ECHO PAS-265 - Manuals

6 equIpment wArning Use only ECHO approved attachments for Pro Attachment Series TM models. Serious injury may result from the use of a non-approved attachment combination. Read and comply with all safety instructions listed in this manual and attachment manual. wArning Moving parts can amputate fin...

P ro A ttAchment S erieS tm 7 o PerAtor ' S m AnuAl Hot Decal (near muffler) 11 18 15 12 13 14 16 17 Shaft Decal Spanish Decal English Translation d escrIptIon Locate these safety decals on your unit. Make sure the decals are legible and that you understand and follow the instruc- tions on them. If ...

8 1. POWER hEAD - Includes the Engine, Clutch, Fuel System, Ignition System and Recoil Starter. 2. SPARK ARRESTOR MUFFLER OR SPARK ARRESTOR MUFFLER WITh CATALyST - The muffler or catalytic muffler controls exhaust noise and emission. The spark arrestor screen prevents hot, glowing particles of carbo...

P ro A ttAchment S erieS tm 9 o PerAtor ' S m AnuAl 1 - Power Head w / Upper Drive Shaft Assembly1 - Plastic Bag (co-pack) - 1, Operator's Manual - 1, Warranty Registration Card - 1, Safety Glasses - 1, Barrier Bar a ssembly attachment shaft assembly Tools Required: None Parts Required: PAS Attachme...

10 Tools Required: Screwdriver. Parts Required: Barrier Bar Handle Adjustment NOTE Label shows minimum spacing for front handle location. 1. Stand in a comfortable operating position with attachment assem- bled, and position front handle for comfortable operation. Tighten handle screws. Barrier Bar ...

12 NOTICE: Use of unmixed, improperly mixed, or fuel older than 90 days, (stale fuel), may cause hard starting, poor performance, or severe engine damage and void the product warranty. Read and follow instructions in the Storage section of this manual. wArning Alternative fuels, such as E-15 (15% et...

P ro A ttAchment S erieS tm 13 o PerAtor ' S m AnuAl IMPORTANT Stored fuel ages. Do not mix more fuel than you expect to use in thirty (30) days, ninety (90) days when a fuel stabilizer is added. IMPORTANT Stored two-stroke fuel may separate. ALWAYS shake fuel container thor- oughly before each use....

14 startInG cold enGIne wArning The attachment will operate immediately when the engine starts and could result in loss of control and possible serious injury. Keep movable parts of the attachment off the ground and away from objects that could become entangled or thrown. 1. Stop Switch Move stop sw...

P ro A ttAchment S erieS tm 15 o PerAtor ' S m AnuAl startInG warm enGIne The starting procedure is the same as Cold Start except DO NOT close the choke, and do not depress throttle trigger to wide open position. wArning The attachment should not move at idle, otherwise serious personal injury may r...

16 maIntenance Intervals m aIntenance wArning Moving parts can amputate fingers or cause severe injuries. Keep hands, clothing and loose objects away from all openings. Always stop engine, disconnect spark plug, and make sure all moving parts have come to a complete stop before removing obstructions...

P ro A ttAchment S erieS tm 17 o PerAtor ' S m AnuAl aIr fIlter Level 1. Tools required: 25 or 50 mm (1 or 2 in.) Cleaning brush Parts required: REPOWER TM AIR & FUEL FILTER KIT 1. Close choke (Cold Start Position [ ]). This prevents dirt from entering the carburetor throat when the air filter i...

18 spark pluG Level 2. Tools Required: T-Wrench, feeler gauge, soft metal brush Parts Required: REPOWER TM Tune-Up Kit IMPORTANT Use only NGK BPM-8Y spark plug (BPMR-8Y in Canada) other- wise severe engine damage may occur. 1. Remove spark plug and check for fouling, worn and rounded center electrod...

P ro A ttAchment S erieS tm 19 o PerAtor ' S m AnuAl IMPORTANT DO NOT use a metal scraper to remove dirt from the cylinder fins. 5. Use brush to remove dirt from the cylinder fins. 6. Remove grass and leaves from the grid between the recoil starter and fuel tank. 7. Assemble components in reverse or...

20 Exhaust Port Cleaning Level 2. Tools required: 4mm Hex Wrench, Wood or plastic scraper Parts Required: As needed: Heat Shield 1. Remove spark plug lead from spark plug, and remove engine cover (2 screws). 2. Place piston at top dead center. Remove muffler (A) and heat shield (B). 3. Use a wood or...

P ro A ttAchment S erieS tm 21 o PerAtor ' S m AnuAl Level 2. Tools required: Screwdriver, Tachometer (ECHO P/N 99051130017) Parts required: None NOTE Every unit is run at the factory and the carburetor is set in compli- ance with emission regulations. Carburetor adjustments, other than idle speed, ...

22 lubrIcatIon Level 1. Tools required: 5 mm Hex Wrench, Clean Rag Parts Required: POWER BLENDX TM 8 oz. (P/N 91014) or Lithium Base Grease. Drive Shaft Upper IMPORTANT The drive shaft must be lubricated with high temperature auto- motive grease every 25 hours of operation, otherwise drive shaft ass...

P ro A ttAchment S erieS tm 23 o PerAtor ' S m AnuAl DAngEr Fuel vapors are extremely flammable and may cause fire and/or explosion. Never test for ignition spark by ground- ing spark plug near cylinder plug hole, otherwise serious personal injury may result. t roubleshootInG T r A H C g n i T O O H...

24 s toraGe Long Term Storage (over 30 days) wArning During operation the muffler or catalytic muffler and surrounding cover become hot. Always keep exhaust area clear of flammable debris during transportation or when storing, otherwise serious property damage or personal injury may result. Do not s...

P ro A ttAchment S erieS tm 25 o PerAtor ' S m AnuAl s pecIfIcatIons MODEL ----------------------------------------------- PAS-265 Unit Length -------------------------------------------- 1036 mm (40.8 in.)Width --------------------------------------------------- 248 mm (9.8 in.)Height -------------...

26 echo approved optIonal attachments wArning • Use only ECHO approved attachments for Pro Attachment Series TM models. Serious injury may result from the use of non-approved attachment combinations. Read and comply with all safety instructions listed in this manual and in the attachment manual. NOT...

P ro A ttAchment S erieS tm 27 o PerAtor ' S m AnuAl ECHO LIMITED WARRANTY STATEMENT FOR PRODUCT SOLD IN USA AND CANADA BEGINNING 01/01/2010 ECHO'S RESPONSIBILITY ECHO Incorporated’s Limited Warranty, provides to the original purchaser that this ECHO product is free from defects in material and work...

COnSUMEr PrODUCT SUPPOrT 1-800-673-1558 8:30 - 4:30 Mon - Fri C.S.T. ECHO, inCOrPOrATED 400 O akwOOd R Oad L ake Z uRich , iL 60047 www.echo-usa.com S75411001001/S75411999999 S67911001001/S67911999999 S86312001001/S86312999999 DEALEr? Call 1-800-432-ECHO 1-800-432-3246 or www.echo-usa.com s ervIcInG...