Page 2 - USER MANUAL FOR GAS PIZZA OVEN; Drawings for reference only; WARNING
USER MANUAL FOR GAS PIZZA OVEN （ Drawings for reference only ） Model No.: 90551 Description: GAS PIZZA OVEN 13 INCH - For universal (LPG) Gas Dimensions: 52(W)x 52(D) x 28.5(H)cm Gas Connector: 5/8’’ – 18UNF Read this instruction carefully and ensure that your pizza oven is properly installed, assem...
Page 3 - CONTENTS
3/24 CONTENTS FEATURES & BENEFITS 4 TECHNICAL INFORMATION 4 POSITIONING THE PIZZA OVEN 5 SAFETY INFORMATION 6~9 USE AND CHARACTERISTICS 9~11 LIGHTING THE PIZZA OVEN 11~12 REGULATOR & HOSE 12 GAS CYLINDERS 13~16 GAS LEAK TEST 16~17 CARE & MAINTENANCE 17~18 EXPLODED PRODUCT DIAGRAM 19 PART...
Page 4 - TECHNICAL INFORMATION; UNIVERSAL LPG ONLY
4/24 FEATURES & BENEFITS TECHNICAL INFORMATION MODEL SAI № INJECTOR (MM) PRESSURE (KPA) INP/BURN R (MJ/H) TOTAL (MJ/H) 90551 SAI-400428 Φ1.19 2.75 1x18 18 Total nominal gas consumption: 18MJ/h Minimum clearance of appliance to combustible surfaces is 100cm at the rear, sides and overhead. FOR OU...
Page 5 - POSITIONING THE PIZZA OVEN
5/24 POSITIONING THE PIZZA OVEN This appliance shall only be used in an above ground open air situation with natural ventilation, without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by wind and natural convection. The pizza oven must not be installed under or o...
Page 6 - SAFETY INFORMATION; IMPORTANT! PLEASE READ
6/24 SAFETY INFORMATION SAFETY COMPLIANCE LABEL While there is a requirement under the regulations for all gas products to be safe, the Australian and New Zealand regulatory environment establishes the limits of fundamental safety. The safety compliance label confirms that this pizza oven has been c...
Page 8 - READ All SAFE GUARDS AND INSTRUCTIONS THOROUGHLY!; GAS APPLIANCE SAFETY
8/24 READ All SAFE GUARDS AND INSTRUCTIONS THOROUGHLY! YOUR SAFETY IS VERY IMPORTANT – FAILURE TO FOLLOW PROPER PROCEDURES AND SAFEGUARDS MAY RESULT IN PROPERTY DAMAGE OR PERSONAL INJURY. GAS APPLIANCE SAFETY REFERENCE TO THE REQUIREMENTS OF AS/NZS 5601 AND THE LOCAL AUTHORITY — — GAS OR ELECTRICITY...
Page 9 - USE AND CHARACTERISTICS
9/24 It may be hazardous to attempt to fit other types of gas containers. This appliance shall only be used with a Universal LPG cylinder certified to AS 2469. USE AND CHARACTERISTICS The pizza oven is safe and easy to use. The specified gases for use are LPG at 2.75kPa, Please ensure you only use y...
Page 11 - INSTRUCTIONS FOR USE; LIGHTING THE PIZZA OVEN
11/24 INSTRUCTIONS FOR USE Follow these instructions carefully to avoid seriously damaging your pizza oven and causing injury to yourself and to property. 1. Assemble the pizza oven by following the assembly instructions carefully. 2. Connect the gas hose to the pizza oven. Connect the regulator to ...
Page 13 - GAS CYLINDERS; GAS AND REGULATOR INFORMATION
13/24 GAS CYLINDERS The gas cylinder should not be dropped or handled roughly! If the appliance is not in use, the cylinder must be disconnected. Replace the protective cap on the cylinder after disconnecting the cylinder from the appliance. Cylinders must be stored outdoors in an upright position a...
Page 14 - CONNECT THE LPG CYLINDER
14/24 CONNECTING THE HOSE AND REGULATOR TO THE LPG CYLINDER • Only use the hose assembly supplied with this appliance for direct connection to the cylinder. DO NOT USE ADAPTORS. DO NOT use any other hose assembly. Check the gas hose for damage or signs of abrasion before each use. only use AGA certi...
Page 16 - GAS LEAK TEST
16/24 DO NOT release liquid petroleum gas (LPG) into the atmosphere. To remove gas from LPG cylinder, contact a certified LPG dealer or local fire department for assistance. GAS LEAK TEST The gas connections on your pizza oven were leak tested at the factory before shipment, however a complete leak ...
Page 17 - CLEANING AND CARE
17/24 Step 3 Apply the soap solution to all the gas connections using a soft bristle brush or spray bottle. If you smell gas and/or soap bubbles start to appear from a gas connection it is a sign that a leak is present. If there is a leak, turn off your gas supply and tighten the connection. Repeat ...
Page 18 - SERVICING
18/24 PIZZA STONE Use a mild soapy water solution. Non-abrasive scouring powder can be used on stubborn stains, then rinse with water. BURNER Turn the gas OFF at the control knob and disconnect the cylinder. Remove cooling grate. Clean the burner with a soft brush or blow clean with compressed air a...
Page 19 - PART
19/24 EXPLODED PRODUCT DIAGRAM PART LIST PART NAME QTY 1 PIZZA OVEN (WITH REGULATOR & HOSE) 1 2 PIZZA STONE 1
Page 20 - ASSEMBLY INSTRUCTIONS; Step 1: put the pizza stone into the pizza oven
20/24 ASSEMBLY INSTRUCTIONS Step 1: put the pizza stone into the pizza oven Step 2: put the battery into the battery box, make sure the battery is installed in correct place.
Page 21 - TROUBLE SHOOTING; Problem
21/24 TROUBLE SHOOTING Problem SOLUTION Burner will not ignite If ignition does not occur in 5 seconds: STEP 1 Turn the burner controls OFF. STEP 2 Wait 5 minutes. STEP 3 Repeat the lighting procedure. If this does not work, to determine the cause, please try to ignite your appliance with a match. M...
Page 22 - WARRANTY
22/24 WARRANTY Thank you for purchasing one of our quality COZZE PIZZA OVENS. YOUR PIZZA OVEN IS COVERED AGAINST DEFECTS FOR A PERIOD OF 2 YEARS FOR PARTS AND LABOUR, REPAIR OR REPLACEMENT. THIS WARRANTY EXCLUDES SURFACE RUST AND DAMAGE CAUSED BY ABUSE OR NEGLECT. CONDITIONS OF THE WARRANTY • The PI...
Page 24 - FIND MORE INSPIRATION ONLINE AT
Mayo Hardware Pty Ltd Phone (Aus): 1300 360 211 Phone (NZ): 09 415 6240 Email: [email protected] FIND MORE INSPIRATION ONLINE AT COZZE-PIZZA.COM 90551
