Page 2 - SAFETY INFORMATION; DANGER: Carbon monoxide poisoning may lead; Carbon Monoxide Poisoning:; Early signs of carbon monoxide; WARNINGS; WARNING: Any change to this heater or its con-; TABLE OF CONTENTS; OPTIONAL POSITIONING OF THERMOSTAT
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 2 SAFETY INFORMATION DANGER: Carbon monoxide poisoning may lead to death! Carbon Monoxide Poisoning: Early signs of carbon monoxi...
Page 3 - Continued; PRODUCT IDENTIFICATION
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 3 3 SAFETY INFORMATION Continued 1. This appliance is only for use with the type of gas indicated onthe rating plate. This applia...
Page 4 - Unusually Tight Construction; LOCAL CODES; OPERATION; PRODUCT FEATURES
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 4 AIR FOR COMBUSTION ANDVENTILATION Today’s homes are built more energy efficient than ever. Newmaterials, increased insulation, ...
Page 5 - Confined and Unconfined Space; per kw) of the aggregate input rating of all; WARNING: If the area in which the heater may be; AIR FOR COMBUSTION AND VENTILATION; Ventilation Air
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 5 5 Confined and Unconfined Space National Fuel Gas Code, ANSI Z223.1/NFPA 54 defines a confinedspace as a space whose volume is ...
Page 6 - Ventilation Air From Inside Building; Do not provide openings for inlet or outlet air into; Figure 4 - Ventilation Air from Outdoors
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 6 AIR FOR COMBUSTION ANDVENTILATION Continued VENTILATION AIR Ventilation Air From Inside Building This fresh air would come from...
Page 7 - Vent-free heaters add moisture to the air. Although; CHECK GAS TYPE; INSTALLATION
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 7 7 INSTALLATION WARNING: A qualified service person must in- stall heater. Follow all local codes. WARNING: Before installing in...
Page 8 - Figure 5 - Minimum Clearance for Combustible to Wall; Minimum Noncombustible Material Clearances; Noncombustible material okay.; *Minimum 16 inches from Side Wall
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 8 INSTALLATION Continued NOTICE: Manual control heaters may be used as avented product. If so, you must always run heater withchi...
Page 9 - Figure 7 - Minimum Mantel Clearances Without Using Hood; MANTEL CLEARANCES; Determining Minimum Mantel Clearance; A. If installing appliance on the floor level, you must maintain; Figure 8 - Minimum Mantel Clearances When Using Hood
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 9 9 Figure 7 - Minimum Mantel Clearances Without Using Hood Minimum Non-Combustible Material Minimum Non-Combustible Material Hei...
Page 10 - Installation Items Needed
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 10 INSTALLING HEATER BASE ASSEMBLY WARNING: If installing in a sunken fireplace, special care is needed. You must raise the firep...
Page 11 - Figure 12 - Attaching Flexible Gas Hose to Heater Gas Regulator; Remove heater base from fireplace.; Fitting; Figure 15 - External Regulator With Vent Pointing Down; CONNECTING TO GAS SUPPLY; WARNING: A qualified service person must con-
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 11 11 Figure 12 - Attaching Flexible Gas Hose to Heater Gas Regulator INSTALLATION Continued 7. Mark screw locations through hole...
Page 12 - CAUTION: Avoid damage to regulator. Hold gas; Figure 16 - Gas Connection; Pressure Testing Gas Supply Piping system; Correct all leaks at once.; WARNING: Never use an open flame to check for; CHECKING GAS CONNECTIONS; Install equipment valve in an accessible location.; WARNING: Use pipe joint sealant that is resistant; Cap
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 12 CAUTION: Avoid damage to regulator. Hold gas regulator with wrench when connecting it to gaspiping and/or fittings. Figure 16 ...
Page 13 - Figure 17 - Equipment Shutoff Valve; Open; Figure 18 - Checking Gas Joints; Pressure Testing Heater Gas Connections; Make sure control knob of heater is in the OFF position.; WARNING: Failure to position the parts in accor-; INSTALLING LOGS; Pin; Dual Burner Smoky Mountain Oak Models; CAUTION: After installation and periodically there-
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 13 13 INSTALLATION Continued ON POSITION OFF POSITION Figure 17 - Equipment Shutoff Valve Open Closed EquipmentShutoffValve Figur...
Page 14 - Dual Burner Premium Aged Split Oak Models
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 14 INSTALLATION Continued Figure 20 - Installing Middle Log (#2) Figure 21 - Installing Front Log (#3) Figure 22 - Installing Cro...
Page 16 - Dual Burner Biltmore Split Oak Models
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 16 Dual Burner Biltmore Split Oak Models WARNING: Failure to position the parts in accor- dance with these diagrams or failure to...
Page 17 - Pins; Locate pin and hole
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 17 17 INSTALLATION Continued 7 6 Figure 34 - Installing Crossover Log (#6)(CCL3930PTA Shown) Figure 35 - Installing Crossover Log...
Page 18 - Single Burner Seasonal Oak Models; Figure 36 - Installing Back Log
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 18 INSTALLATION Installing Logs (Cont.) Single Burner Seasonal Oak Models WARNING: Failure to position the parts in accor- dance ...
Page 19 - OPERATING HEATER; Manually-Controlled Models; Figure 39 - Control Knob and Ignitor Button Location; Ignitor Button; FOR YOUR SAFETY; WARNING: If you do not follow these instructions; LIGHTING INSTRUCTIONS; WARNING: Damper handle will be hot if heater; Control Knob; Thermocouple; OPERATING HEATER (Manually Controlled Models)
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 19 19 OPERATING HEATER Manually-Controlled Models Figure 39 - Control Knob and Ignitor Button Location PILOT OFF LO HI Ignitor Bu...
Page 20 - Shutting Off Heater; CAUTION: Do not try to adjust heating levels by; WARNING: Do not operate heater between PILOT; OPERATING HEATER (Manually Controlled Models
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 20 1. Follow steps 1 through 5 under Lighting Instructions, page 19. 2. Depress control knob and light pilot with match. 3. Keep ...
Page 21 - Figure 41 - Control Knob and Ignitor Button Location; Shutting Off Burners Only (pilot stays lit)
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 21 21 Figure 41 - Control Knob and Ignitor Button Location 1. STOP! Read the safety information, page 20, column 2. 2. Make sure ...
Page 22 - INSPECTING BURNERS; Check pilot flame pattern and burner flame patterns often.; Selecting the HI setting with the control knob will cause the; burners to remain fully on, without modulating down in most cases.; OPERATING HEATER (Thermostatically-Controlled Models
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 22 INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. PILOT FLAME PATTERN Figure 43 shows a correct pi...
Page 23 - • If you remove logs for cleaning, refer to Installing Logs, pages; MAIN BURNER; Figure 45 - Injector Holder On Outlet Burner Tube; Burner Tube; WARNING: Turn off heater and let cool before; Blow air through the ports/slots and holes in the burner.; CLEANING AND MAINTENANCE
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 23 23 LOGS • If you remove logs for cleaning, refer to Installing Logs, pages 13 through 18, to properly replace logs. • Replace ...
Page 24 - POSSIBLE CAUSE; All troubleshooting items are listed in; TROUBLESHOOTING
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 24 TROUBLESHOOTING WARNING: Turn off and un- plug heater and let cool beforeservicing. Only a qualified ser-vice person should se...
Page 25 - OBSERVED PROBLEM
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 25 25 OBSERVED PROBLEM Burner does light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Sl...
Page 26 - IMPORTANT; Operating heater where impurities in air exist may create odors.
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 26 TROUBLESHOOTING Continued POSSIBLE CAUSE 1. Metal expanding while heating or con-tracting while cooling 1. Heater burning vapo...
Page 27 - Do not remove the screw. Make sure you tighten the; Figure 48 - Adhesive-backed Mounting Clip; OPTIONAL POSITIONING OF THERMOSTAT SENSING BULB; Capillary
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 27 27 Adhesive-backedMountingClip Figure 50 - Locating Thermo-stat Sensing Bulb on MasonryFireplace ThermostatSensing Bulb ; ; ; ...
Page 28 - SERVICE HINTS; When Gas Pressure Is Too Low; Use only original replacement parts. This will protect your; PARTS UNDER WARRANTY; When calling DESA International, have ready; PARTS NOT UNDER WARRANTY; REPLACEMENT PARTS; EQUIPMENT SHUTOFF VALVE - GA5010
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 28 SERVICE HINTS When Gas Pressure Is Too Low • pilot will not stay lit• burners will have delayed ignition• heater will not prod...
Page 29 - DUAL BURNER BILTMORE SPLIT OAK MODELS; TBD; SPECIFICATIONS
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 29 29 SPECIFICATIONS DUAL BURNER SMOKY MOUNTAIN OAK AND PREMIUM AGEDSPLIT OAK MODELS 18" Model 24" Models 30" Models ...
Page 30 - Variable Manually-Controlled; Smoky Mountain; ILLUSTRATED PARTS BREAKDOWN
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 30 ILLUSTRATED PARTSBREAKDOWN Variable Manually-Controlled CGD3018P, CGD3924P CGD3930P, CCL3018P, AND CCL3924P 24 3 2 1 4 21 11 1...
Page 31 - PARTS LIST; PART NUMBER
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 31 31 This list contains replaceable parts used in your heater. When ordering parts, follow theinstructions listed under Replacem...
Page 33 - KEY
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 33 33 This list contains replaceable parts used in your heater. When ordering parts, follow theinstructions listed under Replacem...
Page 39 - PARTS AVAILABLE — NOT SHOWN
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 39 39 KEY PART NUMBER NO. CRL2718P CRL3124P DESCRIPTION QTY. 1 110243-01 110242-01 Back Log (#1) 1 2 110243-02 110242-02 Front Lo...
Page 40 - PARTS CENTRAL
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 40 These Parts Centrals are privately owned businesses. They have agreed to support our customer’s needs by providing original re...
Page 41 - OWNER'S REGISTRATION FORM
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 41 41 1. Where will the product be used? ❍ Living/Family Room ❍ Office/Warehouse ❍ Utility Shed/Outbuilding ❍ Garage ❍ Bedroom ❍ ...
Page 42 - Postage; TAPE
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 42 2701 Industrial DriveP.O. Box 90004Bowling Green, KY 42102-9004 Postage Required TM TAPE TAPE
Page 43 - NOTES
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 43 43 NOTES _______________________________________________________________________________________________ _____________________...
Page 44 - KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; LIMITED WARRANTY; For information about this warranty write:; NOT A UPC
107124-01E F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 44 KEEP THIS WARRANTY WARRANTY INFORMATION Always specify model and serial numbers when communicating with the factory. We reserv...
Desa CGD3924P
User Manual
Desa WMP10
Manual
Desa R115T
Manual
Desa CCL3018NR
Manual
Desa CSPBPT CSPINT
Manual
Desa 35
Manual
Desa RP30B
Manual
Desa BLP50VA
Manual
Desa CGP10A
Manual
Desa HD-9260
Manual
Desa GP30
Manual
Desa BLP375A
Manual
Desa VRL24NR
Manual
Desa RCP80
Manual
Desa VP1600E
Manual
Desa CSG3924PT
Manual
Desa 10
Manual
Desa REM110BT
Manual