Desa RM30LP - Manuals - manualsarea.com

Page 2 - PROPANE CONSTRUCTION HEATER; WARNING: NOT FOR HOME; Carbon Monoxide Poisoning:; WARNINGS; Propane gas is odorless. An

2 105343 PROPANE CONSTRUCTION HEATER 30,000 BTU/Hr SAFETYINFORMATION WARNING: FIRE, BURN, IN- HALATION, AND EXPLOSIONHAZARD. KEEP SOLID COMBUS-TIBLES, SUCH AS BUILDING MA-TERIALS, PAPER OR CARD-B O A R D , A S A F E D I S T A N C EAWAY FROM THE HEATER ASRECOMMENDED BY THE IN-STRUCTIONS. NEVER USE TH...

Page 3 - OWNER’S MANUAL; UNPACKING; Remove all items from carton.; The hose/regulator; The piezo ignitor; The Automatic Control System:; This

3 105343 OWNER’S MANUAL Air For Combustion Air For Heating PRODUCTIDENTIFICATION Figure 1 - 30,000 BTU/Hr Model UNPACKING 1. Remove all packing items applied toheater for shipment. Keep plastic covercaps (attached to inlet connector andhose/regulator assembly) for storage. 2. Remove all items from c...

Page 4 - INSTALLATION; At Tank Location; ASSEMBLY; Position regulator so

4 105343 PROPANE CONSTRUCTION HEATER 30,000 BTU/Hr INSTALLATION WARNING: Review and un- derstand the warnings in theSafety Information section, page2. They are needed to safely op-erate this heater. Follow all localcodes when using this heater. WARNING: Test all gas pip- ing and connections for leak...

Page 5 - VENTILATION; WARNING: Provide at least a; OPERATION; To Stop Heater; Wait five minutes after stopping heater.; WARNING: Be sure motor and; If heater fails to ignite, hose may; To Start Heater; • U p t o 5 0 f t l o n g , u s e 1 8 AW G

5 105343 OWNER’S MANUAL VENTILATION WARNING: Provide at least a one square foot opening of fresh,outside air while running heater.If proper fresh, outside air venti-lation is not provided, carbonmonoxide poisoning can occur.Provide proper fresh, outside airventilation before running heater. OPERATIO...

Page 6 - STORAGE

6 105343 PROPANE CONSTRUCTION HEATER 30,000 BTU/Hr STORAGE 1. Store propane tank(s) in safe manner.See Chapter 5 of Standard for Storageand Handling of Liquefied PetroleumGases, ANSI/NFPA 58. Follow all lo-cal codes. Always store propane tanksoutdoors. 2. Place plastic cover caps over brassfittings ...

Page 7 - TROUBLESHOOTING; OBSERVED FAULT; WARNING: Never service heater while it is plugged in, connected

7 105343 OWNER’S MANUAL TROUBLESHOOTING 1. Check voltage to electrical outlet. If volt- age is good, check heater power cord forbreaks 2. Adjust motor/fan guard to keep fan from hitting inside of heater shell. Bend fanguard if necessary 3. Replace fan. See Fan, page 94. Replace motor. See Motor, pag...

Page 8 - WARNING: Never service; ELECTRICAL SYSTEM; Attach green power cord wire to motor.

8 105343 PROPANE CONSTRUCTION HEATER 30,000 BTU/Hr SERVICEPROCEDURES WARNING: Never service heater while it is plugged in, con-nected to propane supply, oper-ating, or hot. Severe burns andelectrical shock can occur. You can also visit DESA International’sTechnical Service web site at www.desatech.c...

Page 9 - FAN; b. If cleaning fan,use soft cloth moistened

9 105343 OWNER’S MANUAL FAN 1. Remove three screws that attach fanguard to heater shell. 2. Remove motor and fan guard fromheater shell (see Figure 13). 3. Use hex wrench to loosen set screw thatholds fan to motor shaft (see Figure 14). 4. Remove fan. Be careful not to damagethe fan blade pitch. 5a....

Page 10 - IGNITOR; Remove ignitor from rear head.; WARNING: Make sure heater

10 105343 PROPANE CONSTRUCTION HEATER 30,000 BTU/Hr IGNITOR 1. Remove motor and fan guard from heater(see Motor, page 8, steps 1 and 2). 2. Remove black ignitor wire from piezoignitor. Access ignitor wire through un-derside of heater base (see Figure 16).Push wire up through notch in fillerpanel. 3....

Page 11 - ACCESSORIES; WARNING: Use only original; Parts Under Warranty

11 105343 OWNER’S MANUAL ACCESSORIES Purchase accessories and parts from yournearest dealer or service center. If they cannot supply an accessory or part, either con-tact your nearest Parts Central (listed in theseparate Authorized Service Center book-let) or contact DESA International for refer-ral...

Page 13 - PARTS LIST

13 105343 OWNER’S MANUAL PARTS LIST RM30LP This list contains replaceable parts used in your heater. When ordering parts, follow theinstructions listed under Replacement Parts on page 11 of this manual. KEY PART NO. NO. DESCRIPTION QTY. 1 104154-01 Combustion Chamber 1 2 104152-01 Unichassis 1 3 M11...

Page 14 - WARRANTY AND REPAIR SERVICE; LIMITED WARRANTY; Model; WARRANTY SERVICE; Complete the following information for future reference.; NOT A UPC; INTERNATIONAL

WARRANTY AND REPAIR SERVICE LIMITED WARRANTY KEEP THIS WARRANTY For information, write: DESA International, P.O. Box 90004 Bowling Green, Kentucky 42102-9004 ATTN: Customer Service Department When writing, always include model number and serial number. 105343-01Rev. B03/00 Model Serial No. Date of P...