Desa REM10PT - Manuals - manualsarea.com

Page 2 - TABLE OF CONTENTS; WARNINGS; SAFETY INFORMATION

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 2 TABLE OF CONTENTS SAFETY INFORMATION ............................................................ 2 PRODUCT IDENTIFICATION .......

Page 3 - Continued; PRODUCT IDENTIFICATION; UNPACKING

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 3 3 SAFETY INFORMATION PRODUCT IDENTIFICATION UNPACKING 1. Install and use heater with care. Follow all local ordinancesand codes...

Page 4 - For convenience and efficiency, install heater; Figure 2 - Mounting Clearances As Viewed From Front of Heater; LOCAL CODES; American National Standards Institute, Inc.; PRODUCT FEATURES; SAFETY PILOT; INSTALLATION; CHECK GAS TYPE

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 4 CAUTION: If you install the heater in a home garage • heater pilot and burner must be at least 18 inches above floor • locate h...

Page 5 - THERMOSTAT SENSING BULB; Marking Screw Locations; Determine where you will locate heater.; Installing Two Mounting Screws; Wall anchors and mounting screws are in hardware package.; WARNING: Maintain minimum clearances shown; For attaching mounting screw to wall stud; IMPORTANT; Placing Heater On Mounting Screws; Locate two keyhole slots on back panel of heater (see Figure 7).

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 5 5 INSTALLATION Thermostat Sensing Bulb Installing Heater To Wall THERMOSTAT SENSING BULB The thermostat sensing bulb is located...

Page 6 - Figure 10 - Regulator Position; Installing Bottom Mounting Screw; Mark screw location on wall.; WARNING: Review and understand the warnings; You must use a propane/LP gas supply cylinder that; WARNING: Test all gas piping and connections; Figure 9 - Installing Bottom Mounting Screw

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 6 Propane/LPTank Propane/LPSupplyValve Regulator Hose ToHeater Fuel GasFitting Figure 10 - Regulator Position Figure 11 - Gas Con...

Page 7 - WARNING: A qualified service person must con-; CONNECTING TO PERMANENT GAS SUPPLY; INSTALLATION ITEMS; WARNING: Use pipe joint sealant that is resistant; Figure 12 - External Regulator With Vent Pointing Down

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 7 7 INSTALLATION Connecting To Permanent Gas Supply INSTALLATION Continued WARNING: A qualified service person must con- nect hea...

Page 8 - Pressure Testing Gas Supply Piping System; Correct all leaks at once.; Figure 14 - Equipment Shutoff Valve; Figure 13 - Gas Connection; Hold the pressure regulator with wrench when

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 8 Pressure Testing Gas Supply Piping System Test Pressures In Excess Of 1/2 PSIG (3.5 kPa) 1. Disconnect appliance with its appli...

Page 9 - Figure 15 - Checking Gas Joints; OPERATING HEATER; FOR YOUR SAFETY READ; WARNING: If you do not follow these instructions; Pressure Testing Heater Gas Connections; Make sure control knob of heater is in the OFF position.; LIGHTING INSTRUCTIONS

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 9 9 CHECKING GAS CONNECTIONS FORPERMANENT GAS SUPPLY (CONTINUED) INSTALLATION Continued INSTALLATION Checking Gas Connections For...

Page 10 - CAUTION: Do not try to adjust heating levels by; Figure 16 - Control Knob In The OFF Position; Shutting Off Heater

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 10 OPERATING HEATER Continued OPERATING HEATER Lighting InstructionsTo Turn Off Gas To ApplianceThermostat Control OperationManua...

Page 11 - PILOT FLAME PATTERN; INSPECTING BURNER; STORAGE; WARNING: If yellow tipping occurs, your heater; Figure 18 - Correct Pilot Flame Pattern; STORAGE; CAUTION: Disconnect heater from propane/LP

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 11 11 INSPECTING BURNER Check pilot flame pattern and burner flame pattern often. PILOT FLAME PATTERN Figure 18 shows a correct p...

Page 12 - CLEANING AND MAINTENANCE; CABINET; Air Passageways; Figure 22 - Pilot Inlet Air Hole; CLEANING BURNER PILOT AIR INLET; WARNING: Turn off heater and let cool before; Figure 23 - Injector Holder On Burner Tube

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 12 CLEANING AND MAINTENANCE ODS/Pilot and BurnerCleaning Burner Pilot Air InletCabinet CABINET Air Passageways • Use a vacuum cle...

Page 13 - WARNING: Turn off heater; POSSIBLE CAUSE; All troubleshooting items are listed in; TROUBLESHOOTING

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 13 13 TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing.Only a qualified service per-son should service and ...

Page 14 - REMEDY; nance, page 12) or replace burner orifice

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 14 TROUBLESHOOTING TROUBLESHOOTING Continued REMEDY 1. Clean burner orifice (see Cleaning and Maintenance, page 12) or replace bu...

Page 15 - OBSERVED PROBLEM

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 15 15 TROUBLESHOOTING WARNING: If you smell gas • Shut off gas supply.• Do not try to light any appliance.• Do not touch any elec...

Page 16 - ILLUSTRATED PARTS BREAKDOWN; PILOT

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 16 1 2 3 4 5 6 7 9 8 10 13 14 15 16 17 18 21 22 24 14 20 23 19 10 12 11 ILLUSTRATED PARTSBREAKDOWN REM10PT ILLUSTRATED PARTS BREA...

Page 17 - PARTS LIST; KEY

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 17 17 PARTS LIST REM10PT This list contains replaceable parts used in your heater. Whenordering parts, follow the instructions li...

Page 18 - When Gas Pressure Is Too Low; PARTS UNDER WARRANTY; Part Number; Hose/Regulator Assembly

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 18 SPECIFICATIONS REM10PT Btu(Variable) 5,000/10,000 Type Gas Propane/LP Only Ignition Piezo Internal Regulator Setting 8" W....

Page 19 - OWNER'S REGISTRATION FORM

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 19 19 1. If you bought this product yourself, did you plan to purchase this type of product before going into the store? ❍ Yes ❍ ...

Page 20 - Postage; T APE

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 20 2701 Industrial DriveP.O. Box 90004Bowling Green, KY 42102-9004 Postage Required TM T APE TAPE

Page 21 - NOTES

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 21 21 NOTES _______________________________________________________________________________________________ _____________________...

Page 22 - KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; NOT A UPC; LIMITED WARRANTY

110373-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 22 KEEP THIS WARRANTY WARRANTY INFORMATION Always specify model and serial numbers when communicating with the factory. We reserv...