Emerson 00825-0100-4075- Manuals

Page 2 - Quick Installation Guide; Smart Wireless THUM Adapter; Explosions could result in death or serious injury:; can cause electrical shock.; IMPORTANT NOTICE

Quick Installation Guide 00825-0100-4075, Rev DA July 2011 Smart Wireless THUM Adapter 2 © 2011 Rosemount Inc. All rights reserved. All marks property of owner. IMPORTANT NOTICE This installation guide provides basic guidelines for the Smart Wireless THUM Adapter. It does not provide instructions fo...

Page 3 - IRELESS; Power Up Sequence; Conduit Entry; Field Communicator Connections

Quick Installation Guide 00825-0100-4075, Rev DAJuly 2011 Smart Wireless THUM Adapter 3 W IRELESS C ONSIDERATIONS Power Up Sequence Power should not be applied to any wireless device until the Smart Wireless Gateway (“Gateway”) is installed and functioning properly. Wireless devices should also be p...

Page 4 - Power Supply; Limit the power supply to 0.5 Amps maximum, and voltage to 55 Vdc.; Load Resistor; ENCH

Quick Installation Guide 00825-0100-4075, Rev DA July 2011 Smart Wireless THUM Adapter 4 Power Supply Minimum loop load of 250 Ohms.The THUM Adapter communicates via and derives power from a standard 4-20 mA/HART ® loop. The THUM Adapter causes a small voltage drop on the loop which is linear from 2...

Page 5 - TEP; The THUM Adapter can be installed in one of two configurations:; Direct Mount; device according to standard installation practices and the

Quick Installation Guide 00825-0100-4075, Rev DAJuly 2011 Smart Wireless THUM Adapter 5 Figure 3. THUM Adapter Only, Powered by a 24 V Power Supply with 1200 Ohm resistor to limit current to 20 mA S TEP 1: P HYSICAL I NSTALLATION The THUM Adapter can be installed in one of two configurations: Direct...

Page 6 - Remote Mount; The THUM Adapter should be mounted as shown in Figure 5 on page 6.

Quick Installation Guide 00825-0100-4075, Rev DA July 2011 Smart Wireless THUM Adapter 6 Remote Mount Remote Mount: The THUM Adapter is mounted separate from the wired device housing and then connected to the wired device using conduit or other suitable means. Figure 5. Remote Mount 1. Install the H...

Page 7 - Wiring Diagrams; Figure 6 - Direct Mount Wiring Diagram for 2-Wire Device on page 8

Quick Installation Guide 00825-0100-4075, Rev DAJuly 2011 Smart Wireless THUM Adapter 7 Wiring Diagrams The following is a list of the figure titles and page numbers for each direct mount and remote mount wiring diagram: Figure 6 - Direct Mount Wiring Diagram for 2-Wire Device on page 8 Figure 7 - R...

Page 16 - Device Network Configuration; Network ID and Join Key; so that; AMS; Right click on the THUM Adapter and select; Configure; and follow the method to enter the Network ID and Join Key.; Field Communicator; Wireless Setup; Radio State

Quick Installation Guide 00825-0100-4075, Rev DA July 2011 Smart Wireless THUM Adapter 16 Device Network Configuration In order to communicate with the Smart Wireless Gateway, and ultimately the Information System, the transmitter must be configured to communicate with the wireless network. This ste...

Page 17 - Loop Current Test

Quick Installation Guide 00825-0100-4075, Rev DAJuly 2011 Smart Wireless THUM Adapter 17 Loop Current Test To verify that the THUM Adapter will work under all conditions, a loop current test should be performed. This test will exercise the loop under the highest possible voltage drop conditions. 1. ...

Page 19 - Wireless; Smart Wireless Gateway; Explorer; AMS Wireless Configurator; Communications

Quick Installation Guide 00825-0100-4075, Rev DAJuly 2011 Smart Wireless THUM Adapter 19 S TEP 2: V ERIFY O PERATION Operation can be verified in three locations: by using the Field Communicator, at the Gateway via the Smart Wireless Gateway’s integrated web server, or via AMS ™ Wireless Configurato...

Page 20 - Troubleshooting; page on the web server. The Network ID and Join Key may be; EFERENCE

Quick Installation Guide 00825-0100-4075, Rev DA July 2011 Smart Wireless THUM Adapter 20 Troubleshooting If the device is not operating properly, refer to the troubleshooting section of the manual. The most common cause of incorrect operation is the Network ID and Join Key. The Network ID and Join ...

Page 21 - RODUCT; Approved Manufacturing Locations; Emerson Process Management complies with the ATEX Directive.; Telecommunication Compliance

Quick Installation Guide 00825-0100-4075, Rev DAJuly 2011 Smart Wireless THUM Adapter 21 P RODUCT C ERTIFICATIONS Approved Manufacturing Locations Rosemount Inc. – Chanhassen, Minnesota, USAEmerson Process Management GmbH & Co. - Karlstein, GermanyEmerson Process Management Asia Pacific Private ...

Page 22 - Hazardous Locations Certificates; North American Certifications; CSA - Canadian Standards Association; European Certifications; II 3 G; Loop Power

Quick Installation Guide 00825-0100-4075, Rev DA July 2011 Smart Wireless THUM Adapter 22 Hazardous Locations Certificates North American Certifications Factory Mutual (FM) Approvals I5 FM Intrinsically Safe and Non-incendiveIntrinsically Safe for Class I/II/III, Division 1, Groups A, B, C, D, E, F,...

Page 23 - IECEx Certifications; INMETRO Certifications; CCoE Certifications; IW; KOSHA Certifications; IP

Quick Installation Guide 00825-0100-4075, Rev DAJuly 2011 Smart Wireless THUM Adapter 23 IECEx Certifications I7 IECEx Intrinsic SafetyCertificate No.: IECEx BAS 09.0050XEx ia IIC T4 (-50 °C  T amb  70 °C) IP66 Special conditions for safe use (X) The surface resistivity of the antenna is greater...

Page 24 - GOST Certifications; IM

Quick Installation Guide 00825-0100-4075, Rev DA July 2011 Smart Wireless THUM Adapter 24 GOST Certifications IM Intrinsically SafeEx ia IIC T4 (-50 °C  T amb  70 °C) Ex nA IIC T4 (-50 °C  T amb  70 °C) IP66 4075_QIG_Rev_DA.fm Page 24 Wednesday, July 27, 2011 8:50 AM

Page 25 - EC Declaration of Conformity

Quick Installation Guide 00825-0100-4075, Rev DAJuly 2011 Smart Wireless THUM Adapter 25 EC Declaration of Conformity No: RMD 1077 Rev. B We, Rosemount Inc.8200 Market Boulevard Chanhassen, MN 55317-6985 USA declare under our sole responsibility that the product, Model 775 manufactured by, Rosemount...

Page 27 - ATEX Notified Bodies for EC Type Examination Certificate

Quick Installation Guide 00825-0100-4075, Rev DAJuly 2011 Smart Wireless THUM Adapter 27 EC Declaration of Conformity No: RMD 1077 Rev. B File ID: 775 CE Marking Page 3 of 3 K:\prodappr\EUCDOCS\775_RMD1077B.doc ATEX Notified Bodies for EC Type Examination Certificate Baseefa. [Notified Body Number: ...