Cub Cadet GT-3204- Manuals

Cub Cadet GT-3204– User Manual in PDF format online.

Manuals:

User Manual

User Manual Cub Cadet GT-3204

Summary

Page 2 - Connect the Battery

2 TABLE OF CONTENTS PAGE TRACTOR PREPARTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2IMPORTANT SAFE OPERATION PRACTICES . . . . . . . . . . . . . . . . . . . . . 3CALLING SERVICE INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7FINDING YOUR...

Page 3 - GENERAL OPERATION; SECTION 2: IMPORTANT SAFE OPERATION PRACTICES; : THIS SYMBOL POINTS OUT IMPORTANT SAFETY; WARNING

3 1. GENERAL OPERATION • Read, understand, and follow all instructions in the operator’s manualand on the machine before starting.Keep this manual in a safe place forfuture and regular reference and forordering replacement parts. • Only allow responsible individuals familiar with the instructions to...

Page 6 - Restrict the use of

6 • To reduce fire hazard, keep the machine free of grass, leaves orother debris build-up. Clean up oil orfuel spillage. Allow machine to coolat least 5 minutes before storing. • Before cleaning, repairing or inspecting, make certain the bladeand all moving parts have stopped.Disconnect the spark pl...

Page 7 - Figure 1; Model Number

7 SECTION 3: CALLING SERVICE INFORMATION The engine manufacturer is responsible for all engine-related issues withregards to performance, power-rating, and specifications. If you have difficulties with the unit, have any question regarding the operationor maintenance of this equipment, or desire add...

Page 8 - SECTION 5: SAFETY LABELS FOUND ON YOUR UNIT; Figure 2; IGNITION; Running Board - Center

8 SECTION 5: SAFETY LABELS FOUND ON YOUR UNIT Figure 2 AVOID SERIOUS INJURY OR DEATH READ OPERATOR'S MANUAL WARNING GO UP AND DOWNS L O P E S , N O T A C R O S S . A V O I D S U D D E N T U R N S .D O N O T O P E R AT E U N I T W H E R E I T C O U L D S L I P O R T I P. I F M A C H I N E S T O P S G...

Page 9 - Figure 3

9 ABCDEFGHI JKLMNOPQ Parking Brake LeverPTO SwitchBrake PedalReverse PedalForward PedalCenter Height Position IndicatorIgnition / Light SwitchTransmission Release RodTransmission Oil Fill / Dipstick Fuel Fill CapCup HolderHydraulic Lift LeverCruise Control LeverChoke LeverThrottle LeverSeat Adjustme...

Page 10 - Figure 4; Check behind the tractor to; Figure 7

10 NOTE: References to LEFT and RIGHT indicate that side of the tractorwhen facing forward while seated inthe drivers seat. Reference to FRONTindicates the grille end of the tractor;to REAR, the drawbar end. Steering Wheel The steering wheel, centered on thedash panel, is used to turn the tractorlef...

Page 11 - When using power

11 Ignition / Light Switch To prevent accidental starting and/orbattery discharge, remove the keyfrom the ignition switch when thetractor is not in use. The combinationlights and ignition switch has fourpositions. See Figure 8 for adescription of each position. Figure 8 Transmission Release Rod The ...

Page 12 - RAISE; Quick Latch Rod

12 Seat Adjustment Lever The seat adjustment lever is locatedbelow the seat. This lever is used toadjust the seat forward or backward. Deck Height Adjustment Knob The deck height adjustment knob islocated on the left running board (SeeFigure 10). Use this knob to set (andhold) your desired deckstop ...

Page 14 - Remove the key from the

14 SECTION 7: OPERATION Safety Interlock Switches This tractor is equipped with a safetyinterlock system for the protection ofthe operator. If the interlock systemshould ever malfunction, do notoperate the tractor. Contact yourauthorized Cub Cadet Dealer. Thesafety interlock system prevents theengin...

Page 15 - Driving The Tractor; Avoid sudden; Do not use the forward or; Setting The Cruise Control; The cruise control feature; Driving On Slopes; Do not mow

15 • Place the PTO switch in the “OFF” position. Place the throttle controllever between the “MID” and “FAST”positions. Then turn the ignition keyto the “OFF” position and removethe key from the ignition switch. Driving The Tractor WARNING: Avoid sudden starts, excessive speed andsudden stops. WARNI...

Page 17 - SECTION 8: ADJUSTMENTS; Seat Adjustment; Do not adjust

17 Mowing should be done with theengine at full throttle. Do not mow athigh ground speed.During certain times of the year andunder some conditions, the mowermay leave streaks of uncut grass.Streaking may occur when attemptingto mow heavy weeds and tall grass.Under these conditions it may benecessary...

Page 18 - Front

18 Front Wheel Alignment Note: The left-hand ball joint is left- hand threaded. The front wheels should toe-in approx-imately 1/8 inch. Measure distances Aand B. A should be approximately 1/8inch less than B. See Figure 16. Figure 16 To adjust toe-in, loosen left and rightball joint jam nuts. See Fi...

Page 19 - Turning Radius Adjustment; SECTION 9: MAINTENANCE; Maintenance Chart; Eac

19 From just above the right axle carrier,inside the right frame rail, slowly turnthe hex nylon lock nut at the end ofthe brake rod as follows to adjust thebrake (Refer to Figure 18):• Turn the nylon lock nut clockwise to increase the braking force. • Turn the nylon lock nut counter- clockwise to de...

Page 20 - LUBRICATION ILLUSTRATION; System Fluid Plus - ONLY

20 LUBRICATION ILLUSTRATION Cub Cadet 251H EP Greaseor equivalent No. 2 lithium grease Engine Oil: See Figure 27 on page 30Transmission Oil - Cub Cadet Drive Oil Can (High quality lubricating oil) System Fluid Plus - ONLY Engine Front Piv o t Axle L /R Steering Knuckle L /R Front Whe e ls Fo ot Co n...

Page 21 - Accessing Engine Compartment; Turn; General Battery Information

21 Accessing Engine Compartment The engine compartment can beaccessed by raising the hood asfollows: • Lift the hood straight upward at the recessed notches of the side panelsto disengage the internal hood latch. • Carefully pivot the hood forward to open. To close the hood: • Carefully pivot the ho...

Page 24 - Adding Transmission Oil; dipstick must be installed; Changing Transmission Oil

24 then fully reinserted before beingwithdrawn again for a true reading. Figure 21 Adding Transmission Oil WARNING: The fluid for yourtransmission has been spe-cially formulated to ensurethe safe and proper opera-tion of your tractor. Add CubCadet Drive System FluidPlus ONLY. Do not use anyother flu...

Page 25 - Electrical Box

25 Figure 22 • Clean around the base of the trans- mission oil filter and remove thefilter by turning it counterclockwise. • Apply a light coating of clean trans- mission oil to the gasket of the newfilter. Install the filter by turning itclockwise, by hand, until the gasketcontacts the filter base ...

Page 26 - Fuse

26 Fuse Fuses are installed to protect the trac-tor’s electrical system from damagecaused by excessive amperage.Always use the same capacity fuse forreplacement. Refer to the Specifica-tions Chart. If the electrical systemdoes not function, check the fuses.To replace a fuse, note the position ofthe ...

Page 27 - SECTION 10: ENGINE INFORMATION

27 SECTION 10: ENGINE INFORMATION KOHLER CO. FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS LIMITED WARRANTY SMALL OFF-ROAD EQUIPMENT ENGINES The U.S. Environmental Protection Agency (EPA), the California Air Resources Board (CARB), andKohler Co. are pleased to explain the Federal and California Em...

Page 28 - LIMITATIONS; MAINTENANCE AND REPAIRS REQUIREMENTS

28 LIMITATIONS This Emission Control System Warranty shall not cover any of the following: (a) repair or replacement required because of misuse or neglect, improper maintenance, repairs improperly performed or replacement not conforming to Kohler Co. specifications that adverselyaffect performance a...

Page 29 - Full

29 Cleaning The Engine This tractor has an air-cooled engine.Air must be able to circulate freelyaround the engine through theflywheel screen, through the coolingshrouds and over the fins of thecylinder head and cylinder block. Keepthese areas free of accumulated dirtand debris or the engine will ov...

Page 30 - Changing Engine Oil

30 Refer to Figure 27 for informationregarding the proper type of oil to addto the crankcase. • Place the tractor on a level surface and engage the parking brake. Stopthe tractor engine and remove theignition key. • Clean the area around the oil filler cap to prevent debris from enteringthe crankcas...

Page 33 - SECTION 11: TROUBLE SHOOTING; Possible Cause; Hard To Start

33 SECTION 11: TROUBLE SHOOTING Possible Cause Possible Remedy Hard To Start No fuel in fuel tank or carburetor Fill the tank with fuel. Check the fuel line, carburetor and fuel filter. Fuel line or carburetor clogged Clean the fuel line and carburetor with a commercial carburetor cleaner. Fuel filt...

Page 35 - SECTION 12: OPTIONAL EQUIPMENT; Description

35 SECTION 12: OPTIONAL EQUIPMENT When you purchased your tractor, you probably had it completely equipped foryour particular needs at that time. However, later you may wish to obtainoptional equipment or accessories. These items and other allied equipment canbe purchased from, and installed by, you...

Page 36 - SECTION 13: SPECIFICATIONS; Tires

36 SECTION 13: SPECIFICATIONS Engine Manufacturer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . KohlerHorsepower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23Cylinders . . . . . . . . . . . . . . . . . . . . . . . . ....

Page 37 - SECTION 14: SLOPE GAUGE; Do not mow on inclines with a slope in excess of 15

37 SECTION 14: SLOPE GAUGE WARNING: Do not mow on inclines with a slope in excess of 15 degrees (a rise of approximately 2-1/2 feet every 10 feet). A ridingmower could overturn and cause serious injury. If operating a walk-behind mower on such a slope, it is extremely difficult to maintainyour footi...

Page 39 - Batteries and belts are subject to separate terms as follows:

39 CUB CADET LLC MANUFACTURER’S ONE YEAR LIMITED WARRANTY (COMMERCIAL USE) The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)with respect to new merchandise purchased and used in the United States, itspossessions and territories. CUB CADET warrants this product against defe...

Page 41 - Year/500 Hour Limited Warranty

41 CUB CADET LLC MANUFACTURER’S LIMITED WARRANTY (RESIDENTIAL USE) The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)with respect to new merchandise purchased and used in the United States, itspossessions and territories. CUB CADET warrants this product against defects in m...

Page 44 - SECTION 15: QUICK REFERENCE PARTS; Cub Cadet Drive; CARTRIDGE

SECTION 15: QUICK REFERENCE PARTS Description Part Number Engine Oil 737-3030A (10W30) 737-3049 (5W30) Air Filter KH-47-083-03 KH-24-083-02 Engine Oil Filter KH-12-050-08 Spark Plug 759-3336 Transmission Oil Cub Cadet Drive System Fluid Plus 737-3120 - Quart 737-3121 - Gallon Transmission Oil Filter...