Page 2 - LIMITED WARRANTY
2 LIMITED WARRANTY Bercomac Limitée 92, Fortin North, Adstock, Quebec, Canada, G0N 1S0 Conditions and Products Covered: BERCOMAC guarantees any part of the product or accessory manufactured by BERCOMAC and found in the reasonable judgment of BERCOMAC to be defective in material and or workmanship wi...
Page 3 - TABLE OF CONTENTS
1 TABLE OF CONTENTS INTRODUCTION ................................................................................................................................................... 2 SAFETY PRECAUTIONS .....................................................................................................
Page 4 - INTRODUCTION; This manual should be kept for future reference.; NUMBER
2 INTRODUCTION TO THE PURCHASER This new accessory was carefully designed to give years of dependable service. This manual has been provided toassist in the safe operation and servicing of your attachment. NOTE: All photographs and illustrations in the manual may not necessarily depict the actual mo...
Page 5 - SAFETY PRECAUTIONS
3 SAFETY PRECAUTIONS Careful operation is your best insurance against an accident. Read this section carefully before operating the vehicle and accessory. This accessory is capable of amputating hands and feet and throwing objects. Failure to observe the following safety instructions could result in...
Page 7 - SAFETY DECALS; REPLACE IF DECALS ARE DAMAGED
5 SAFETY DECALS REPLACE IF DECALS ARE DAMAGED SEE PARTS BREAKDOWN FOR DECAL LOCATION DECAL #105133 Failure to observe these instructions could lead to severe injury or death. To avoid injury to hands or fingers: -Always keep hands clear of rope hook loop, ,hook and fairlead opening during installati...
Page 8 - ASSEMBLY; INSTALLING THE REFLECTORS
6 ASSEMBLY Install the left & right supports (item 2) on each side of the vehicle. Item # Description Action 1 Tractor shoulder screw Remove from both sides of tractor. 2 Left & right support (qty 2) Install on each side as shown. 3 Lock washer (qty 2) Insert on the bolt (item 5) as shown. 4...
Page 12 - IMPORTANT
10 ASSEMBLY Install the winch control switch STEP 2: INSTALLATION OF THE WINCH CONTROL SWITCH Install the relay (item 1). # Item Description Action 2 Metal screw #12 x 3/4’’ (qty 4) Secure relay in place. *3 Nylon tie wrap 8’’ (qty 4) See * *If necessary use the nylon tie wraps to secure the relay i...
Page 14 - CAUTION
12 ASSEMBLY CAUTION FOR YOUR SECURITY: Read and follow the safety precautions for the battery in the vehicle’s manual. CONNECT THE WIRES ON THE BATTERY: Connect the wires from the relay to the vehicle’s battery. The red wire (+) on the positive post of the battery (item 1). The black wire (-) on the...
Page 15 - STEP; WARNING
13 ASSEMBLY STEP 3: DRIVE MECHANISM INSTALLATION: WARNING TO PREVENT INJURIES: It is the person who installs the drive mechanism responsibility to make sure that when the clutch is disengaged that all moving parts stop. For more information, do not hesitate to contact the technical support. WARNING ...
Page 18 - OPERATION & MAINTENANCE; DISMOUNTING & STORAGE
16 OPERATION & MAINTENANCE CAUTION Read the vehicle Owner’s Manual carefully. Be thoroughly familiar with the controls & proper use of the attachment. Know how to stop the attachment quickly . IMPORTANT: THE WINCH KIT IS TO BE USED ONLY TO LIFT BERCO ACCESSORIES, ANY OTHER USE MAY CAUSE DAMA...
Page 19 - TROUBLESHOOTING; PROBLEM
17 TROUBLESHOOTING PROBLEM POSSIBLE CAUSES CORRECTIVE ACTION Winch runs backwards. Winch wires reversed. Recheck wiring. Switch wires reversed. Recheck wiring. Switch installed incorrectly. Check switch installation. Battery wires reversed. Recheck wiring. Winch cable is not winded up from the botto...
Page 20 - PARTS BREAKDOWN
18 PARTS BREAKDOWN COMPACT DRIVE MECHANISM 700528-1
Page 21 - PARTS LIST
19 O/L = Obtain Locally PARTS LIST COMPACT DRIVE MECHANISM 700528-1 Ref. Réf. English description Description française Qty. Qté. Part # Pièce # 1 Drive frame Châssis d'entraînement 1 105505 2 Double pulley inc. 102736 & 102782 Poulie double inc. 102736 & 102782 1 102692 3 Adjustment rod Tig...
Page 28 - TORQUE SPECIFICATION TABLE
26 TORQUE SPECIFICATION TABLE GENERAL TORQUE SPECIFICATION TABLE USE THE FOLLOWING TORQUES WHEN SPECIAL TORQUES ARE NOT GIVEN NOTE: These values apply to fasteners as received from supplier, dry or when lubricated with normal oil. They do not apply if special graphited or moly disulphide greases or ...
Page 30 - NOTES
28 NOTES _____________________________________________________________________________________________ _____________________________________________________________________________________________ _____________________________________________________________________________________________ _________...
Page 32 - Ber coma c Limit ée
30 WHEN PERFORMANCE & DEPENDABILIT Y ARE NON NEGOTIABLE ! Ber coma c Limit ée 9 2 , For t in Nor t h , Ad s t ock, Qu ebec, Ca n a d a , G0 N 1 S0 WWW.BERCOMAC.COM PRI NTED I N CANADA ( ORI GI NAL N OTI CE) BY