Dyna-Glo TT15000M - Manuals

Page 3 - TABLE OF CONTENTS; noT For hoMe or reCreaTional vehiCle uSe.; WA R N I N G; CALIFORNIA PROPOSITION 65:; Fuels used in gas or oil fired appliances and the products of

general Safety information .............................................................................. 3 - 4 Specifications .............................................................................................................. 3 product Features ..............................................

Page 4 - PROPANE TANK TOP CONSTRUCTION HEATERS; read ThiS uSer’S Manual CareFully and CoMpleTely BeFore Trying; SPECIFICATIONS; PROPANE TANK TOP HEATER

The heater is designed and approved for use as a construction heater under anSi z83.7b, CSa 2.14b.it is hard to anticipate every use which may be made of this heater. CHECK WITH YOUR LOCAL FIRE SAFETY AUTHORITY IF YOU HAVE QUESTIONS ABOUT APPLICATIONS. PROPANE TANK TOP CONSTRUCTION HEATERS This is a...

Page 5 - PRODUCT FEATURES; • Portable & Stable; GENERAL SAFETY INSTRUCTIONS

accidents are always tragic especially because so many of them could have been prevented with little care and judgment. There are some basic good practices, we hope you will follow for safe use of your heater. • Children should be carefully supervised, when they are in the area.• Always maintain pro...

Page 6 - TT30 SERIES HEATER ASSEMBLY; FIGURE 1; DUAL BURNER MODEL; Estimated Assembly Time:

TT30 SERIES HEATER ASSEMBLY The tank collar bracket must be assembled before the heaters can be attached to the propane tank.1. Align bolt holes in tank collar bracket and piezo bracket with bolt holes in center plate on manifold.2. Drive-in two machine screws (supplied) into the bolt holes attachin...

Page 7 - WIRING DIAGRAM; electrode Cable; eleCTrode

WIRING DIAGRAM electrode Cable 6 PROPANE TANK TOP HEATER NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! eleCTrode TherMoCouple T ip over S wiTCh M,p,uSaFeTy valve piezo igni T er * Piezo models only earthyellow yellow black

Page 8 - PROPANE SUPPLY; The propane (LP) gas tank must also be equipped with the following:; REFILLING THE PROPANE GAS TANK; THE DISCONNECTED TANK MUST NEVER BE STORED IN A BUILDING,; ALL NEW CYLINDERS MUST BE PURGED BEFORE THE FIRST FILLING.

• A collar to protect the propane gas valve.• A shutoff valve terminating a Propane gas cylinder valve outlet as specified in the American National Standard for Compressed gas Cylinder valve outlet and inlet Connections.• A safety relief valve having direct communications with the vapor space of the...

Page 9 - CONNECTING HEATER TO PROPANE TANK; never uSe an open FlaMe To CheCk For leakS.

CONNECTING HEATER TO PROPANE TANK Read and understand all safety information before connecting heater to propane tank. 1. (Applies to dual burner models only). Place heater onto tank with tank collar bracket over tank collar (Fig. 1) Mounting bolt knob should be positioned to the outside of tank col...

Page 10 - PROPANE TANK TOP HEATER; FIGURE 2

CONNECTING HEATER TO PROPANE TANK Support Leg Wing Bolt Ignition Hole Safety Shut-off Valve Piezo (NOTE: some models only) Heat Regluator Knob Spark Plug (After setting support leg, tighten wing nut) 9 PROPANE TANK TOP HEATER FIGURE 2 TT30 SERIES FIGURE 3 TT15 SERIES Tip Over Switch Spark Plug Heat ...

Page 11 - CHECKING FOR LEAKS; OPERATION - LIGHTING INSTRUCTIONS WHEN USING MATCH; Burner and Burner Guard should always face away from

Check all gas connections with a 50/50 soap and water solution to be sure they are tight and leak proof. The formation of bubbles indicate a gas leak. Correct all leaks before using the heater. • The installation of your heater must meet all local codes and/or gas utility requirements or, in the abs...

Page 12 - FIGURE 5

5. Once the burner is lit, continue to depress the valve plunger for 30 seconds and then release. Be careful not to shake the heater when releasing the plunger. 6. if the burner does not light within 10 seconds, turn regulator knob to the “OFF” ( ) position. Wait at least five (5) minutes for the ga...

Page 13 - TURNING OFF THE HEATER; OPERATION - LIGHTING INSTRUCTIONS FOR PIEZO IGNITION MODELS

TURNING OFF THE HEATER 1. Tightly close propane tank valve by turning fully clockwise . 2. Turn the heater regulator knob to the “OFF” ( ) position. wait at least 30 minutes for the heater to cool before handling heater. 3. Always remove the heater from the propane tank after each use and store indo...

Page 14 - over or in front of heater while lighting.; LIGHTING INsTRUcTIONs FOR PIEzO IGNITION MODELs (cONTINUED)

1. Stop! Read all safety information first. 2. Open cylinder valve by turning counterclockwise . WARNING: stand to the side of unit while lighting. Do not stand or have any part of your body over or in front of heater while lighting. 3. Turn heater regulator knob counterclockwise to “OFF” ( ) positi...

Page 15 - LIGHTING UNDER WIND CONDITIONS; STORAGE

LIGHTING UNDER WIND CONDITIONS when using this heater outdoors on a windy day, it will be necessary to use a match or long stem butane lighter to ignite the burner. It may be difficult to keep the match lit long enough under windy conditions. Follow the “Lighting instructions when Using a Match” pro...

Page 16 - TROUBLESHOOTING; REPLACEMENT PARTS LIST

TROUBLESHOOTING 1. Unit will not light. 1. Valve on propane cylinder not open. 1. Open cylinder valve by turning counterclockwise. 2. Propane cylinder empty 2. Have cylinder refilled. 3. Regulator not in "High" position 3. Turn regulator to "High" position. 4. Excess flow device trig...

Page 17 - REPLACEMENT PARTS ILLUSTRATION

REPLACEMENT PARTS ILLUSTRATION 16 PROPANE TANK TOP HEATER TT30 SERIES TT15 SERIES REPLACEMENT PARTS ILLUSTRATION 15 16 PROPANE TANK TOP HEATER TT30 SERIES TT15 SERIES NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

Page 18 - ThiS page inTenTionally leFT Blank.

Page 19 - WARRANTY

LIMITED WARRANTY: This limited warranty is extended to the original retail purchaser of this Forced Air/Convection/Radiant Heater and warrants against any defect in materials and workmanship for a period of one (1) year from the date of retail sale. GHP Group, Inc., at it’s option, will either provi...

Page 20 - WARRANTY REGISTRATION; GHP

WARRANTY REGISTRATION IMPORTANT: We urge you to fill out your warranty registration card within fourteen (14)days of date of purchase. You can also register your warranty on the internet atwww.ghpgroupinc.com. Complete the entire serial number. Retain this portion of the cardfor your records. SAVE T...