Desa TC100RNG - Manuals - manualsarea.com

Page 2 - NATURAL GAS CONSTRUCTION HEATER; The gas supply at-; UNPACKING; WARNING: NOT FOR HOME; WARNINGS

2 104131 NATURAL GAS CONSTRUCTION HEATER TC100RNG THEORY OFOPERATION The Fuel System: The gas supply at- taches to the heater by a minimum 3/4 inchi.d. hose or flexible connector. User mustsupply hose or flexible connector. The lengthshould be no more than 10 feet long. Thenatural gas moves through ...

Page 3 - OWNER’S MANUAL; VENTILATION; WARNING: Provide at least a; SPECIFICATIONS; INSTALLATION

3 104131 OWNER’S MANUAL PRODUCTIDENTIFICATION NATURAL GASSUPPLY The user must furnish the natural gas supplyand the connections to the heater. Regulate the natural gas supply down froma minimum 6 inches water column to amaximum of 1/2 psi. The natural gas supplycapacity should be able to supply a mi...

Page 4 - TO STOP HEATER; STORAGE; CAUTION: Disconnect heater; TO START HEATER; OPERATION; TO RESTART HEATER

4 104131 NATURAL GAS CONSTRUCTION HEATER TC100RNG TO STOP HEATER 1. Close valve on gas supply. 2. Turn control valve knob 1/4 turn toright to PILOT position. Slightly pushin knob and turn 1/4 turn to right to OFFposition (see Figure 6). STORAGE 1. Place plastic cover cap over brass fit-ting on inlet...

Page 5 - MAINTENANCE; WARNING: Never service; PARTS UNDER WARRANTY; WARNING: Use only original

5 104131 OWNER’S MANUAL MAINTENANCE 1. Keep heater clean. Clean heater annu-ally or as needed to remove dust anddebris. If heater is dirty or dusty, cleanheater with a damp cloth. 2. Inspect heater before each use. Checkconnections for leaks. Apply mixtureof liquid soap and water to connections.Bubb...

Page 7 - PARTS LIST; KEY

7 104131 OWNER’S MANUAL PARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow theinstructions listed under Replacement Parts on page 5 of this manual. KEY TC100RNG NO. PART NO. DESCRIPTION QTY. 1 104145-01 Upper Disk 1 2 103897-01 Emitter 1 3 103898-01 Shel...

Page 8 - SYMPTOM; TROUBLESHOOTING; WARNING: Never service heater while it is connected to gas

8 104131 NATURAL GAS CONSTRUCTION HEATER TC100RNG SYMPTOM Pilot fails to light. Pilot lights but goes outwhen control valve knob isreleased. Maximum burn rate is low;emitter not glowing. Soot forming inside heater,flame 100% yellow. Flames are extremely high.Coming out of louvers POSSIBLE CAUSE 1. N...

Page 9 - NOTES

9 104131 OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ ______________________________________________________________________________...

Page 12 - WARRANTY AND REPAIR SERVICE; LIMITED WARRANTY; NOT A UPC

For information, write: DESA International, P.O. Box 90004 Bowling Green, Kentucky 42102-9004 ATTN: Customer Service Department When writing, always include model number and serial number. 104131-01Rev. C10/97 DESA International warrants this product and any parts thereof, to be free from defects in...