Desa FGHS30NGB - Manuals

Desa FGHS30NGB – Manual in PDF format online.

Manuals:

Manual

Manual Desa FGHS30NGB

Summary

Page 2 - BLUE FLAME NATURAL GAS HEATER; Carbon Monoxide Poisoning:; Early signs; WARNINGS; DANGER: Carbon monoxide

2 107340 BLUE FLAME NATURAL GAS HEATER Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning resemble theflu, with headaches, dizziness, or nausea. Ifyou have these signs, the heater may not beworking properly. Get fresh air at once!Have heater serviced. Some people are moreaffected by...

Page 3 - OWNER’S MANUAL; LOCAL CODES; American National Standards Institute, Inc.; UNPACKING; Remove heater from carton.; SAFETY DEVICE

3 107340 OWNER’S MANUAL PRODUCTIDENTIFICATION LOCAL CODES Install and use heater with care. Follow alllocal codes. In the absence of local codes, usethe latest edition of National Fuel Gas Code,ANS Z223.1, also known as NFPA 54*. *Available from: American National Standards Institute, Inc. 1430 Broa...

Page 4 - Unusually Tight Construction; per

4 107340 BLUE FLAME NATURAL GAS HEATER AIR FORCOMBUSTION ANDVENTILATION Today’s homes are built more energy effi-cient than ever. New materials, increasedinsulation, and new construction methodshelp reduce heat loss in homes. Home ownersweather strip and caulk around windows anddoors to keep the col...

Page 5 - Determining if You Have a Confined or Unconfined Space

5 107340 OWNER’S MANUAL AIR FORCOMBUSTION ANDVENTILATION Continued DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION Determining if You Have a Confined or Unconfined Space Use this worksheet to determine if you have a confined or unconfined space. Space: Includes the room in which you will install heat...

Page 6 - Figure 3 - Ventilation Air from Outdoors; Ventilation Air From Outdoors; Do not provide openings for; Figure 2 - Ventilation Air from Inside Building

6 107340 BLUE FLAME NATURAL GAS HEATER Figure 3 - Ventilation Air from Outdoors OutletAir VentilatedAttic OutletAir InletAir Inlet Air Ventilated Crawl Space To Crawl Space To Attic Ventilation Air From Outdoors Provide extra fresh air by using ventilationgrills or ducts. You must provide two per-ma...

Page 7 - INSTALLATION; CHECK GAS TYPE; CAUTION: If you install the; LOCATING HEATER

7 107340 OWNER’S MANUAL 36" 16.75" FLOOR CEILING Minimum Minimum to Top of Carpeting, Tile,or Other Combustible Material 6" MinimumFromSides ofHeater LeftSide RightSide INSTALLATION Continued CHECK GAS TYPE Use only natural gas. If your gas supply is notnatural, do not install heater. Ca...

Page 8 - Figure 8 - Mounting Bracket Clearances; WARNING: Maintain minimum; Figure 7 - Removing Front Panel Of Heater; Attaching to wall stud; Attaching To Wall Stud:; This method; Removing Front Panel Of Heater; Marking Screw Locations; Only mark last hole on each end; Mounting Bracket; Figure 5 - Mounting Bracket

8 107340 BLUE FLAME NATURAL GAS HEATER Figure 8 - Mounting Bracket Clearances WARNING: Maintain minimum clearances shown in Figure 7. Ifyou can, provide greater clear-ances from floor and joining wall. Figure 7 - Removing Front Panel Of Heater Methods For AttachingMounting Bracket To Wall Only use l...

Page 9 - Figure 9 - Folding Anchor; Attaching To Wall Stud Method; For attaching mounting bracket to wall studs; Attaching To Wall Anchor Method; Fold wall anchor as shown in Figure 9.; Mark screw locations on wall.; Do not replace front panel at this

9 107340 OWNER’S MANUAL Figure 9 - Folding Anchor INSTALLATION Continued Attaching Mounting Bracket ToWall Note: Wall anchors, mounting screws, and spacers are in hardware package. The hard-ware package is provided with heater. Attaching To Wall Stud Method For attaching mounting bracket to wall stu...

Page 10 - WARNING: A qualified service; Install an equipment shutoff; ant that is resistant to natural gas.; Check gas line pressure be-; Figure 13 - Gas Connection

10 107340 BLUE FLAME NATURAL GAS HEATER CONNECTING TO GASSUPPLY WARNING: A qualified service person must connect heater togas supply. Follow all local codes. WARNING: Never connect heater to private (non-utility) gaswell. This gas is commonly knownas wellhead gas. Typical Inlet Pipe Diameters FGHS30...

Page 11 - Figure 14 - Equipment Shutoff Valve; WARNING: Never use an open; Correct all leaks at once.; FOR YOUR SAFETY

11 107340 OWNER’S MANUAL O POS PO Figure 14 - Equipment Shutoff Valve Figure 15 - Checking Gas Joints EquipmentShutoffValve Closed WARNING: Test all gas pip- ing and connections for leaksafter installation or servicing.Correct all leaks at once. WARNING: Never use an open flame to check for a leak. ...

Page 12 - Shutting Off Heater; CAUTION: Do not try to adjust

12 107340 BLUE FLAME NATURAL GAS HEATER TO TURN OFF GAS TO APPLIANCE 1. Remove front panel (see Figure 7,page 8). 2. Follow steps 1 through 5 under Light-ing Instructions. 3. With control knob pressed in, strikematch. Hold match to pilot until pi-lot lights. 4. Keep control knob pressed in for 30sec...

Page 13 - Figure 19 - Incorrect Pilot Flame Pattern; PILOT FLAME PATTERN; Figure 18 - Correct Pilot Flame Pattern; BURNER FLAME PATTERN; Figure 20 - Correct Burner Flame Pattern; WARNING: If yellow tipping; Figure 22 - Pilot Inlet Air Hole; CABINET; Air Passageways

13 107340 OWNER’S MANUAL Figure 19 - Incorrect Pilot Flame Pattern Thermocouple Pilot Burner INSPECTINGBURNER Check pilot flame pattern and burner flamepattern often. PILOT FLAME PATTERN Figure 18 shows a correct pilot flame pattern.Figure 19 shows an incorrect pilot flamepattern. The incorrect pilo...

Page 14 - TROUBLESHOOTING; All troubleshooting items are listed in; POSSIBLE CAUSE

14 107340 BLUE FLAME NATURAL GAS HEATER TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off and un- plug heater and let cool beforeservicing. Only a qualified ser-vice person should service andrepair heater. CAUTION: Never use a wire, needle, or simila...

Page 15 - OBSERVED PROBLEM; nance, page 13) or replace burner orifice

15 107340 OWNER’S MANUAL OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Yellow flame during burner combustion Slight smoke or odor during initial operation Heater produces a whistling noise whenburner is lit White powder r...

Page 16 - IMPORTANT

16 107340 BLUE FLAME NATURAL GAS HEATER WARNING: If you smell gas • Shut off gas supply.• Do not try to light any appliance.• Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instruction...

Page 17 - PARTS CENTRALS

17 107340 OWNER’S MANUAL Baltimore Electric 1348 Dixwell AvenueHamden, CT 06514-03221-800-397-7553203-248-7553Parts Department Portable Heater Parts 342 N. County Rd. 400 EastValparaiso, IN 46383-9704All States219-462-74411-800-362-6951sales@[email protected]...

Page 19 - PARTS LIST; PART NUMBER

19 107340 OWNER’S MANUAL PARTS LIST THERMOSTAT MODELFGHS30NGB This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listedunder Replacement Parts on page 17 of this manual. KEYNO. PART NUMBER DESCRIPTION QTY. 1 L98409-09 Cabinet Assembly 1 2 L98006-01...

Page 20 - ACCESSORIES; When Gas Pressure Is Too Low; PARTS UNDER WARRANTY

20 107340 BLUE FLAME NATURAL GAS HEATER FAN KITS - UH1000FB, ANDUHS1000FB For all models. Provides better heat distri-bution. Makes heater more efficient. Com-plete installation and operating instructionsincluded. Manually-controlled - UH1000FB. IncludesON/OFF switch. Thermostatically-controlled - U...

Page 21 - NOTES

21 107340 OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _____________________________________________________________________________...

Page 22 - KEEP THIS WARRANTY; Model; WARRANTY INFORMATION; INTERNATIONAL; NOT A UPC

KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard writtenwarranty. We make no other warranty, expr...