Desa VP1000BT - Manuals

Desa VP1000BT – Manual in PDF format online.

Manuals:

Manual

Manual Desa VP1000BT

Summary

Page 2 - PROPANE/LP GAS HEATER; Carbon Monoxide Poisoning:; WARNINGS; DANGER: Carbon monoxide

2 102393 PROPANE/LP GAS HEATER BLUE FLAME 10,000 BTU SAFETYINFORMATION Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning re-semble the flu, with headaches, dizziness,and/or nausea. If you have these signs, theheater may not be working properly. Getfresh air at once! Have heater ser...

Page 3 - OWNER’S MANUAL; SAFETY PILOT; LOCAL CODES; American National Standards Institute, Inc.; UNPACKING; Remove heater from carton.; WARNING: This heater shall

3 102393 OWNER’S MANUAL PRODUCTIDENTIFICATION PRODUCTFEATURES SAFETY PILOT This heater has a pilot with an OxygenDepletion Sensor Shutoff System (ODS).The ODS/pilot is a required feature for vent-free room heaters. The ODS/pilot shuts offthe heater if there is not enough fresh air. PIEZO IGNITION SY...

Page 4 - Unusually Tight Construction; Gas water heater; Confined and Unconfined Space

4 102393 PROPANE/LP GAS HEATER BLUE FLAME 10,000 BTU WARNING: If the area in which the heater may be operated issmaller than that defined as anunconfined space, provide ad-equate combustion and ventila-tion air by one of the methodsdescribed in the National Fuel Gas Code, ANSI Z223.1, 1992,Section 5...

Page 5 - Figure 2 - Ventilation Air from Inside Building; Figure 3 - Ventilation Air from Outdoors; Ventilation Air From Outdoors

5 102393 OWNER’S MANUAL Figure 2 - Ventilation Air from Inside Building Or Remove Door into Adjoining Room, Option 3 Ventilation Grills Into Adjoining Room, Option 2 12" 12" Ventilation Grills into Adjoining Room, Option 1 WARNING: Rework work- sheet, adding the space of theadjoining unconfi...

Page 6 - Figure 5 - Mounting Screw Locations; JOINING WALL; Marking Screw Locations; Determine where you will locate heater.; WARNING: Maintain minimum; For convenience and efficiency, install heater; CHECK GAS TYPE

6 102393 PROPANE/LP GAS HEATER BLUE FLAME 10,000 BTU Figure 5 - Mounting Screw Locations Mounting Screw Locations 8 7/8" Minimum To Maintain 6" ClearanceFrom Wall 7 3/4" 20 1/4" Minimum To Maintain 3" Clearance From Floor FLOOR JOINING WALL INSTALLING HEATER TOWALL Marking Screw ...

Page 7 - Installing Two Mounting Screws; Wall anchors and mounting screws; Attaching to wall stud method; For attaching mounting screw to wall stud; Figure 8 - Tightening Anchors; Mark screw location on wall.; Removing Front Panel Of Heater

7 102393 OWNER’S MANUAL Installing Two Mounting Screws Note: Wall anchors and mounting screws are in hardware package. The hardware pack-age is provided with heater. Attaching to wall stud method For attaching mounting screw to wall stud 1. Drill hole at marked location using9/64" drill bit. 2. ...

Page 8 - Hold pressure regulator; Figure 13 - Gas Connection; CAUTION: Never connect

8 102393 PROPANE/LP GAS HEATER BLUE FLAME 10,000 BTU IMPORTANT: Hold pressure regulator with wrench when connecting it to gaspiping and/or fittings. Figure 13 - Gas Connection * An A.G.A. design-certified manual shutoff valve with 1/8" NPT tap is an acceptablealternative to test gauge connection...

Page 9 - WARNING: Never use an open; Correct all leaks at once.; Figure 14 - Manual Shutoff Valve; Figure 15 - Checking Gas Joints

9 102393 OWNER’S MANUAL CHECKING GASCONNECTIONS PRESSURE TESTING GASSUPPLY PIPING SYSTEM Test Pressures In Excess Of 1/2PSIG 1. Disconnect heater and its individualmanual shutoff valve from gas supplypiping system. Pressures in excess of1/2 Psig will damage heater regulator. 2. Cap off open end of g...

Page 10 - CAUTION: Do not try to adjust; Shutting Off Heater; The thermostat sensing bulb mea-

10 102393 PROPANE/LP GAS HEATER BLUE FLAME 10,000 BTU TO TURN OFF GASTO APPLIANCE 1. Remove front panel (see Figure 10,page 7). 2. Follow steps 1 through 5 under Light-ing Instructions. 3. With control knob pressed in, strikematch. Hold match to pilot until pi-lot lights. 4. Keep control knob presse...

Page 11 - PILOT FLAME PATTERN; Figure 18 - Correct Pilot Flame Pattern; Figure 19 - Incorrect Pilot Flame Pattern; BURNER FLAME PATTERN; WARNING: If yellow tipping; CABINET; Air Passageways; WARNING: Turn off heater; Figure 20 - Correct Burner Flame Pattern; Figure 21 - Incorrect Burner Flame Pattern

11 102393 OWNER’S MANUAL GRH/OV 008 BAD PILOT/LP INSPECTINGBURNER Check pilot flame pattern and burner flamepattern often. PILOT FLAME PATTERN Figure 18 shows a correct pilot flame pat-tern. Figure 19 shows an incorrect pilotflame pattern. The incorrect pilot flame isnot touching the thermocouple. T...

Page 12 - TROUBLESHOOTING; POSSIBLE CAUSE

12 102393 PROPANE/LP GAS HEATER BLUE FLAME 10,000 BTU TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off heater and let cool before servicing.Only a qualified service per-son should service and repairheater. CAUTION: Never use a wire, needle, or simil...

Page 13 - REMEDY

13 102393 OWNER’S MANUAL TROUBLESHOOTING Continued REMEDY 1. Clean burner orifice (see Cleaning and Maintenance, page 11) or replace burnerorifice 2. Replace burner orifice3. Contact local propane/LP gas company 1. Contact local propane/LP gas company2. Clean burner orifice (see Cleaning and Mainten...

Page 14 - OBSERVED PROBLEM; IMPORTANT

14 102393 PROPANE/LP GAS HEATER BLUE FLAME 10,000 BTU WARNING: If you smell gas • Shut off gas supply.• Do not try to light any appliance.• Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier...

Page 15 - SPECIFICATIONS; When gas pressure is too low; SERVICE HINTS; Parts Under Warranty; ACCESSORY

15 102393 OWNER’S MANUAL SPECIFICATIONS VP1000BT Btu(Variable) 5,000/10,000 Type Gas Propane/LP Only Ignition Piezo Pressure Regulator Setting 8" W.C. Inlet Gas Pressure (inches of water) 14" Max. / 11" Min. Heater Dimensions (Includes knobs and grill) 21.5" (H) x 13.5" (W) x 7&#...

Page 17 - PARTS LIST; KEY

17 102393 OWNER’S MANUAL This list contains replaceable parts used in your heater. When ordering parts, follow the instructionslisted under Replacement Parts on page 15 of this manual. PARTS LIST KEY PART NO. NUMBER DESCRIPTION QTY. 1 098304-01 Screw, #10 x 3/8" 2 2 099467-03 Front Panel Assembl...

Page 18 - NOTES

18 102393 PROPANE/LP GAS HEATER BLUE FLAME 10,000 BTU NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ ________________________________________________...

Page 20 - KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; LIMITED WARRANTY; For information about this warranty write:

KEEP THIS WARRANTY WARRANTY INFORMATION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standardwritten warranty. We make no other warranty, expressed or im...