Desa CB36N - Manuals - manualsarea.com

Page 2 - chemicals known to the State; SAFETy; the Commonwealth of

www.desatech.com 117437-01D WARNING: Improper installation, adjustment, a l t e r a t i o n , s e r v i c e o r maintenance can cause injury or property dam - age. Refer to this manual for correct installation and operational proce - dures. For assistance or additional information consult a qualifie...

Page 3 - Continued; Carbon Monoxide Poisoning:; WARNING: Do not allow fans

www.desatech.com 117437-01D 3 Due to high temperatures, the appliance should be located out of traffic and away from furniture and draperies. Do not place clothing or other flammable material on or near the appliance. Never place any objects on or around fireplace. Fireplace reaches high tempera - t...

Page 4 - PRODUCT; Cleaning and Maintenance; LOCAL CODES; The National Fuel

www.desatech.com 117437-01D 4 3.. If.you.smell.gas •.shut.off.gas.supply•.do.not.try.to.light.any.appliance•.do.not.touch.any.electrical.switch;.do.not. use.any.phone.in.your.building •.immediately.call.your.gas.supplier.from. a. neighbor’s. phone.. Follow. the. gas.supplier’s.instructions • if you ...

Page 5 - PRODUCT FEATURES; Figure 2 - Common Fireplace Locations; PRE-INSTALLATION PREPARATION; Accessories

www.desatech.com 117437-01D 5 PRODUCT FEATURES These.are.a.few.facts.that.can.help.you.un-derstand and enjoy your vented decorative fireplace:•. The.(V)CB36N(E).and.(V)CB36P(E).series. of vented decorative fireplaces may be recessed into an exterior chase, an interior flush wall enclosure or a frame...

Page 6 - PACKAGING AND REMOVAL; on the burner in the firebox.; CLEARANCES

www.desatech.com 117437-01D 6 • Your fireplace is designed to be used in zero clearance installations. Wall or framing material.can.be.placed.directly.against.any.exterior surface on the back, sides or top of your fireplace, except when clearances are required from flue vent pipe, see Clear- ances ....

Page 7 - Figure 7 - Unit Dimensions

www.desatech.com 117437-01D 7 Figure 5 - Framing Clearances for Flush Wall Installation 36"(91.4.cm) 36. 1 / 4 " (9.1.cm) 14. 3 / 4 " (37.5.cm) Figure 6 - Framing Clearances for Corner Installation 28 5 / 8 " (72.7 cm) 21" (53.3 cm) To Center of Top Vent 14 3 / 4 " (37.5 cm) ...

Page 8 - Opening; MANTEL CLEARANCES; used and the face are sealed with

www.desatech.com 117437-01D 8 Figure 9 - Clearances for Combustible Mantels Figure 8 - Side Clearances for Combustible Mantels PRE-INSTALLATION PREPARATION Continued 1 1 / 2 " (3.8 cm) 3 1 / 2 " (8.9 cm) Outer Surround Combustible Material May Be Used Perpendicular Side Wall 5 1 / 4 " (1...

Page 9 - INSTALLATION PRECAUTIONS; protection; Failure to do so could result in; VENTING INSTALLATION; National Fuel Gas Code NFPA 54/ANSI

www.desatech.com 117437-01D 9 INSTALLATION PRECAUTIONS NOTICE: Failure to follow these in- structions will void the warranty. •. We a r . g l o v e s . a n d . s a f e t y . g l a s s e s . f o r. protection • Use extreme caution when using ladders or.when.on.roof.tops •. Be. aware. of. electrical. ...

Page 11 - CHECKING FOR PROPER VENTING; Figure 12 - Checking for Spillage; ELECTRICAL SUPPLY CONNECTION; CAUTION: Disconnect the

www.desatech.com 117437-01D 11 VENTING INSTALLATION Continued CHECKING FOR PROPER VENTING After completing and checking electrical, gas and vent connections, follow lighting instructions.and.allow.main.burner.to.run.for.approximately. 5. minutes.. Hold. a. match. or.butane lighter flame, near openin...

Page 12 - National Electric Code,; or the; Canadian; HIGH ALTITUDE INSTALLATION; Receiver; INSTALLING OPTIONAL CONTROLS; Installing Remote Receiver; Figure 14 - Connecting Remote Receiver

www.desatech.com 117437-01D 1 WARNING: This appliance, when installed must be electri - cally grounded in accordance with local code or in the ab - sence of local code, with the current National Electric Code, ANSI/NFPA 70, or the Canadian Electric Code, CSA C22.1 . HIGH ALTITUDE INSTALLATION Your D...

Page 13 - Use clips to mount receiver on remote; Installing 9-Volt Alkaline Battery in Hand-; Figure 16 - Mounting Remote Receiver to; Installing and Activating the Remote

www.desatech.com 117437-01D 13 4.. Connect. one. wire. from. receiver. to. male. connector.on.high.limit.harness.and.one.to “TH” on control valve (see Figure 14, page.1). 5.. Locate.two.plastic.mounting.clips.provided. with.kit. 6. Use clips to mount receiver on remote mounting.bracket.as.shown.in.F...

Page 14 - Thermocouple; Millivolt Wiring Diagram; WIRING DIAGRAMS; Ignition Module; ELECTRONIC IGNITION

www.desatech.com 117437-01D 14 Figure 20 - Millivolt Ignition Wiring Diagram Figure 21 - Electronic Ignition Wiring Diagram THTPTH/TP WHITE RED DO NOT CONNECT TO 120V HIGH LIMIT SWITCH N O T O L P FF O I NC PilotBurner IncomingMain GasSupply Thermocouple Wall Switch/Remote Receiver Replace factory w...

Page 15 - FIREPLACE INSTALLATION; Figure 22 - External Regulator with Vent; CHECK GAS TYPE; Installation Items Needed; Figure 23 - Gas Connection; Natural

www.desatech.com 117437-01D 15 FIREPLACE INSTALLATION Figure 22 - External Regulator with Vent Pointing Down (Propane/LP Only) Propane/LP.Supply.Tank External.Regulator.with.Vent.Pointing.Down CAUTION: Use only new, black iron or steel pipe. Inter - nally-tinned copper tubing may be used in certain ...

Page 16 - IMPORTANT; Attach flexible gas line from gas supply; CHECKING GAS CONNECTIONS; and connections, internal and; Disconnect fireplace and its individual

www.desatech.com 117437-01D 16 FIREPLACE INSTALLATION Continued IMPORTANT :.Install.main.gas.valve.(equip- ment.shutoff.valve).in.an.accessible.location..The.main.gas.valve.is.for.turning.on.or.shutting.off.gas.to.appliance.Check. your. building. codes. for. any. special.requirements. for. locating....

Page 17 - Figure 25 - Equipment Shutoff Valve; tion see; Replacement Parts

www.desatech.com 117437-01D 17 Test Pressures Equal To or Less Than 1/2 PSIG (3.5 kPa) 1.. Close.equipment.shutoff.valve.(see.Fig- ure.5). 2. Pressurize supply piping system by either opening. propane/LP. supply. tank. valve.for propane/LP gas fireplace or opening main. gas. valve. located. on. or. ...

Page 18 - Figure 28 - Removing Louver Panel; Removing/Replacing Glass Door; WARNING: Handle glass; at Lower Rail; Door; Removing Louver Panels

www.desatech.com 117437-01D 18 Figure 28 - Removing Louver Panel Louver.Panel Spring.Latch Removing/Replacing Glass Door WARNING: Handle glass door panel with care. Do not strike, slam or otherwise abuse glass. Do not operate fire - place with glass door removed, cracked or broken. If replacement of...

Page 19 - Figure 32 - Applying Ember Material; WARNING: The glass door

www.desatech.com 117437-01D 19 INSTALLING LOGS AND GLOWING EMBERS A.4.piece.ceramic.log.set.comes.packed.in-side the unit firebox. Removal of glass door is necessary.to.unpack.and.assemble.logs.and.add. hearth. treatments.. Follow. steps. under. Removing/Replacing Glass Door , page 18 to access.logs...

Page 20 - OPERATING FIREPLACE; MANUAL IGNITION SySTEM; low these instructions exactly,; WHAT TO DO IF YOU SMELL GAS; gas. Then smell for gas, including near

www.desatech.com 117437-01D 0 O FF P IL O T O N OPERATING FIREPLACE MANUAL IGNITION SySTEM FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not fol- low these instructions exactly, a fire or explosion may result causing property damage, per - sonal injury or loss of life. A. This appliance is...

Page 21 - Turn off all electrical power to the fire-

www.desatech.com 117437-01D 1 OPERATING FIREPLACE Continued MANUAL LIGHTING PROCEDURE 1.. Remove. glass. door. (see. Removing/Re- placing Glass Door , page 18). .. Follow. steps. 1. through. 8. under. Lighting Instructions , page 20). 3.. Press.gas.control.knob.and.light.pilot.with. match. 4.. Keep....

Page 22 - Figure 36 - Setting the Selector Switch,; REMOTE OPERATION; NOTICE: You must light the pilot; Button; ON/OFF SERIES MODEL HRC100; WARNING: Do not connect; Lighting

www.desatech.com 117437-01D OPERATING FIREPLACE Continued OF F PIL O T LO IH ON OFF REMOTE ON OFF O N Blower.Control.Knob.(Optional.Accessory) Variable.Control.Knob Selector.Switch.in.Remote.Position Gas.Control.Knob.in.ON.Position Figure 36 - Setting the Selector Switch, Gas Control Knob and Variab...

Page 23 - INSPECTING BURNERS; PILOT ASSEMBLY; Figure 40 - Typical Flame Pattern; AIR ADjUSTMENT SETTING

www.desatech.com 117437-01D 3 INSPECTING BURNERS Thermocouple Thermopile 1/4" Pilot.Burner Piezo Ignitor Figure 38 - Pilot Assembly (Millivolt Ignition System) 3/8".to.1/" Sensor.Rod Pilot.Burner Piezo Ignitor Figure 39 - Pilot Assembly Electronic Ignition System) Check pilot flame patte...

Page 24 - CLEANING AND MAINTENANCE; GLASS DOOR; WA R N I N G : D o n o t u s e; ing Glass Door; Removing/Replacing Glass; CAUTION: Do not vacuum if; ment Parts; PILOT AND BURNERS; • Use a vacuum cleaner or small, soft bristled

www.desatech.com 117437-01D 4 CLEANING AND MAINTENANCE WARNING: Turn off fireplace and let cool before cleaning. CAUTION: You must keep control areas, burners, and cir - culating air passages of fireplace clean. Inspect these areas of fireplace before each use. Have fireplace inspected yearly by a q...

Page 25 - LOGS; • If you remove logs for cleaning, refer to; VENTING SYSTEM; Remove the vent cap and shine a flashlight; SPECIFICATIONS; ALL MODELS; SERVICE HINTS; When Gas Pressure Is Too Low; TECHNICAL SERVICES

www.desatech.com 117437-01D 5 LOGS • If you remove logs for cleaning, refer to Installing Logs and Glowing Embers , page 19, to properly replace logs. • Use a vacuum cleaner to remove any carbon.buildup.on.logs. •. Replace.log(s).if.broken..See. Replacement Parts, .page.31. •. Replace. ember. materi...

Page 26 - TROUBLESHOOTING; WARNING: Turn off heater and let cool before servicing. Only a; Note: All troubleshooting items are listed in order of operation.; POSSIBLE CAUSE; Manual Ignition System Only; REMEDY; ing and Maintenance

www.desatech.com 117437-01D 6 TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. CAUTION: Never use a wire, needle or similar object to clean ODS/pilot. This can damage ODS/pilot unit. Note: All troubleshooting it...

Page 30 - See Warning; blocked; OBSERVED PROBLEM; nections

www.desatech.com 117437-01D 30 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Fol - low the gas ...

Page 31 - NOTE: All accessories may not; CIK; Models; CONTROL KIT

www.desatech.com 117437-01D 31 Usually, we will ask you to return the part to the.factory. PARTS NOT UNDER WARRANTY Contact authorized dealers of this product. If they can’t supply original replacement part(s), call DESA Heating, LLC at 1-866-672-6040 for referral information. A list of authorized d...

Page 32 - PARTS; FIREPLACE ASSEMBLY FOR MODELS

www.desatech.com 117437-01D 3 PARTS FIREPLACE ASSEMBLY FOR MODELS (V)CB36N, (V)CB36P, (V)CB36NE AND (V)CB36PE 12 14 1-2 1-1 1-4 1-3 20 8 11 10 5 6 7 18 9 13 26 27 17 21 22 25 26 3 24 4 16 23 2 15 26 19

Page 33 - Replacement Parts; DESCRIPTION; Bushing Universal Strain Relief; PARTS AVAILABLE - NOT SHOWN

www.desatech.com 117437-01D 33 PARTS This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions.listed.under. Replacement Parts .on.page.31.of.this.manual. KEY NO. PART NO. DESCRIPTION QTY. 1 116108-01 Log.Set • • • • 1 1-1 116109-01 Burner.Base.Log • •...

Page 34 - BURNER ASSEMBLY FOR MODELS; Electric Ignition Models Only

www.desatech.com 117437-01D 34 PARTS BURNER ASSEMBLY FOR MODELS (V)CB36N (V)CB36P, (V)CB36NE AND (V)CB36PE H IG H V O LT A G E 3 4 5 6 7 8 9 1 21 20 24 28 25 26 29 27 30 31 22 15 23 2 Piezo IgnitionModels Only Electric Ignition Models Only 19 18 12 13 14 15 16 17 10 11

Page 35 - Transformer, 24V Class 2

www.desatech.com 117437-01D 35 PARTS This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions.listed.under. Replacement Parts .on.page.31.of.this.manual. KEY NO. DESCRIPTION QTY. 1 116317-01 Remote.Ignitor.Bracket • • 1 10445-01 Ignitor Piezo • • 1 3 ...

Page 36 - NOT A UPC; WARRANTy; KEEP THIS WARRANTy; keep receipt for warranty verification.

117437.01 DESA Heating, LLC701.Industrial.DriveP.O..Box.90004Bowling Green, kY 42102-9004www.desatech.com NOT A UPC WARRANTy KEEP THIS WARRANTy Always.specify.model.and.serial.numbers.when.communicating.with.the.factory.The only warranty applicable is our standard written warranty. We make no other ...