Desa VP600BA - Manuals

Desa VP600BA – Manual in PDF format online.

Manuals:

Manual

Manual Desa VP600BA

Summary

Page 2 - VENT FREE PROPANE/LP GAS HEATER; Carbon Monoxide Poisoning:; WARNINGS; DANGER: Carbon monoxide

2 104272 VENT FREE PROPANE/LP GAS HEATER ® SAFETYINFORMATION Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning resemble theflu, with headaches, dizziness, and/or nau-sea. If you have these signs, the heater maynot be working properly. Get fresh air atonce! Have heater serviced. Som...

Page 3 - OWNER’S MANUAL; SAFETY PILOT; LOCAL CODES; American National Standards Institute, Inc.; UNPACKING; Remove heater from carton.

3 104272 OWNER’S MANUAL PRODUCTIDENTIFICATION PRODUCTFEATURES SAFETY PILOT This heater has a pilot with an OxygenDepletion Sensing (ODS) safety shutoffsystem. The ODS/pilot is a required featurefor vent-free room heaters. The ODS/pilotshuts off the heater if there is not enoughfresh air. PIEZO IGNIT...

Page 4 - Confined and Unconfined Space; Unusually Tight Construction

4 104272 VENT FREE PROPANE/LP GAS HEATER ® Confined and Unconfined Space The National Fuel Gas Code ANS Z223.1defines a confined space as a space whosevolume is less than 50 cubic feet per 1,000Btu per hour (4.8 m3 per kw) of the aggre-gate input rating of all appliances installedin that space and a...

Page 5 - DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION; Determining if You Have a Confined or Unconfined Space

5 104272 OWNER’S MANUAL WARNING: If the area in which the heater may be operated is smaller than that defined as an unconfined space or if the building is of unusually tight construction, provide adequate combustion and ventilation air by one ofthe methods described in the National Fuel Gas Code, AN...

Page 6 - Figure 2 - Ventilation Air from Inside Building; Figure 3 - Ventilation Air from Outdoors; Ventilation Air From Outdoors; Do not provide openings for

6 104272 VENT FREE PROPANE/LP GAS HEATER ® Or Remove Door into Adjoining Room, Option 3 Ventilation Grills Into Adjoining Room, Option 2 12" 12" Ventilation Grills into Adjoining Room, Option 1 Figure 2 - Ventilation Air from Inside Building AIR FORCOMBUSTION ANDVENTILATION Continued VENTILA...

Page 7 - Marking Screw Locations; WARNING: Maintain minimum; Figure 5 - Mounting Screw Locations; INSTALLATION; CHECK GAS TYPE; WARNING: Never install the

7 104272 OWNER’S MANUAL 2. Mark two mounting screw locations onwall (see Figure 5). INSTALLING HEATER TOWALL Marking Screw Locations 1. Determine where you will locate heater. WARNING: Maintain minimum clearances shown in Figure 5. Ifyou can, provide greater clear-ances from floor and joining wall. ...

Page 8 - Installing Two Mounting Screws; Wall anchors and mounting screws; Attaching To Wall Stud Method; For attaching mounting screw to wall stud; Attaching To Wall Anchor Method; Mark screw location on wall.; Removing Front Panel Of Heater

8 104272 VENT FREE PROPANE/LP GAS HEATER ® Installing Two Mounting Screws Note: Wall anchors and mounting screws are in hardware package. The hardware pack-age is provided with heater. Attaching To Wall Stud Method For attaching mounting screw to wall stud 1. Drill hole at marked location using 9/64...

Page 9 - WARNING: A qualified service; Figure 13 - Gas Connection; Hold pressure regulator

9 104272 OWNER’S MANUAL CONNECTING TO GASSUPPLY WARNING: A qualified service person must connect heater to gassupply. Follow all local codes. The installer must supply an external regu-lator. The external regulator will reduceincoming gas pressure. You must reduceincoming gas pressure between 11 and...

Page 10 - WARNING: Never use an open; Correct all leaks at once.; Figure 14 - Equipment Shutoff Valve; Figure 15 - Checking Gas Joints; FOR YOUR SAFETY; A. This appliance has a pilot which

10 104272 VENT FREE PROPANE/LP GAS HEATER ® CHECKING GASCONNECTIONS Pressure Testing Gas SupplyPiping System Test Pressures In Excess Of 1/2 PSIG(3.5 kPa) 1. Disconnect appliance with its appliancemain gas valve (control valve) and equip-ment shutoff valve from gas supply pip-ing system. Pressures i...

Page 11 - Shutting Off Heater

11 104272 OWNER’S MANUAL Shutting Off Heater 1. Turn control knob clockwise Clockwise to the PILOT position. 2. Press in control knob and turn clock-wise Clockwise to the OFF position. Shutting Off Burner Only (pilotstays lit) Turn control knob clockwise Clockwise to the PILOT position. 1. Remove fr...

Page 12 - Figure 19 - Incorrect Pilot Flame Pattern; BURNER FLAME PATTERN; WARNING: If yellow tipping; Figure 20 - Correct Burner Flame Pattern; WARNING: Turn off heater; PILOT FLAME PATTERN; Figure 18 - Correct Pilot Flame Pattern; CABINET; Air Passageways; Figure 22 - Pilot Inlet Air Hole

12 104272 VENT FREE PROPANE/LP GAS HEATER ® Thermocouple Pilot Burner Figure 19 - Incorrect Pilot Flame Pattern GRH/OV 008 BAD PILOT/LP BURNER FLAME PATTERN Figure 20 shows a correct burner flamepattern. Figure 21 shows an incorrect burnerflame pattern. The incorrect burner flamepattern shows yellow...

Page 13 - TROUBLESHOOTING; POSSIBLE CAUSE; All troubleshooting items are listed in

13 104272 OWNER’S MANUAL TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Onlya qualified service person shouldservice and repair heater. CAUTION: Never use a wire, needle, or similar object to cleanODS/pilot. This can damage ODS/pilot unit. POSSIBLE CAUSE 1. Ignitor electrode...

Page 14 - OBSERVED PROBLEM; nance, page 12) or replace burner orifice

14 104272 VENT FREE PROPANE/LP GAS HEATER ® OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Yellow flame during burner combustion Slight smoke or odor during initial operation Heater produces a whistling noise whenburner is...

Page 15 - IMPORTANT; REMEDY

15 104272 OWNER’S MANUAL WARNING: If you smell gas • Shut off gas supply.• Do not try to light any appliance.• Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. • If you can...

Page 17 - PARTS LIST; KEY

17 104272 OWNER’S MANUAL This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listedunder Replacement Parts on page 18 of this manual. PARTS LIST VP600BA KEY PART NO. NUMBER DESCRIPTION QTY. 1 098304-01 Screw, #10 x 3/8" 2 2 099467-03 Front Panel...

Page 18 - PARTS UNDER WARRANTY; ACCESSORY; When Gas Pressure Is Too Low; SERVICE HINTS

18 104272 VENT FREE PROPANE/LP GAS HEATER ® Note: Use only original replacement parts. This will protect your warranty coverage forparts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealer from whom youpurchased this product. If they cannot sup-ply original replacement part(s), c...

Page 19 - NOTES

19 104272 OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _____________________________________________________________________________...

Page 20 - KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; INTERNATIONAL; LIMITED WARRANTY; NOT A UPC

KEEP THIS WARRANTY WARRANTY INFORMATION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.We make no other warranty, expressed or im...