILL RATE, allow water to fill to stop/full level automatically; then turn off masterswitch. Draw off 1 gallon of water from faucet. Turn master switch back on and time how long ittakes for the water level to come up to stop/full mark again. Com...

Page 5 - Thermostat; If thermostat will not cycle, replace entire control.

American Metal Ware Hot Water Boiler Page 4 Thermostat Factory set so that knob on BREW setting holds unit at brewing temperature toward HIGH end ofbrew zone on thermometer dial. Then, if turned back to HOLD position, thermostat should cycleon and off and hold at LOW 'end of BREW zone on thermometer...

Page 6 - Service Instructions; POSSIBLE CAUSE

Page 5 American Metal Ware Hot Water Boiler Service Instructions PROBLEM: THERMOSTAT DIAL TURNED TO BREW AND WATER IN COMPARTMENT REMAINS COLD POSSIBLE CAUSE 1. 2. PROBLEM: WATER BOILS CONTINUOUSLY WITH THERMOSTAT DIAL ON POSITION BREW OR HOLD. POSSIBLE CAUSE 1. 2. 3. Set knob on BREW and remove kno...

Page 7 - Description and Operation of Dual Level Control System:

American Metal Ware Hot Water Boiler Page 6 Dual Level ControlAuto Refill And Low Water Cutoff System I) II) Dual Level Control: What it does: Description and Operation of Dual Level Control System: A. B. C. A. AUTO REFILL of the water compartment to keep the tank filled with water. When water is us...

Page 9 - rouble Shooting

American Metal Ware Hot Water Boiler Page 8 A) B) C) Overfilling of water tank when power is of f. Overfilling of water tank only when power to unit is on. Auto refill fails to fill water t ank. PROBLEM IV) T rouble Shooting Auto Refill, Low W ater Cutof f, and Dual Level Control System POSSIBLE CAU...

Page 11 - If you still need help, call our service dep

American Metal Ware Hot Water Boiler Page 10 NOTE: The level control board works on the principle that water is conductive and with some pure water inst allations, an increased senseitivity may be required in the level control system. Consult factory if this be the case. If you still need help, call...

Page 12 - Safety Instructions; Installation; FLUID TEMPERATURE RATING F; INSTALLATION AND SERVICE; FOR

Page 11 American Metal Ware Hot Water Boiler Read installation instructions- thoroughly. Failure to comply canresult in valve failure or system damage or personal injury.Do not use solenoid valves on applications or fluid media notspecifically cataloged without prior approval of Alco EngineeringDepa...

Page 13 - Figure 1

American Metal Ware Hot Water Boiler Page 12 Diassembly Disassemble in the same general order as indicated in exploded-viewillustrations except as noted in the following steps:1. 2. 3. Notes: Do NOT Lose Nameplate, as it is extremelyimportant if it becomes necessary to order a parts kit, coil or dup...

Page 14 - Parts List; Description; IMPORTANT: Give Model Number and Serial Number when ordering

Page 13 American Metal Ware Hot Water Boiler Parts List 815, 830, 850 - Electric, Gas or Steam Heat AMW Part # Description 522004 Aluminum Gauge Shield Only for 815 - 5/8” x 13” 522006 Aluminum Gauge Shield Only for 830 - 5/8” x 16” 522010 Aluminum Gauge Shield Only for 850 - 5/8” x 20” 522034 Gauge...