Desa and FVF30N - Manuals - manualsarea.com

Page 2 - Carbon Monoxide Poisoning:; WARNINGS; DANGER: Carbon monoxide

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 2 105191 1. This appliance is only for use with thetype of gas indicated on the rating plate.This appliance is not convertible for usewith other gases. SAFETYINFORMATION Carbon Monoxide Poisoning: Early signs of carbon monoxide poi...

Page 3 - OWNER’S MANUAL; OPERATION; UNPACKING; CAUTION: Do not remove the; Do not pick up; LOCAL CODES; American National Standards Institute, Inc.; Figure 1 - Heat MajicTM Log Set

OWNER’S MANUAL 3 105191 PRODUCTIDENTIFICATION PRODUCTFEATURES OPERATION This heater is clean burning. It requires nooutside venting. There is no heat loss out avent or up a chimney. Heat is generated byrealistic, dancing yellow flames. This heateris designed for vent-free operation with fluedamper c...

Page 4 - Unusually Tight Construction; per

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 4 105191 PROVIDING ADEQUATEVENTILATION The following are excerpts from NationalFuel Gas Code. NFPA 54/ANS Z223.1, Sec-tion 5.3, Air for Combustion and Ventilation. All spaces in homes fall into one of the threefollowing ventilation...

Page 5 - DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION; Determining if You Have a Confined or Unconfined Space

OWNER’S MANUAL 5 105191 DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION Determining if You Have a Confined or Unconfined Space Use this work sheet to determine if you have a confined or unconfined space. Space: Includes the room in which you will install heater plus any adjoining rooms with doorless ...

Page 6 - Figure 3 - Ventilation Air from Outdoors; VENTILATION AIR; Ventilation Air From Outdoors; Do not provide openings for

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 6 105191 AIR FORCOMBUSTION ANDVENTILATION Continued Figure 3 - Ventilation Air from Outdoors Figure 2 - Ventilation Air from Inside Building OutletAir VentilatedAttic OutletAir InletAir Inlet Air Ventilated Crawl Space To Crawl Spa...

Page 7 - INSTALLATION; CHECK GAS TYPE; MINIMUM FIREPLACE; B. Clearances from the top of the fireplace

OWNER’S MANUAL 7 105191 WARNING: Never install the heater• in a bedroom or bathroom un- less installed as a vented ap-pliance (see page 10) • in a recreational vehicle• w h e r e c u r t a i n s , f u r n i t u r e , clothing, or other flammableobjects are less than 42 inchesfrom the front, top, or ...

Page 8 - If using a mantel, proceed to If Using; Noncombustible material OK.

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 8 105191 Minimum NoncombustibleMaterial Clearances If Not Using Mantel Note: If using a mantel, proceed to If Using a Mantel. If not using a mantel, follow theinformation below. You must have noncombustible material(s)above the fir...

Page 9 - Figure 6 - Minimum Mantel Clearances Without Using Hood; MANTEL CLEARANCES; flue damper open; FLOOR CLEARANCES; A. If installing appliance on the floor level,

OWNER’S MANUAL 9 105191 INSTALLATION Continued Figure 6 - Minimum Mantel Clearances Without Using Hood Figure 7 - Minimum Mantel Clearances When Using Hood Minimum Non-Combustible Material 8"Min. 12" 15" 18" All minimum distances arein inches 20" 2 1 /2 " 6" 8" 10"...

Page 10 - Make sure the heater burner; You prefer vented operation; Figure 10 - Attaching Damper Clamp; Masonry Fireplace

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 10 105191 Area of Various Standard Round Flues Diameter (ins.) Area (sq. ins.) 5" 20 sq. inches 6" 29 sq. inches 7" 39 sq. inches 8" 51 sq. inches INSTALLING HEATER BASEASSEMBLY WARNING: You must secure this heater ...

Page 11 - Figure 11 - Attaching Flexible Gas Hose to Heater Gas Regulator; Installation Items Needed

OWNER’S MANUAL 11 105191 INSTALLATION Continued Figure 11 - Attaching Flexible Gas Hose to Heater Gas Regulator Figure 12 - Attaching Base Assembly to Fireplace Floor Masonry Screw Bracket withScrew Holes Continued Installation Items Needed • hardware package (provided with heater) • approved flexib...

Page 12 - Figure 13 - Gas Connection; WARNING: Never connect

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 12 105191 Tee Joint PipeNipple Cap 3" Minimum SedimentTrap GasRegulator From GasMeter (5"W.C.** to10.5" W.C.Pressure) A.G.A. Design-CertifiedManual Shutoff Valve With1/8" NPT Tap Approved Flexible GasHose (if allowe...

Page 13 - Figure 14 - Manual Shutoff Valve; Figure 15 - Checking Gas Joints; WARNING: Never use an open; Correct all leaks at once.; Correct all leaks at once.

OWNER’S MANUAL 13 105191 Test Pressures Equal To or Less Than1/2 PSIG 1. Close manual shutoff valve (see Fig-ure 14). 2. Pressurize supply piping system by ei-ther using compressed air or openingmain gas valve located on or near gasmeter. 3. Check all joints from gas meter tomanual shutoff valve (se...

Page 14 - Make sure log; WARNING: Failure to position; INSTALLING LOGS; CAUTION: After installation

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 14 105191 It is very important to install the logs exactlyas instructed. Do not modify logs. Only uselogs supplied with heater. 1. Place one-piece log set on grate to fitas illustrated in Figure 16. Make surebottom of front log is ...

Page 15 - LIGHTING; Figure 18 - Control Knob and Ignitor Button Location; • If fireplace has glass doors,

OWNER’S MANUAL 15 105191 LIGHTING INSTRUCTIONS OPERATINGHEATER FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not fol- low these instructions exactly, afire or explosion may result caus-ing property damage, personalinjury or loss of life. A. This appliance has a pilot which must be lighted ...

Page 16 - Shutting Off Heater; Note; Figure 20 - Correct Pilot Flame Pattern; WARNING: Do not operate

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 16 105191 TO TURN OFF GAS TO APPLIANCE Shutting Off Heater 1. Press in and turn control knob clock-wise Clockwise to the HIGH position. 2. Turn the control knob clockwise Clockwise to the PILOT position. 3. Press in control knob an...

Page 17 - TROUBLESHOOTING; POSSIBLE CAUSE; All troubleshooting items are listed in

OWNER’S MANUAL 17 105191 TROUBLESHOOTING WARNING: Turn off and un- plug heater and let cool beforeservicing. Only a qualified ser-vice person should service andrepair heater. CAUTION: Never use a wire, needle, or similar object to cleanODS/pilot. This can damage ODS/pilot unit. POSSIBLE CAUSE 1. Ign...

Page 18 - OBSERVED PROBLEM; nance, page 20) or replace burner orifice

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 18 105191 OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition burner Burner backfiring during combustion Slight smoke or odor during initial operation Heater produces a whistling noise whenburner is lit M...

Page 19 - IMPORTANT

OWNER’S MANUAL 19 105191 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply.• Do not try to light any appliance.• Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s ...

Page 20 - WARNING: Turn off heater; LOGS; SERVICE HINTS; When Gas Pressure Is Too Low; Figure 23 - Pilot Inlet Air Hole

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 20 105191 CLEANING ANDMAINTENANCE WARNING: Turn off heater and let cool before cleaning. CAUTION: You must keep control areas, burner, and circu-lating air passageways of heaterclean. Inspect these areas ofheater before each use. H...

Page 21 - PARTS UNDER WARRANTY; SPECIFICATIONS; Variable Manually; ACCESSORIES; FIREPLACE HOODS

OWNER’S MANUAL 21 105191 Note: Use only original replacement parts. This will protect your warranty coverage forparts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealers of this product.If they can’t supply original replacementp a r t ( s ) , c a l l F i r e p l a c e M a n u f ...

Page 22 - ODS Pilot

UNVENTED NATURAL GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED 22 105191 ILLUSTRATEDPARTSBREAKDOWN HEAT MAJIC™FVF18NFVF24NFVF30N ODS Pilot 4 12 21 10 11 21 7 21 5 6 8 9 15 14 16 19 2 18 13 19 17 20 18 3 1

Page 23 - PARTS LIST; KEY

OWNER’S MANUAL 23 105191 PARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructionslisted under Replacement Parts on page 21 of this manual. KEY PART NUMBER FOR NO. FVF18N FVF24N FVF30N DESCRIPTION QTY. 1 105186-01 105186-02 105186-03 One Piece ...

Page 24 - KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; NOT A UPC; LIMITED WARRANTY

KEEP THIS WARRANTY WARRANTY INFORMATION Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard writtenwarranty. We make no...