Page 2 - TABLE OF CONTENTS
TABLE OF CONTENTS PB-580 H/T 2 X7505200707 © 07/19 ECHO Incorporated TABLE OF CONTENTS Introduction ................................................................................................. 3Servicing Information ..................................................................................
Page 3 - INTRODUCTION; OR; SERVICING INFORMATION
PB-580 H/T INTRODUCTION X7505200707 3 © 07/19 ECHO Incorporated INTRODUCTION Specifications, descriptions and illustrative material in this literature are as accurate as known at the time of publication, but are subject to change without notice. Illustrations may include optional equipment and acces...
Page 4 - SAFETY
SAFETY PB-580 H/T 4 X7505200707 © 07/19 ECHO Incorporated Service Service of this product during the warranty period must be performed by an Authorized ECHO Service Dealer. For the name and address of the Authorized ECHO Service Dealer nearest you, ask your retailer or call: 1-800-432-ECHO (3246). D...
Page 5 - Note: This enclosed message provides tips for use, care and; International Symbols
PB-580 H/T SAFETY X7505200707 5 © 07/19 ECHO Incorporated The safety alert symbol accompanied by the word “WARNING” calls attention to an act or condition which CAN lead to serious personal injury or death if not avoided. The safety alert symbol accompanied by the word “CAUTION” calls attention to a...
Page 7 - Physical Condition; Your judgment and physical dexterity may not be good:
PB-580 H/T SAFETY X7505200707 7 © 07/19 ECHO Incorporated Personal Condition and Safety Equipment Cancer and Reproductive Harmwww.P65Warnings.ca.gov The muffler or catalytic muffler and surrounding cover may become extremely hot. Always keep clear of exhaust and muffler area, otherwise serious perso...
Page 8 - Eye Protection
SAFETY PB-580 H/T 8 X7505200707 © 07/19 ECHO Incorporated Operate unit only if you are physically and mentally well. Eye Protection ◆ Eye protection that meets ANSI Z87.1 or CE requirements must be worn whenever you operate the unit. ◆ For additional safety, a full-face shield may be worn over safet...
Page 9 - Extended Operation / Extreme Conditions; during frequent work breaks, and also by not smoking.
PB-580 H/T SAFETY X7505200707 9 © 07/19 ECHO Incorporated Keep long hair away from engine and air intake. Retain hair with cap or net. Heavy protective clothing can increase operator fatigue, which may lead to heat stroke. Schedule heavy work for early morning or late afternoon hours when temperatur...
Page 10 - • Avoid using your wrist in a bent,
SAFETY PB-580 H/T 10 X7505200707 © 07/19 ECHO Incorporated Repetitive Stress Injuries (RSI) It is believed that overusing the muscles and tendons of the fingers, hands, arms, and shoulders may cause soreness, swelling, numbness, weakness, and extreme pain in those areas. Certain repetitive hand acti...
Page 11 - Read the Manual; • To prevent from dropping the unit, hold the handle in one hand, with; Keep a Solid Stance; • Maintain footing and balance at all times. Do not stand on slippery,; Avoid Hot Surfaces; • Keep exhaust area clear of flammable debris.
PB-580 H/T SAFETY X7505200707 11 © 07/19 ECHO Incorporated Do not operate this product indoors or in inadequately ventilated areas. Engine exhaust contains poisonous emissions and can cause serious injury or death. Read the Manual • Provide all users of this equipment with literature for instruction...
Page 12 - Do not use blower if any part is missing or damaged.
SAFETY PB-580 H/T 12 X7505200707 © 07/19 ECHO Incorporated Equipment Use only approved attachments. Serious injury may result from the use of a non-approved attachment combination. ECHO, INC. will not be responsible for the failure of cutting devices, attachments or accessories which have not been t...
Page 13 - An Emission Control Label; is
PB-580 H/T EMISSION CONTROL X7505200707 13 © 07/19 ECHO Incorporated EMISSION CONTROL (EXHAUST & EVAPORATIVE) CARB And EPA Emissions Control Information The emission control system for the engine is EM (engine modification) and, if the second to last character of the Engine Family on the Emissio...
Page 14 - DESCRIPTION
DESCRIPTION PB-580 H/T 14 X7505200707 © 07/19 ECHO Incorporated DESCRIPTION PB-580 H Locate the safety decal(s) on your unit. Make sure the decal(s) is legible and that you understand and follow the instructions on it. If a decal cannot be read, a new one can be ordered from your ECHO dealer. The sa...
Page 18 - CONTENTS
CONTENTS PB-580 H/T 18 X7505200707 © 07/19 ECHO Incorporated CONTENTS The ECHO product you purchased has been factory pre-assembled for your convenience. Due to packaging restrictions, some assembly may be necessary. After opening the carton, check for damage. Immediately notify your retailer or ECH...
Page 19 - ASSEMBLY; Install Blower Pipes and Stick Handle; Note: A light lubricant may be
PB-580 H/T ASSEMBLY X7505200707 19 © 07/19 ECHO Incorporated ASSEMBLY PB-580 H Never perform maintenance or assembly procedures with engine running or serious personal injury may result. Install Blower Pipes and Stick Handle 1. Assemble clamps (A) onto both ends of flexible pipe (B). 2. Assemble str...
Page 20 - Note: Blower use will eventually; Install Blower Pipes; Note: Clamp with cable guide
ASSEMBLY PB-580 H/T 20 X7505200707 © 07/19 ECHO Incorporated 7. Assemble straight pipe (J) onto swivel pipe (C), until you feel light resistance. Hold swivel pipe and turn straight pipe clockwise, engaging positive locking channels, until connection is firm. Do not force connection. 8. Assemble stra...
Page 22 - Assemble swivel pipe into flexible pipe and tighten clamp (A).
ASSEMBLY PB-580 H/T 22 X7505200707 © 07/19 ECHO Incorporated 5. Position throttle cable along the outside of elbow. Loosen knob (H) on handle (E). Align notches in handle with tabs (F) and install onto swivel pipe (C) past long ridges in pipe. 6. Insert anti-static wire through swivel pipe (wire wil...
Page 23 - OPERATION; Always be alert for changes in operation of unit.
PB-580 H/T OPERATION X7505200707 23 © 07/19 ECHO Incorporated OPERATION Moving parts can amputate fingers or cause severe injuries. Keep hands, clothing and loose objects away from all openings. Always stop engine, disconnect spark plug, and make sure all moving parts have come to a complete stop be...
Page 24 - Fuel Requirements; Gasoline; approved. Use of ECHO branded fuel is; Two Stroke Oil; KEEP OUT OF REACH OF CHILDREN.
OPERATION PB-580 H/T 24 X7505200707 © 07/19 ECHO Incorporated Fuel Diesel fuels and alternative fuels, such as E-15 (15% ethanol), E -85 (85% ethanol) or any fuels not meeting ECHO requirements are NOT approved for use in ECHO 2-stroke gasoline engines. Use of diesel or alternative fuels may cause p...
Page 25 - AVOID repeated or prolonged skin contact.; DO NOT smoke near fuel.
PB-580 H/T OPERATION X7505200707 25 © 07/19 ECHO Incorporated ◆ AVOID repeated or prolonged skin contact. ◆ AVOID inhaling oil mists or vapors. ECHO branded 2-stroke oils may be mixed at 50:1 ratio for application in all ECHO engines sold in the past regardless of ratio specified in those manuals. H...
Page 26 - Mixing Instructions; Storage; - Fuel storage laws vary by locality. Contact your local government
OPERATION PB-580 H/T 26 X7505200707 © 07/19 ECHO Incorporated Mixing Instructions 1. Fill an approved fuel container with half of the required amount of gasoline. 2. Add the proper amount of 2-stroke oil to gasoline. 3. Close container and shake to mix oil with gasoline. 4. Add remaining gasoline, c...
Page 27 - Do not allow the rope to snap back in. Always hold the unit firmly.; Note: If engine does not start; Allow engine to warm up for several minutes before use.
PB-580 H/T OPERATION X7505200707 27 © 07/19 ECHO Incorporated Starting Cold Engine • Recoil starter: Use short pulls - only 1/2 - 2/3 of rope length for starting. Do not allow the rope to snap back in. Always hold the unit firmly. • (PB-580H): Rotate spring loaded throttle arm downward to a comforta...
Page 28 - Stopping Engine; Throttle Lever
OPERATION PB-580 H/T 28 X7505200707 © 07/19 ECHO Incorporated Starting Warm Engine The starting procedure is the same as Cold Start except DO NOT close the choke.v 1. Throttle Lever Move throttle lever (A) to IDLE position. 2. Purge Bulb Pump purge bulb (C) until fuel is visible. Pump bulb an additi...
Page 29 - Operating Blower; Read the Safety Section carefully.
PB-580 H/T OPERATION X7505200707 29 © 07/19 ECHO Incorporated - PB-580 T 1. Throttle Lever Release throttle trigger. Move Throttle Lever (A) forward to idle position and allow engine to return to idle before shutting off engine. 2. Throttle Lever Move Throttle Lever (A) all the way forward to STOP p...
Page 30 - Allow the engine to warm up at a fast idle for a few minutes.; Note: Never use a higher speed setting than necessary to perform a; Use the full blower pipe configuration when blowing.
OPERATION PB-580 H/T 30 X7505200707 © 07/19 ECHO Incorporated To avoid engine damage due to over-revving, do not block blower pipe. 1. Use only during appropriate hours. Contact your local government for the ordinances affecting your area. 2. To reduce sound levels, limit the number of pieces of equ...
Page 31 - Plug
PB-580 H/T OPERATION X7505200707 31 © 07/19 ECHO Incorporated Contacting blower pipe tip on abrasive surfaces can create sharp cutting edges and can result in personal injury if touched. Do not scrape or drag blower pipe tip when operating or transporting unit. Replace blower pipe assembly if protec...
Page 32 - Note: Blower performance may; Adjust the Harness
OPERATION PB-580 H/T 32 X7505200707 © 07/19 ECHO Incorporated 2. Install intake cover (B) on frame over air intake. 3. Install back cushion (A) to frame over intake cover. Note: Blower performance may be reduced slightly. Adjust the Harness 1. Loosen upper and lower buckles (A), then put blower on y...
Page 33 - MAINTENANCE; Skill Levels; Level 1; = Moderate difficulty. Some specialized tools may be required.; Level 3; or
PB-580 H/T MAINTENANCE X7505200707 33 © 07/19 ECHO Incorporated MAINTENANCE Moving parts can amputate fingers or cause severe injuries. Keep hands, clothing and loose objects away from all openings. Always stop engine, disconnect spark plug, and make sure all moving parts have come to a complete sto...
Page 35 - CLOSE choke (COLD START
PB-580 H/T MAINTENANCE X7505200707 35 © 07/19 ECHO Incorporated Air Filter Level 1. 1. CLOSE choke (COLD START [ ] position). This prevents dirt from entering the carburetor throat when the air filter is removed. Brush accumulated dirt from air cleaner area. 2. Remove air filter cover. Brush dirt fr...
Page 36 - Note: Federal EPA regulations
MAINTENANCE PB-580 H/T 36 X7505200707 © 07/19 ECHO Incorporated Fuel Filter Level 1. Fuel is VERY flammable. Use extreme care when mixing, storing or handling, or serious personal injury may result. 1. Use a clean rag to remove loose dirt from around fuel cap and empty fuel tank. 2. Pull the fuel li...
Page 37 - • Air intakes are blocked,
PB-580 H/T MAINTENANCE X7505200707 37 © 07/19 ECHO Incorporated Spark Plug Level 2. Use only NGK BPM8Y spark plug (BPMR8Y in Canada) otherwise severe engine damage may occur. 1. Remove spark plug and check for fouling, worn and rounded center electrode. 2. Clean the plug or replace with a new one. D...
Page 38 - Cleaning Grill; Remove starter
MAINTENANCE PB-580 H/T 38 X7505200707 © 07/19 ECHO Incorporated Removal of cooling passage blockages or cleaning of cooling fins is considered “Normal Maintenance.” Any failure attributed to lack of maintenance is not warranted. Cleaning Grill 1. Brush accumulated debris from intake grill between ba...
Page 39 - Spark Arrestor Screen; Remove engine cover.; Note: When cleaning carbon; Assemble components in reverse order.
PB-580 H/T MAINTENANCE X7505200707 39 © 07/19 ECHO Incorporated Exhaust System Spark Arrestor Screen Level 2. Carbon deposits in muffler will cause a drop in engine output and overheating. Spark arrestor screen must be checked periodically. 1. Remove spark plug. 2. Remove starter. 3. Remove engine c...
Page 40 - Exhaust Port Cleaning
MAINTENANCE PB-580 H/T 40 X7505200707 © 07/19 ECHO Incorporated Exhaust Port Cleaning Level 2. 1. Remove spark plug. 2. Remove starter 3. Remove engine cover. 4. Place piston at top dead center. Remove muffler (A) heat shield (B). 5. Use a wood or plastic scraping tool to clean deposits from cylinde...
Page 41 - operating temperature.; Carburetor Adjustment; High Altitude Operation; Note: Every unit is run at the factory and the carburetor is set in
PB-580 H/T MAINTENANCE X7505200707 41 © 07/19 ECHO Incorporated Assure heat shield is installed correctly behind rib (A) and in front of rib (B) in fan case. 7. Install muffler. 8. Tighten muffler mounting bolts (or nuts) to 90 - 110 kgf • cm (80 - 95 in • lbf). 9. Assemble components in reverse ord...
Page 42 - Idle Adjustment; Before adjustment make sure that:; Throttle Cable Adjustment
MAINTENANCE PB-580 H/T 42 X7505200707 © 07/19 ECHO Incorporated Idle Adjustment Before adjustment make sure that: • Air filter is clean and properly installed. • Spark arrestor screen and muffler are free of carbon. • Blower pipes are installed. 1. Start engine, run at idle for one minute. 2. Comple...
Page 44 - TROUBLESHOOTING
TROUBLESHOOTING PB-580 H/T 44 X7505200707 © 07/19 ECHO Incorporated TROUBLESHOOTING Fuel vapors are extremely flammable and may cause fire and/or explosion. Never test for ignition spark by grounding spark plug near cylinder plug hole, otherwise serious personal injury may result. ENGINE PROBLEM TRO...
Page 46 - STORAGE; Store unit in a dry, dust free place, out of the reach of children.
STORAGE PB-580 H/T 46 X7505200707 © 07/19 ECHO Incorporated STORAGE During operation the muffler or catalytic muffler and surrounding cover become hot. Always keep exhaust area clear of flammable debris during transportation or when storing, otherwise serious property damage or personal injury may r...
Page 47 - SPECIFICATIONS; MODEL
PB-580 H/T SPECIFICATIONS X7505200707 47 © 07/19 ECHO Incorporated SPECIFICATIONS MODEL PB-580 H PB-580 T Length (w/o pipes) 379 mm (14.92in.) 379 mm (14.92 in.) Width (w/o pipes) 537 mm (21.14 in.) 478 mm (18.82 in.) Height (w/o pipes) 459 mm (18.07 in.) Weight (dry) (w/o pipes) 9.4 kg (20.7 lb.) 9...
Page 49 - PRODUCT REGISTRATION; Thank you for choosing ECHO Power Equipment; FAST
PB-580 H/T PRODUCT REGISTRATION X7505200707 49 © 07/19 ECHO Incorporated PRODUCT REGISTRATION Thank you for choosing ECHO Power Equipment Please go to http://www.echo-usa.com/Warranty/Register-Your-ECHO to register your new product on-line. It's FAST and EASY ! NOTE: your information will never be s...
Page 51 - NOTES
PB-580 H/T NOTES X7505200707 51 © 07/19 ECHO Incorporated NOTES
Page 52 - ECHO INCORPORATED
ECHO INCORPORATED 400 Oakwood Road Lake Zurich, IL 60047 www.echo-usa.com H P44713001001 - P44713999999 P48013001001 - P48013999999 T P44813001865 - P44813999999 P48113001865 - P48113999999
ECHO DPB-2500C1
User Manual
ECHO DPB-2500R2
User Manual
ECHO DPB-5800TD2-2
User Manual
ECHO ES-250AA
User Manual
ECHO PB-2520
User Manual
ECHO PB-2620
User Manual
ECHO PB-265LN
User Manual
ECHO PB-580T
User Manual
ECHO PB-755SH
User Manual
ECHO PB-755ST
User Manual
ECHO PB-760LNH
User Manual
ECHO PB-760LNT
User Manual
ECHO PB-770H
User Manual
ECHO PB-770T
User Manual
ECHO PB-9010H
User Manual
ECHO PB-9010T
User Manual