Chevrolet Roadtrek - Manuals

Page 3 - WARNINGS AND CAUTIONS; WARNINGS

WARNINGS & CAUTIONS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 WARNINGS AND CAUTIONS This manual contains WARNINGS against operating procedures which could result in an accident or bodil...

Page 4 - CARBON MONOXIDE LEAK DETECTOR:

WARNINGS & CAUTIONS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt© © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 WARNINGS: SEAT BELTS: Only forward facing seats equipped with factory installed seat belts are to be occupied while the vehi...

Page 5 - 10 VOLT ELECTRICAL SERVICING:; Cloverleaf dining table is heavy, lift while bending knees.; REPLACING THE AUXILIARY BATTERY:

WARNINGS & CAUTIONS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt© © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 110 VOLT ELECTRICAL SERVICING: Prior to servicing the 110 volt Galley GFCI & Audio/Video cabinet interior receptacles, u...

Page 6 - CUSTOMER SERVICE PROCEDURES; OBTAINING MOTORHOME SERVICE; Using the word “Motorhome” may cause

CUSTOMER SERVICE PROCEDURES D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 OBTAINING MOTORHOME SERVICE The solution to all your Roadtrek concerns starts with your Roadtrek Dealer Roadtrek Dealer...

Page 7 - TABLE OF CONTENTS

Page 9 - Roadtrek Motorhome Van.; We would like to take this opportunity to thank you for selecting a; Roadtrek; INTRODUCTION; Roadtrek; dealer will; IMPORTANT

INTRODUCTION D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 A A--0 0 A WORD TO ROADTREK OWNERS... This manual has been prepared to acquaint you with the operation, maintenance and warranties of ...

Page 11 - VEHICLE SPECIFICATIONS

VEHICLE SPECIFICATIONS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt© © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 A A--2 2 2005 STANDARD Roadtrek 210 models AND OPTIONAL on Chevrolet 3500 AUTOMOTIVE FEATURES Extended Van Air bag - driver &...

Page 12 - APPLIANCE LOG; APPLIANCE & ACCESSORY MANUFACTURER’S LOG; Appliance

APPLIANCE LOG D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 A A--3 3 APPLIANCE & ACCESSORY MANUFACTURER’S LOG Appliance Manufacturer Model Awning Fiamma F45 Battery - Auxiliary Trojan 27TM ...

Page 13 - Component

CONTACT INFORMATION MANUFACTURER CONTACT INFORMATION: Component Manufacturer Location Phone Number Awning Fiamma Orlando, FL 407-672-0091 Detector-carbon monoxide MTI Industries Wauconda, IL 800-383-0269, 847-487-4940 Detector - LP gas MTI Industries Wauconda, IL 800-383-0269, 487-487-4940 DVD Playe...

Page 15 - DAILY LIVING; Swivel Lever

CAPTAIN’S SEATS: To recline, pull up the recline control lever below the inboardarmrest and lean back. To slide, pull up on the slide bar located on the front of theseat and slide the seat either forward or back, (see Picture B-P1a). To swivel the seats from a forward facing position to arearward fa...

Page 20 - To convert the lounge seat into a single bed:; Swiveled front captain seat.

FRONT LOUNGE SEATS: To convert the lounge seat into a single bed: 1. Swivel the passengercaptain’s seat 90degrees clockwiseso that the backrestis toward thecenter aisle. Be sureall armrests are inan upright position,(see Picture B-P15). 2. Slide out the drawerunder thepassenger loungeseat and fullye...

Page 24 - Exterior fresh water tank drain valve.; EXTERIOR ACCESS DOORS:; Grey water gate valve handle.

Picture B-P29: Exterior fresh water tank drain valve. DAILY LIVING D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 B B--1 10 0 EXTERIOR ACCESS DOORS: DRIVER SIDE ACCESS DOORS: Behind the lockable...

Page 25 - PASSENGER SIDE ACCESS DOORS:; REAR STORAGE UNDER THE BED:; Slide out battery drawer, dual battery

L.P.G. (Liquid Propane Gas) ACCESS DOOR: Behind the L.P.G. access door, (integrated into the rear bumper, covered with a black plate, see Picture B-P31), thefollowing are found: 1. L.P.G. fill valve. 2. L.P.G. tank shut off valve. 3. Portable barbecue connection. PASSENGER SIDE ACCESS DOORS: Behind ...

Page 29 - FRESH WATER SYSTEM

FRESH WATER SYSTEM D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 C C--1 1 210 Chevrolet

Page 30 - FLOOR PLAN & APPLIANCE LOCATION

Page 35 - ELECTRICAL SYSTEM

Page 43 - should be checked annually for possible leaks.; Follow all recommended maintenance schedules.

D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 F F--1 1 L.P.G. & SAFETY SYSTEM Your vehicle is equipped with an L.P.G. (Liquid Propane Gas) system which, when properly handled and maintained...

Page 44 - REFUELING PROCEDURES:; The tank valve must be closed and; (see Operating Instructions) SHALL BE TURNED OFF

L.P.G. & SAFETY SYSTEM D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 F F--2 2 L.P.G. TANK: To open and close the tank use the manual tank shutoff valve located on the tank, accessible from ...

Page 45 - Do not; Carbon monoxide leak detector.

L.P.G. & SAFETY SYSTEM D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 F F--3 3 L.P.G. LEAK DETECTOR: Your vehicle has been equipped with a L.P.G. leak detection devicefor your protection, (s...

Page 46 - 10-Popular Chevrolet

L.P.G. & SAFETY SYSTEM D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 F F--4 4 210-Popular Chevrolet BTU/hr BTU/hr BTU/hr BTU/hr (POL) B TU/hr

Page 47 - 10-Versatile Chevrolet

L.P.G. & SAFETY SYSTEM D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 F F--5 5 210-Versatile Chevrolet

Page 49 - WATER SYSTEMS; WINTER MODE VALVE POSITIONS:; During winter use - Use gravity fill for interior tank only.; SUMMER USE VALVE POSITION:; Selector valve position for supply from

WATER SYSTEMS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 G G--1 1 WINTER MODE VALVE POSITIONS: Tank selector valve must be in the interior tank position, (see Picture G-P1). WINTER USE: (Mod...

Page 50 - When the water system is operating in the winter mode,

WATER SYSTEMS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 G G--2 2 Your Roadtrek is equipped with a water heater by-pass.valve. When it is in summer mode, all three valves will facethe aisle,...

Page 51 - Repeat the steps in reverse order.

WATER SYSTEMS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 G G--3 3 To drain the exterior fresh water tank you must open exterior drain valve at the low point drain located below thedrivers si...

Page 52 - FILLING THE INTERIOR FRESH WATER TANK:; Open the rear passenger door.; The gravity fill for the interior fresh

FRESH WATER TANKS: One tank is located in the vehicle’s interior, the other tank is located on the vehicle’s exterior. The purpose of thedual tank system is to provide a separate fresh water system that can be used in moderate sub freezing conditions. The system can only function properly in either ...

Page 53 - Open the water source moderately.; CITY WATER CONNECTION:; City water connection can only be used in summer

WATER SYSTEMS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 G G--5 5 The fresh water tanks can also be filled through the citywater inlet located behind the rear lockable driver sideaccess draw...

Page 54 - To disconnect the city water connection:; WASTE WATER STORAGE AND DUMPING SYSTEM:; Ensure that both the black and grey water gate; Waste Water Tank Preparation:; During winter use under moderate subfreezing

WATER SYSTEMS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 G G--6 6 To disconnect the city water connection: 1. Turn off the external water source. 2. Open the sink faucet to relieve the press...

Page 55 - Macerator; Macerator manual

Waste Water Tank Dumping: To dump the exterior black waste water tank: 1. Turn the battery disconnect switch to the “ON” position, if not already on, (located on the monitor panel). 2. Remove sewage discharge hose from storage, (see Picture G-P17). 3. Insert the discharge outlet into the waste recep...

Page 56 - Waste Water Tank Flushing:; (be sure to step on the flush pedal, so the; POTABLE WATER SYSTEM DRAINING:; Outside shower and shore power

WATER SYSTEMS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 G G--8 8 Waste Water Tank Flushing: To flush the waste water tanks: 1. Ensure that both tanks are empty by checking the monitor panel...

Page 57 - POTABLE WATER SYSTEM SANITIZING:

WATER SYSTEMS D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 G G--9 9 POTABLE WATER SYSTEM SANITIZING: NOTE: Water system must be in summer operation mode. Your potable water system should be sa...

Page 61 - OWNER MAINTENANCE; FIBERGLASS MAINTENANCE:; OUTSIDE YOUR VEHICLE:; Before winter storage:

OWNER MAINTENANCE D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 H H--1 1 FIBERGLASS MAINTENANCE: To maintain the original appearance and finish, your vehicle’s fiberglass running boards, roof a...

Page 62 - CARGO CARRYING CAPACITY:

OWNER MAINTENANCE D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 H H--2 2 SPRING START UP: After storage, reactivate your vehicle for use by reversing all the procedures that you performed to pr...

Page 63 - AT LEAST TWICE A YEAR:

OWNER MAINTENANCE D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 H H--3 3 AT LEAST TWICE A YEAR: Check power steering fluid level. Check windshield washer level and wiper operation. Clean wiper ...

Page 64 - ALUMINUM WHEEL MAINTENANCE:

OWNER MAINTENANCE D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 H H -- 4 4 ALUMINUM WHEEL MAINTENANCE: Never clean your wheels when they are hot either from free standing in the sun, or from no...

Page 65 - LIMITED WARRANTY INFORMATION; LIMITED WARRANTY DEFINITIONS

LIMITED WARRANTY INFORMATION D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 II--1 1 LIMITED WARRANTY DEFINITIONS Home & Park Home & Park Motorhomes (A Division of HANMAR MOTOR CORPORATIO...

Page 66 - Chevrolet dealers; manufactured components

LIMITED WARRANTY INFORMATION D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 II--2 2 AUTOMOTIVE WARRANTY - GENERAL MOTORS ( CHEVROLET CHASSIS) For Chevrolet chassis sold through Chevrolet dealers...

Page 67 - or; all warranty repairs; Unauthorized repairs or alterations.

LIMITED WARRANTY INFORMATION HOME & PARK LIMITED MOTORHOME WARRANTY: Home & Park warrants to the Purchaser that the Vehicle is free from defects in material and workmanship on theportion manufactured by Home & Park, under normal use and service, for four (4) years or 48,000 miles (U.S). ...

Page 69 - CUSTOMER ASSISTANCE

CUSTOMER ASSISTANCE D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 JJ--1 1 REPORTING SAFETY DEFECTS (U.S. ONLY) If you believe that your vehicle has a defect which could cause a crash or could c...

Page 70 - ROADTREK CLUB INTERNATIONAL; Address all inquiries to:; WEBSITE; Checkout the Roadtrek website at WWW.roadtrek.com

CUSTOMER ASSISTANCE D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 JJ--2 2 ROADTREK CLUB INTERNATIONAL As a new Roadtrek owner, you are cordially invited to join our family of Roadtrek owners as...

Page 71 - MEMBERSHIP APPLICATION; Date; FMCA; “Roadtrek International”; FAMILY MOTOR COACH ASSOCIATION; Please Print; License Plate Number:

ROADTREK INTERNATIONAL CHAPTER FMCA A ROADTREK OWNERS’ CLUB Please Print MEMBERSHIP APPLICATION Date ______________ Last Name __________________ First Name ________________ Spouse ____________________ Address ____________________ City ______________________ Prov/State __________________ Country ____...

Page 73 - CHANGE OF ADDRESS FORM

CHANGE OF ADDRESS FORM D Do occ N No o:: 21906532-210C05 R Re ev v:: 02 C Co op py yrriig gh htt © © H Ha an nm ma arr M Mo otto orr C Co orrp po orra attiio on n 2 20 00 05 5 L L--2 2

Page 75 - CUSTOMER REFERRAL CARD