Dyna-Glo TT40000M - Manuals

Page 3 - TABLE OF CONTENTS; NOT FOR HOME OR RECREATIONAL VEHICLE USE.; COMBUSTIBLES, SUCH AS BUILDING MATERIALS, PAPER OR CARDBOARD,; WARNING

General Safety Information .............................................................................. 3 - 4Specifications .............................................................................................................. 3Product Features ................................................

Page 4 - CHECK WITH YOUR LOCAL; PROPANE TANK TOP CONSTRUCTION HEATERS; READ THIS USER’S MANUAL CAREFULLY AND COMPLETELY BEFORE TRYING; SPECIFICATIONS; PROPANE TANK TOP HEATER

The heater is designed and approved for use as a construction heater under ANSI Z83.7, CSA 2.14. It is hard to anticipate every use which may be made of this heater. CHECK WITH YOUR LOCAL FIRE SAFETY AUTHORITY IF YOU HAVE QUESTIONS ABOUT APPLICATIONS. PROPANE TANK TOP CONSTRUCTION HEATERS This is a ...

Page 5 - PRODUCT FEATURES

Accidents are always tragic especially because so many of them could have been prevented with a little care and judgment. There are some basic good practices, we hope you will follow for safe use of your heater. • Children should be carefully supervised, when they are in the area. • Always maintain ...

Page 6 - TT360 SERIES HEATER ASSEMBLY; FIGURE 1; DUAL BURNER MODEL; Estimated Assembly Time:

TT360 SERIES HEATER ASSEMBLY The tank collar bracket must be assembled before the heaters can be attached to the propane tank. 1. Align bolt holes in tank collar bracket with bolt holes in mounting plate on heater. 2. Drive-in two machine screws (supplied) into the bolt holes attaching tank collar b...

Page 7 - WIRING DIAGRAM; Piezo models only

WIRING DIAGRAM 6 PROPANE TANK TOP HEATER NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! ELECTRODE THERMOCOUPLE TIP OVER SWITCH M,P,U SAFETY VALVE PIEZO IGNITER * Piezo models only earth yellow yellow black

Page 8 - PROPANE SUPPLY; The propane (LP) gas tank must also be equipped with the following:; REFILLING THE PROPANE GAS TANK; THE DISCONNECTED TANK MUST NEVER BE STORED IN A BUILDING,; ALL NEW CYLINDERS MUST BE PURGED BEFORE THE FIRST FILLING.

• A collar to protect the propane gas valve.• A shutoff valve terminating a Propane gas cylinder valve outlet as specified in the American National Standard for Compressed Gas Cylinder Valve Outlet and Inlet Connections.• A safety relief valve having direct communications with the vapor space of the...

Page 9 - CONNECTING HEATER TO PROPANE TANK; wrench is required, but may be used if desired.; NEVER USE AN OPEN FLAME TO CHECK FOR LEAKS.

CONNECTING HEATER TO PROPANE TANK Read and understand all safety information before connecting heater to propane tank. 1. Place heater onto tank with tank collar bracket over tank collar (Fig. 2). Mounting bolt knob should be positioned to the outside of tank collar and be positioned as closely as p...

Page 10 - FIGURE 2

CONNECTING HEATER TO PROPANE TANK 9 PROPANE TANK TOP HEATER FIGURE 2 NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

Page 11 - CHECKING FOR LEAKS; OPERATION - LIGHTING INSTRUCTIONS WHEN USING MATCH; thoroughly before installing or servicing this equipment.

Check all gas connections with a 50/50 soap and water solution to be sure they are tight and leak proof. The formation of bubbles indicate a gas leak. Correct all leaks before using the heater. • The installation of your heater must meet all local codes and/or gas utility requirements or, in the abs...

Page 12 - Be careful not to shake the heater when releasing the plunger.; FIGURE 3; Stand to the side of unit while

8. Once the burner is lit, continue to depress the valve plunger for 30 seconds and then release. Be careful not to shake the heater when releasing the plunger. 9. If the burner does not light within 10 seconds, turn regulator knob to the (OFF) [ ] position. Wait at least five (5) minutes for the ga...

Page 13 - TURNING OFF THE HEATER; VENTILATION; OPERATION - LIGHTING INSTRUCTIONS FOR PIEZO IGNITION MODELS

TURNING OFF THE HEATER 1. Tightly close propane tank valve by turning fully clockwise . 2. Turn the heater regulator knob to the (OFF) [ ] position. Wait at least 30 minutes for the heater to cool before handling heater. 3. Always remove the heater from the propane tank after each use and store indo...

Page 14 - over or near the heater while lighting.; LIGHTING INSTRUCTIONS FOR PIEZO IGNITION MODELS (CONTINUED)

1. Stop! Read all safety information first. 2. Turn heater regulator knob counterclockwise to (OFF) [ ] position. WARNING: Stand to the side of unit while lighting. Do not stand or have any part of your body over or near the heater while lighting. 3. Slowly open cylinder valve by turning countercloc...

Page 15 - LIGHTING IN WINDY AREAS; STORAGE

LIGHTING IN WINDY AREAS When using this heater indoors where there is wind, it will be necessary to use a match or long stem butane lighter to ignite the burner. It may be difficult to keep the match lit long enough under windy conditions. Follow the “Lighting instructions when Using a Match” proced...

Page 16 - TROUBLESHOOTING; REPLACEMENT PARTS LIST

TROUBLESHOOTING 1. Unit will not light. 1. Valve on propane cylinder not open. 1. Open cylinder valve by turning counterclockwise. 2. Propane cylinder empty 2. Have cylinder refilled. 3. Regulator not in "Low" position 3. Turn regulator to "Low" position. 4. Excess flow device trigge...

Page 17 - REPLACEMENT PARTS ILLUSTRATION

REPLACEMENT PARTS ILLUSTRATION 15 16 PROPANE TANK TOP HEATER NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

Page 18 - THIS PAGE INTENTIONALLY LEFT BLANK.

Page 19 - WARRANTY

LIMITED WARRANTY: This limited warranty is extended to the original retail purchaser of this Forced Air/Convection/Radiant Heater and warrants against any defect in materials and workmanship for a period of one (1) year from the date of retail sale. GHP Group, Inc., at it’s option, will either provi...

Page 20 - WARRANTY REGISTRATION; GHP

WARRANTY REGISTRATION IMPORTANT: We urge you to fill out your warranty registration card within fourteen (14)days of date of purchase. You can also register your warranty on the internet atwww.ghpgroupinc.com. Complete the entire serial number. Retain this portion of the cardfor your records. SAVE T...