Cub Cadet 3186 - Manuals - manualsarea.com

Page 2 - SECTION 1: TABLE OF CONTENTS; PAGE; WARNING; The Engine Exhaust from this product; Your lawn mower was built to be operated according to the; GENERAL OPERATION; • Only allow responsible individuals

2 SECTION 1: TABLE OF CONTENTS PAGE IMPORTANT SAFE OPERATION PRACTICES . . . . . . . . . . . . . . . . . . . . . 2CALLING SERVICE INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6FINDING YOUR MODEL & SERIAL NUMBER . . . . . . . . . . . . . . . . . . . . . . 6SAFETY LABELS...

Page 6 - Restrict the use of; SECTION 3: CALLING SERVICE INFORMATION; rail behind the right front tire. See Figure 1.; Model Number

6 • Use proper containers when draining fluids. Do not use food orbeverage containers that maymislead someone into drinking fromthem. Properly dispose of thecontainers immediately following thedraining of fluids. • DO NOT pour oil or other fluids into the ground, down a drain or into astream, pond, ...

Page 7 - SECTION 5: SAFETY LABELS FOUND ON YOUR UNIT; IGNITION; POSITION

7 SECTION 5: SAFETY LABELS FOUND ON YOUR UNIT Figure 2 IGNITION STOP STARTING INSTRUCTIONS POSITION INDICATOR AVOID SERIOUS INJURY OR DEATH READ OPERATOR'S MANUAL WARNING STOPPING INSTRUCTIONS GO UP AND DOWNS L O P E S , N O T A C R O S S . A V O I D S U D D E N T U R N S .D O N O T O P E R AT E U N...

Page 8 - * Steering Wheel and Seat Removed For Clarity

8 SECTION 6: CONTROLS Figure 3 ABCDEFGHI JKLMNOPQ Parking Brake LeverPTO SwitchBrake PedalReverse PedalForward PedalCenter Lift Height IndicatorIgnition / Light SwitchTransmission Release RodTransmission Oil Fill / Dipstick Fuel Fill CapCup HolderHydraulic Lift LeverSteering Wheel Tilt LockCruise Co...

Page 9 - Check behind the tractor to

9 NOTE: References to LEFT and RIGHT indicate that side of the tractorwhen facing forward while seated inthe drivers seat. Reference to FRONTindicates the grille end of the tractor;to REAR, the drawbar end. Steering Wheel The steering wheel is centered on thedash panel. It is used to change thedirec...

Page 10 - When using power

10 Ignition / Light Switch To prevent accidental starting and/orbattery discharge, remove the keyfrom the ignition switch when thetractor is not in use. The combinationlights and ignition switch has fourpositions. See Figure 8 for adescription of each position. Figure 8 Transmission Release Rod The ...

Page 12 - Remove the key from the

12 SECTION 7: OPERATION Safety Interlock Switches This tractor is equipped with a safetyinterlock system for the protection ofthe operator. If the interlock systemshould ever malfunction, do notoperate the tractor. Contact yourauthorized Cub Cadet Dealer. Thesafety interlock system prevents theengin...

Page 13 - Driving The Tractor; Avoid sudden; Do not use the forward or; Setting The Cruise Control; The cruise control feature; Driving On Slopes; Do not mow

13 • Place the PTO switch in the “OFF” position. Place the throttle controllever between the “MID” and “FAST”positions. Then turn the ignition keyto the “OFF” position. • Remove the key from the ignition switch. Driving The Tractor WARNING: Avoid sudden starts, excessive speed andsudden stops. WARNI...

Page 14 - The PTO clutch

14 Before operating the tractor on anyslope, walk the slope to look forpossible hazards such as rocks.mounds, ruts, stumps or other surfaceirregularities which could cause thetractor to be upset. Back the tractor with attachment upthe steepest portion of each slope youintend to work. If the tractor ...

Page 15 - Never direct; SECTION 8: ADJUSTMENTS; Seat Adjustment; Do not adjust

15 WARNING: To avoid possi- ble injury, do not allow anyonein the area opposite the dis-charge chute while mowing.Although the area has beensupposedly cleared of foreignobjects, small objects may bepicked up and discharged bythe mower. WARNING: Never direct the discharge of materialtoward bystanders...

Page 16 - Steering Wheel Tilt Adjustment; Front Wheel Alignment; Figure 16 is shown with the; Front

16 Steering Wheel Tilt Adjustment WARNING: Do not adjust the steering wheel when thetractor is moving. Adjustingthe steering wheel while thetractor is moving couldcause the operator to losecontrol of the tractor. To allow for the comfort of theoperator, an easy to operateadjustable steering wheel is...

Page 17 - Turning Radius Adjustment; SECTION 9: MAINTENANCE; Maintenance Chart

17 • With the brake pedal disengaged, insert an .030” feeler gauge betweenthe inner brake pad and the rotor. Ifthe .030” gauge does not fit, thebrakes are overly tightened andshould be loosened. • Attempt to insert an .060” feeler gauge between the inner brake padand the rotor. The .060” clearanceis...

Page 18 - LUBRICATION ILLUSTRATION; System Fluid Plus - ONLY

18 LUBRICATION ILLUSTRATION Cub Cadet 251H EP Greaseor equivalent No. 2 lithium grease Engine Oil: See Figure 25 on page 28Transmission Oil- Cub Cadet Drive Oil Can (High quality lubricating oil) System Fluid Plus - ONLY Eng ine Fro n t Pi vo t Ax le L /R Stee ring Knu c k le L /R Fro n t W hee ls F...

Page 19 - Accessing Engine Compartment; Turn; General Battery Information

19 Accessing Engine Compartment The engine compartment can beaccessed by lifting the hood upwardfrom the recessed notches of the sidepanels and tipping the hood forward. Ifgreater access is required, the tractoris equipped with quick release side panels. To remove the quick releaseside panels (see F...

Page 20 - Specific Gravity; Headlight Bulb Replacement

20 Battery Removal The battery is located under the dashpanel in the frame pedestal.To remove the battery:• Open the tractor hood by lifting it at the notches in the side panels. • Remove the upper baffle of the bulkhead from the front of the dashpanel by lifting upward on thelocking tab on each sid...

Page 22 - Adding Transmission Oil; dipstick must be installed; Changing Transmission Oil

22 Adding Transmission Oil WARNING: The fluid for yourtransmission has been spe-cially formulated to ensurethe safe and proper opera-tion of your tractor. Add CubCadet Drive System FluidPlus ONLY. Do not use anyother fluid. WARNING: Never overfill thetransmission case. Damagemay result if the oil le...

Page 23 - Electrical Box

23 NOTE: Do not reuse the transmissionoil. Contaminated transmission oil candamage the hydro transmission. Please dispose of used oilat appropriate recyclingcenters. • Clean around the base of the transmission oil filter and removethe filter by turning itcounterclockwise. • Apply a light coating of ...

Page 24 - Fuse

24 Figure 21 Fuse Fuses are installed to protect thetractor’s electrical system fromdamage caused by excessiveamperage.Always use the same capacity fuse forreplacement. Refer to theSpecifications Chart. If the electricalsystem does not function, check thefuses.To replace a fuse, note the position of...

Page 25 - SECTION 10: ENGINE INFORMATION; FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS; COVERAGE

25 SECTION 10: ENGINE INFORMATION KOHLER CO. FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS LIMITED WARRANTY UTILITY AND LAWN AND GARDEN ENGINES The U.S. Environmental Protection Agency (EPA),the California Air Resources Board (CARB), andKohler Co. are pleased to explain the Federal andCalifornia E...

Page 26 - LIMITATIONS; Cleaning The Engine; Full

26 LIMITATIONS This Emission Control System Warranty shall notcover any of the following: (a) repair or replacement required because of misuse or neglect, improper maintenance,repairs improperly performed or replacementnot conforming to Kohler Co. specificationsthat adversely affect performance and/...

Page 28 - Sparkplugs

28 See (Figure 25), VISCOSITY CHART,below for the proper type of oil. Figure 25 The oil filter is located behind the leftside panel and is mounted on theengine. See Accessing EngineCompartment on page 19 for detailson removing the side panels.Run the engine for a few minutes toallow the oil in the c...

Page 30 - Servicing The Paper Element

30 Servicing The Paper Element Inspect an replace the paper elementas necessary. See Figure 27. • Loosen the air cleaner cover knob and remove the cover. • Loosen and remove the element cover wing nut. • Remove element cover by lifting straight up. • Remove the foam precleaner by sliding it up off t...

Page 31 - SECTION 11: TROUBLE SHOOTING; Hard To Start

31 SECTION 11: TROUBLE SHOOTING Possible Cause Possible Remedy Hard To Start No fuel in fuel tank or carburetor Fill the tank with fuel. Check the fuel line, carburetor and fuel filter. Fuel ine or carburetor clogged Clean the fuel line and carburetor with a commercial carburetor cleaner. Fuel filte...

Page 32 - SECTION 12: OPTIONAL EQUIPMENT; Description

32 SECTION 12: OPTIONAL EQUIPMENT When you purchased your tractor, you probably had it completely equipped foryour particular needs at that time. However, later you may wish to obtainoptional equipment or accessories. These items and other allied equipment canbe purchased from, and installed by, you...

Page 33 - SECTION 13: SLOPE GAUGE; Do not mow on inclines with a slope in excess of

33 SECTION 13: SLOPE GAUGE WARNING: Do not mow on inclines with a slope in excess of 15 degrees (a rise of approximately 2-1/2 feet every 10 feet). A riding mower could overturn and cause serious injury. If operating a walk-behind mower on such a slope, it is extremely difficult to maintainyour foot...

Page 35 - SECTION 14: SPECIFICATIONS; Tires

35 SECTION 14: SPECIFICATIONS Engine Manufacturer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . KohlerHorsepower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18Cylinders . . . . . . . . . . . . . . . . . . . . . . . . ....

Page 36 - Batteries and belts are subject to separate terms as follows:

36 CUB CADET CORPORATION MANUFACTURER’S ONE YEAR LIMITED WARRANTY (COMMERCIAL USE) The limited warranty set forth below is given by CUB CADET CORPORATION(“CUB CADET”) with respect to new merchandise purchased and used in theUnited States, its possessions and territories. CUB CADET warrants this prod...

Page 38 - Year Limited Warranty - PTO Clutch

38 CUB CADET CORPORATION MANUFACTURER’S LIMITED WARRANTY (RESIDENTIAL USE) The limited warranty set forth below is given by CUB CADET CORPORATION(“CUB CADET”) with respect to new merchandise purchased and used in theUnited States, its possessions and territories. CUB CADET warrants this product agai...

Page 40 - SECTION 15: QUICK REFERENCE PARTS

SECTION 15: QUICK REFERENCE PARTS Description Part Number Engine Oil 737-3029 (SAE 30) 737-3030A (10W30) 737-3049 (5W30) Air Filter KH-47-083-03 KH-24-083-02 Engine Oil Filter KH-12-050-08 Spark Plug 759-3336 Transmission Oil Cub Cadet Drive System Fluid Plus 737-3120 - Quart 737-3121 - Gallon Trans...