Desa FAS-20BB - Manuals

Desa FAS-20BB – Manual in PDF format online.

Manuals:

Manual

Manual Desa FAS-20BB

Summary

Page 2 - BLUE FLAME NATURAL GAS HEATER; Carbon Monoxide Poisoning:; Early signs; WARNINGS; DANGER: Carbon monoxide

2 105568 BLUE FLAME NATURAL GAS HEATER Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning resemble theflu, with headaches, dizziness, or nausea. Ifyou have these signs, the heater may not beworking properly. Get fresh air at once!Have heater serviced. Some people are moreaffected by...

Page 3 - OWNER’S MANUAL; LOCAL CODES; American National Standards Institute, Inc.; UNPACKING; Remove heater from carton.; SAFETY DEVICE

3 105568 OWNER’S MANUAL PRODUCTIDENTIFICATION LOCAL CODES Install and use heater with care. Follow alllocal codes. In the absence of local codes, usethe latest edition of National Fuel Gas CodeANS Z223.1, also known as NFPA 54*. *Available from: American National Standards Institute, Inc. 1430 Broad...

Page 4 - Unusually Tight Construction; per

4 105568 BLUE FLAME NATURAL GAS HEATER AIR FORCOMBUSTION ANDVENTILATION Today’s homes are built more energy effi-cient than ever. New materials, increasedinsulation, and new construction methodshelp reduce heat loss in homes. Home ownersweather strip and caulk around windows anddoors to keep the col...

Page 5 - Determining if You Have a Confined or Unconfined Space

5 105568 OWNER’S MANUAL AIR FORCOMBUSTION ANDVENTILATION Continued DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION Determining if You Have a Confined or Unconfined Space Use this worksheet to determine if you have a confined or unconfined space. Space: Includes the room in which you will install heat...

Page 6 - Figure 3 - Ventilation Air from Outdoors; Ventilation Air From Outdoors; Do not provide openings for; Figure 2 - Ventilation Air from Inside Building

6 105568 BLUE FLAME NATURAL GAS HEATER Figure 3 - Ventilation Air from Outdoors OutletAir VentilatedAttic OutletAir InletAir Inlet Air Ventilated Crawl Space To Crawl Space To Attic Ventilation Air From Outdoors Provide extra fresh air by using ventilationgrills or ducts. You must provide two per-ma...

Page 7 - INSTALLATION; CHECK GAS TYPE; CAUTION: If you install the; LOCATING HEATER

7 105568 OWNER’S MANUAL 36" 2" FLOOR CEILING Minimum Minimum to Top of Carpeting, Tile,or Other Combustible Material 6" MinimumFromSides ofHeater LeftSide RightSide INSTALLATION Continued CHECK GAS TYPE Use only natural gas. If your gas supply is notnatural, do not install heater. Call d...

Page 8 - Figure 8 - Mounting Bracket Clearances; WARNING: Maintain minimum; Figure 7 - Removing Front Panel Of Heater; Attaching to wall stud; Attaching To Wall Stud:; This method; Removing Front Panel Of Heater; Marking Screw Locations; Only mark last hole on each end; For T-Stat Models Only; Figure 5 - Mounting Bracket

8 105568 BLUE FLAME NATURAL GAS HEATER Models FA-30BB, FAS-30BB, and FGH-30NGB Models FA-20BB and FAS-20BB Figure 8 - Mounting Bracket Clearances WARNING: Maintain minimum clearances shown in Figure 7. Ifyou can, provide greater clear-ances from floor and joining wall. Figure 7 - Removing Front Pane...

Page 9 - Figure 9 - Folding Anchor; Attaching To Wall Stud Method; For attaching mounting bracket to wall studs; Attaching To Wall Anchor Method; Fold wall anchor as shown in Figure 9.; Mark screw locations on wall.; Do not replace front panel at this

9 105568 OWNER’S MANUAL Figure 9 - Folding Anchor INSTALLATION Continued Attaching Mounting Bracket ToWall Note: Wall anchors, mounting screws, and spacers are in hardware package. The hard-ware package is provided with heater. Attaching To Wall Stud Method For attaching mounting bracket to wall stu...

Page 10 - WARNING: A qualified service; Install an equipment shutoff; ant that is resistant to natural gas.; Check gas line pressure be-; Figure 13 - Gas Connection

10 105568 BLUE FLAME NATURAL GAS HEATER CONNECTING TO GASSUPPLY WARNING: A qualified service person must connect heater togas supply. Follow all local codes. WARNING: Never connect heater to private (non-utility) gaswell. This gas is commonly knownas wellhead gas. Typical Inlet Pipe Diameters FA-20B...

Page 11 - Figure 14 - Equipment Shutoff Valve; WARNING: Never use an open; Correct all leaks at once.; FOR YOUR SAFETY

11 105568 OWNER’S MANUAL O POS PO Figure 14 - Equipment Shutoff Valve Figure 15 - Checking Gas Joints EquipmentShutoffValve Closed WARNING: Test all gas pip- ing and connections for leaksafter installation or servicing.Correct all leaks at once. WARNING: Never use an open flame to check for a leak. ...

Page 12 - Shutting Off Heater; CAUTION: Do not try to adjust

12 105568 BLUE FLAME NATURAL GAS HEATER TO TURN OFF GAS TO APPLIANCE 1. Remove front panel (see Figure 7,page 8). 2. Follow steps 1 through 5 under Light-ing Instructions . 3. With control knob pressed in, strikematch. Hold match to pilot until pi-lot lights. 4. Keep control knob pressed in for 30se...

Page 14 - Figure 21 - Incorrect Pilot Flame Pattern; PILOT FLAME PATTERN; Figure 20 - Correct Pilot Flame Pattern; BURNER FLAME PATTERN; Figure 22 - Correct Burner Flame Pattern; WARNING: If yellow tipping; Figure 24 - Pilot Inlet Air Hole; CABINET; Air Passageways

14 105568 BLUE FLAME NATURAL GAS HEATER Figure 21 - Incorrect Pilot Flame Pattern Thermocouple Pilot Burner INSPECTINGBURNER Check pilot flame pattern and burner flamepattern often. PILOT FLAME PATTERN Figure 20 shows a correct pilot flame pattern.Figure 21 shows an incorrect pilot flamepattern. The...

Page 15 - TROUBLESHOOTING; All troubleshooting items are listed in; POSSIBLE CAUSE

15 105568 OWNER’S MANUAL TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off and un- plug heater and let cool beforeservicing. Only a qualified ser-vice person should service andrepair heater. CAUTION: Never use a wire, needle, or similar object to cle...

Page 16 - OBSERVED PROBLEM; nance, page 14) or replace burner orifice

16 105568 BLUE FLAME NATURAL GAS HEATER OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Yellow flame during burner combustion Slight smoke or odor during initial operation Heater produces a whistling noise whenburner is lit...

Page 17 - IMPORTANT

17 105568 OWNER’S MANUAL WARNING: If you smell gas • Shut off gas supply.• Do not try to light any appliance.• Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. • If you can...

Page 18 - PARTS CENTRALS

18 105568 BLUE FLAME NATURAL GAS HEATER Baltimore Electric 1348 Dixwell AvenueHamden, CT 06514-03221-800-397-7553203-248-7553Parts Department Portable Heater Parts 342 N. County Rd. 400 EastValparaiso, IN 46383-9704All States219-462-74411-800-362-6951sales@portableheaterparts.comtechservice@portable...

Page 19 - ACCESSORIES; FLOOR MOUNTING STAND; instructions included.; SERVICE HINTS; When Gas Pressure Is Too Low; PARTS UNDER WARRANTY

19 105568 OWNER’S MANUAL FAN KITS - UH1000FB, ANDUHS1000FB For all models. Provides better heat distri-bution. Makes heater more efficient. Com-plete installation and operating instructionsincluded. Manually-controlled - UH1000FB. IncludesON/OFF switch. Thermostatically-controlled - UHS1000FB.Includ...

Page 21 - PARTS LIST; KEY

21 105568 OWNER’S MANUAL PARTS LIST THERMOSTAT MODELSFAS-20BBFAS-30BB This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listedunder Replacement Parts on page 19 of this manual. KEY PART NUMBER FOR NO. FAS-20BB FAS-30BB DESCRIPTION QTY. 1 L98409-10...

Page 24 - KEEP THIS WARRANTY; Model; WARRANTY INFORMATION; INTERNATIONAL; NOT A UPC

KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard writtenwarranty. We make no other warranty, expr...