Chevrolet 2002 - Manuals

iv Vehicle Damage Warnings Also, in this book you will find these notices: NOTICE: These mean there is something that could damageyour vehicle. In the notice area, we tell you about something that candamage your vehicle. Many times, this damage wouldnot be covered by your warranty, and it could be c...

vi Model Reference This manual covers these models: Passenger Van Cargo Van Cab and Chassis

1-2 Seats and Seat Controls This part tells you about the seats -- how to adjust them, take them out and put them back in. It also tells youabout reclining front seatbacks. Manual Front Seats The bucket seats can be adjusted forward or rearwardwith the lever located at the front of the seat. To adju...

1-3 Power Seat (Option) If your vehicle has a power seat on the driver’s orpassenger’s side, you can adjust it with these controlslocated at the front center of the seat cushion. To raise or lower the seat, move the center knob up ordown. To move the seat forward or rearward, move thecenter knob tow...

1-5 Rear Seats Getting Into the Rear Seats To make it easier for passengers to get into the rearseats, use the fastener spot on the headliner and safetybelt sleeve. These will keep the safety belts out of theway while people get into the rear seats. Removing the Rear Seat 1. Disconnect the quick rel...

1-8 For the remaining rear seats, stow the safety beltlatch plate on the clip at the window trim. Replacing the Rear Seats CAUTION: A seat that isn’t locked into place properly canmove around in a collision or sudden stop. Peoplein the vehicle could be injured. Be sure to lockthe seat into place pro...

1-10 5. Turn the blue or yellow handle down until it is in the retaining clip. 6. If the vehicle has a floor mat, put the flap back to its original position 7. Repeat this procedure for the other seat base. 8. Connect the quick - release latch plates for the lap - shoulder belts by inserting the lat...

1-12 Why Safety Belts Work When you ride in or on anything, you go as fast as it goes. Take the simplest vehicle. Suppose it’s just a seat on wheels. Put someone on it.

1-13 Get it up to speed. Then stop the vehicle. The riderdoesn’t stop. The person keeps going until stopped by something. In a real vehicle, it could be the windshield ...

1-15 Here Are Questions Many People AskAbout Safety Belts -- and the Answers Q: Won’t I be trapped in the vehicle after anaccident if I’m wearing a safety belt? A: You could be -- whether you’re wearing a safety belt or not. But you can unbuckle a safety belt,even if you’re upside down. And your cha...

1-16 How to Wear Safety Belts Properly Adults This part is only for people of adult size. Be aware that there are special things to know about safety belts and children. And there are different rules for smaller children and babies. If a child will be riding in your vehicle, see the part of this man...

1-18 Shoulder Belt Height Adjuster Before you begin to drive, move the shoulder beltadjuster to the height that is right for you. To move it down, push in at the top of the arrows andmove the height adjuster to the desired position. You canmove the adjuster up just by pushing up on the shoulderbelt ...

1-19 Q: What’s wrong with this? A: The shoulder belt is too loose. It won’t give nearlyas much protection this way. CAUTION: You can be seriously hurt if your shoulder belt istoo loose. In a crash, you would move forward toomuch, which could increase injury. The shoulderbelt should fit against your ...

1-20 Q: What’s wrong with this? A: The belt is buckled in the wrong place. CAUTION: You can be seriously injured if your belt is buckledin the wrong place like this. In a crash, the beltwould go up over your abdomen. The belt forceswould be there, not at the pelvic bones. This couldcause serious int...

1-21 Q: What’s wrong with this? A: The belt is over an armrest. CAUTION: You can be seriously injured if your belt goesover an armrest like this. The belt would bemuch too high. In a crash, you can slide underthe belt. The belt force would then be applied atthe abdomen, not at the pelvic bones, and ...

1-23 Q: What’s wrong with this? A: The belt is twisted across the body. CAUTION: You can be seriously injured by a twisted belt. In a crash, you wouldn’t have the full width of the belt to spread impact forces. If a belt istwisted, make it straight so it can work properly,or ask your dealer to fix i...

1-24 To unlatch the belt, just push the button on the buckle.The belt should go back out of the way. Before you close the door, be sure the belt is out of theway. If you slam the door on it, you can damage both thebelt and your vehicle. Safety Belt Use During Pregnancy Safety belts work for everyone...

1-25 The best way to protect the fetus is to protect the mother. When a safety belt is worn properly, it’s more likely that the fetus won’t be hurt in a crash.For pregnant women, as for anyone, the key to makingsafety belts effective is wearing them properly. Right Front Passenger Position To learn ...

1-29 How the Air Bag System Works Where are the air bags? The driver’s air bag is in the middle of the steering wheel. The right front passenger’s air bag is in the instrumentpanel on the passenger’s side.

1-30 CAUTION: If something is between an occupant and an airbag, the bag might not inflate properly or it mightforce the object into that person causing severeinjury or even death. The path of an inflating air bag must be kept clear. Don’t put anythingbetween an occupant and an air bag, and don’tatt...

1-31 What makes an air bag inflate? In an impact of sufficient severity, the air bag sensingsystem detects that the vehicle is in a crash. The sensingsystem triggers a release of gas from the inflator, whichinflates the air bag. The inflator, air bag and relatedhardware are all part of the air bag m...

1-33 Servicing Your Air Bag-Equipped Vehicle Air bags affect how your vehicle should be serviced.There are parts of the air bag system in several placesaround your vehicle. You don’t want the system toinflate while someone is working on your vehicle. Your dealer and the service manual have informati...

1-34 Rear Seat Passengers It’s very important for rear seat passengers to buckle up!Accident statistics show that unbelted people in the rearseat are hurt more often in crashes than those who arewearing safety belts. Rear passengers who aren’t safety belted can be thrownout of the vehicle in a crash...

1-36 CAUTION: You can be seriously hurt if your shoulder belt istoo loose. In a crash, you would move forward toomuch, which could increase injury. The shoulderbelt should fit against your body. To unlatch the belt, just push the button on the buckle. Rear Safety Belt Comfort Guides forChildren and ...

1-39 Center Passenger Position Lap Belt If your vehicle has rear bench seats, someone can sit inthe center positions. When you sit in a center seating position, you have a lap safety belt, which has no retractor. To make the beltlonger, tilt the latch plate and pull it along the belt.

1-40 To make the belt shorter, pull its free end as shown untilthe belt is snug. Buckle, position and release it the same way as the lappart of a lap - shoulder belt. If the belt isn’t long enough, see “Safety Belt Extender” at the end of this section. Make sure the release button on the buckle is p...

1-42 CAUTION: Children who are up against, or very close to, any air bag when it inflates can be seriouslyinjured or killed. Air bags plus lap - shoulder belts offer outstanding protection for adults and olderchildren, but not for young children and infants.Neither the vehicle’s safety belt system n...

1-43 CAUTION: The body structure of a young child is quiteunlike that of an adult or older child, for whomthe safety belts are designed. A young child’s hipbones are still so small that the vehicle’s regularsafety belt may not remain low on the hip bones,as it should. Instead, it may settle up aroun...

1-45 CAUTION: People should never hold a baby in their armswhile riding in a vehicle. A baby doesn’t weighmuch -- until a crash. During a crash a baby will become so heavy it is not possible to hold it.For example, in a crash at only 25 mph (40 km/h),a 12 - lb. (5.5 kg) baby will suddenly become a 2...

1-46 Restraint Systems for Children An infant car bed (A), a special bed made for use in amotor vehicle, is an infant restraint system designed torestrain or position a child on a continuous flat surface.Make sure that the infant’s head rests toward the centerof the vehicle. A rear - facing infant s...

1-48 Q: How do child restraints work? A: A child restraint system is any device designed foruse in a motor vehicle to restrain, seat, or positionchildren. A built - in child restraint system is a permanent part of the motor vehicle. An add - on child restraint system is a portable one, which ispurch...

1-50 Where to Put the Restraint (Cargo Vansand Cab and Chassis Models) The child restraint must be secured properly in thepassenger seat. If your vehicle has a passenger air bag,never put a rear - facing child restraint in this vehicle. Here’s why: CAUTION: A child in a rear - facing child restraint...

1-52 If your vehicle is a cargo van, the anchor for a top strapis located at the rear of the seat cushion on the rightfront passenger’s seat. Cargo Van Models If your vehicle is a passenger van with rear seats, an anchor bracket for a top strap is located at the rear of the seat cushion for each thr...

1-61 Older Children Older children who have outgrown booster seats shouldwear the vehicle’s safety belts. If you have the choice, a child should sit next to awindow so the child can wear a lap - shoulder belt and get the additional restraint a shoulder belt can provide. Q: What is the proper way to ...

1-62 CAUTION: Never do this. Here two children are wearing the same belt. The belt can’t properly spread the impact forces.In a crash, the two children can be crushedtogether and seriously injured. A belt must beused by only one person at a time. Q: What if a child is wearing a lap - shoulder belt, ...

1-63 CAUTION: Never do this. Here a child is sitting in a seat that has alap - shoulder belt, but the shoulder part is behind the child. If the child wears the belt in this way, in a crash the child might slide under the belt.The belt’s force would then be applied right onthe child’s abdomen. That c...

1-64 Safety Belt Extender If the vehicle’s safety belt will fasten around you, you should use it. But if a safety belt isn’t long enough to fasten, yourdealer will order you an extender. It’s free. When you go in to order it, take the heaviest coat you will wear, sothe extender will be long enough f...

2-2 Windows CAUTION: Leaving children in a vehicle with the windowsclosed is dangerous. A child can be overcome by the extreme heat and can suffer permanentinjuries or even death from heat stroke. Never leave a child alone in a vehicle, especiallywith the windows closed in warm or hot weather. Manua...

2-4 Swing-Out Windows Side Swing - Out Window To open the side door swing - out windows, pull up on the latch at the edge of the window. Swing the windowout and push down on the latch to lock the window into place. To close the window, pull the latch toward you and pushdown on the latch to lock it. ...

2-6 Door Locks CAUTION: Unlocked doors can be dangerous.D Passengers -- especially children -- can easily open the doors and fall out of a movingvehicle. When a door is locked, the handlewon’t open it. You increase the chance ofbeing thrown out of the vehicle in a crash if the doors aren’t locked. S...

2-7 Power Door Locks (Option) Press the bottom side of thepower door lock switch tolock all the doors at once.Press the top side of thepower door lock switch tounlock all the doors at once. When a door is locked, the inside door handle will not work. Rear Door Security Lock Security locks are locate...

2-8 Move the button to the left to engage the security feature. Move the button to the right to return the door locks tonormal operation. 60/40 Swing - Out Side Door Move the button up toengage the securityfeature. Move thebutton down to returnthe door locks tonormal operation. Side Sliding Door Key...

2-9 Changes or modifications to this system by other than an authorized service facility could void authorization to use this equipment. At times you may notice a decrease in range. This isnormal for any remote keyless entry system. If thetransmitter does not work or if you have to stand closerto yo...

2-10 Matching Transmitter(s) to Your Vehicle Each remote keyless entry transmitter is coded toprevent another transmitter from unlocking your vehicle.If a transmitter is lost or stolen, a replacement can bepurchased through your dealer. Remember to bring anyremaining transmitters with you when you g...

2-11 3. Align the covers and snap them together. 4. Check the operation of the transmitter. If the transmitter does not work after battery replacement,it may need to be resynchronized to your vehicle.See “resynchronization” following. Resynchronization Resynchronization may be necessary due to the s...

2-14 60/40 Swing - Out Side Door To open the front portion of a 60/40 door from theoutside, pull up on the handle and pull the handle toward you. To open the front portion of a 60/40 door from the inside,pull the handle toward you and push open the door.

2-16 Rear Doors CAUTION: It can be dangerous to drive with the rear door(s)or rear swing - out windows open because carbon monoxide (CO) gas can come into your vehicle.You can’t see or smell CO. It can causeunconsciousness and even death. CAUTION: (Continued) CAUTION: (Continued) If you must drive w...

2-18 Rear Swing - Out Window The rear swing - out windows work the same way as the side swing out windows, but the latch is located at thebottom edge of the window. See ”Side - Door Swing Out Windows” in the index. Theft Vehicle theft is big business, especially in some cities.Although your vehicle ...

2-19 Parking at Night Park in a lighted spot, close all windows and lock yourvehicle. Remember to keep your valuables out of sight.Put them in a storage area, or take them with you. Parking Lots Even if you park in a lot where someone will bewatching your vehicle, it’s still best to lock it up andta...

2-20 New Vehicle “Break - In” NOTICE: Your vehicle doesn’t need an elaborate “break - in.” But it will perform better in the long run if youfollow these guidelines:D Keep your speed at 55 mph (88 km/h) or less for the first 500 miles (805 km). D Don’t drive at any one speed -- fast or slow -- for th...

2-21 NOTICE: If your key seems stuck in LOCK and you can’tturn it, be sure you are using the correct key; if so, is it all the way in? If it is, then turn thesteering wheel left and right while you turn thekey hard. Turn the key only with your hand.Using a tool to force it could break the key or the...

2-23 Engine Coolant Heater (If Equipped) In very cold weather, 0 _F ( - 18 _C) or colder, the engine coolant heater can help. You’ll get easier starting andbetter fuel economy during engine warm - up. Usually, the coolant heater should be plugged in a minimum offour hours prior to starting your vehi...

2-24 How long should you keep the coolant heater pluggedin? The answer depends on the outside temperature, thekind of oil you have, and some other things. Instead oftrying to list everything here, we ask that you contactyour dealer in the area where you’ll be parking yourvehicle. The dealer can give...

2-27 Parking Brake To set the parking brake, hold the regular brake pedaldown with your right foot. Push down the parking brakepedal with your left foot. If the ignition is on, the brake system warning light willcome on. To release the parking brake, hold the regular brakepedal down. Pull the handle...

2-30 Torque Lock If you are parking on a hill and you don’t shift yourtransmission into PARK (P) properly, the weight of thevehicle may put too much force on the parking pawl inthe transmission. You may find it difficult to pull theshift lever out of PARK (P). This is called “torque lock.”To prevent...

2-31 Parking Over Things That Burn CAUTION: Things that can burn could touch hot exhaustparts under your vehicle and ignite. Don’t parkover papers, leaves, dry grass or other things thatcan burn.

2-32 Engine Exhaust CAUTION: Engine exhaust can kill. It contains the gascarbon monoxide (CO), which you can’t see orsmell. It can cause unconsciousness and death. You might have exhaust coming in if:D Your exhaust system sounds strange or different. D Your vehicle gets rusty underneath. D Your vehi...

2-33 CAUTION: It can be dangerous to get out of your vehicle ifthe shift lever is not fully in PARK (P) with theparking brake firmly set. Your vehicle can roll.Don’t leave your vehicle when the engine isrunning unless you have to. If you’ve left theengine running, the vehicle can move suddenly.You o...

2-34 Tilt Wheel (Option) A tilt steering wheel allows you to adjust the steeringwheel before you drive. You can also raise it to thehighest level to give your legs more room when youenter and exit the vehicle. The lever is located on the lower left side of the steering column. To tilt the wheel, hol...

2-35 Turn and Lane Change Signals The turn signal has two upward (for right) and twodownward (for left) positions. These positions allow youto signal a turn or a lane change. To signal a turn, move the lever all the way up or down.When the turn is finished, the lever will return automatically. An ar...

2-38 Setting Cruise Control CAUTION: If you leave your cruise control switch on whenyou’re not using cruise, you might hit a buttonand go into cruise when you don’t want to. Youcould be startled and even lose control. Keep thecruise control switch off until you want to usecruise control. 1. Move the...

2-39 Resuming a Set Speed Suppose you set your cruise control at a desired speedand then you apply the brake. This, of course, shuts offthe cruise control. But you don’t need to reset it. Once you’re going about 25 mph (40 km/h) or more,you can move the cruise control switch briefly from on to resum...

2-40 Reducing Speed While Using Cruise Control D Press in the button at the end of the lever until you reach the lower speed you want, then release it. D To slow down in very small amounts, press the button at the end of the lever briefly. Each time youdo this, you’ll go about 1 mph (1.6 km/h) slowe...

2-41 Exterior Lamps The exterior lamp control is located on the driver’s sideof the instrument panel. The exterior lamp control has three positions: OFF: Turning the control to this position turns off alllamps except the Daytime Running Lamps (DRL). (Parking Lamps): Turning the control to this posit...

2-42 Headlamps On Reminder A tone will sound when your headlamps are turned onand your ignition is in OFF, LOCK or ACCESSORY. If you need to use your headlamps when the ignitionswitch is in OFF, LOCK or ACCESSORY, the tone can be turned off by moving the instrument panelbrightness thumbwheel next to...

2-43 Center High-Mounted Stoplamp Your vehicle’s center high - mounted stoplamp is located above the rear doors at the center of the vehicle. If items are loaded on the roof of the vehicle, as in aluggage carrier, care should be taken not to block ordamage the center high - mounted stoplamp unit. In...

2-44 Dome Lamps The dome lamps will come on when you open a door. You can also turn the dome lamps on by moving theinstrument panel brightness thumbwheel, located next to the exterior lamp control, all the way up to the secondposition. In this position, the dome lamps will remain onwhether a door is...

2-45 Reading Lamps (Option) If your vehicle has reading lamps, press the button nextto the lamp to turn the lamp on or off. Mirrors Inside Day/Night Rearview Mirror Pull the tab under the mirror toward you to reduce glare from headlamps behind you after dark. Push thetab away from you to restore the...

2-47 Convex Outside Mirror Your passenger’s side mirror may be convex. A convexmirror’s surface is curved so you can see more from thedriver’s seat. CAUTION: A convex mirror can make things (like othervehicles) look farther away than they really are. If you cut too sharply into the right lane, youco...

2-48 1. To adjust the mirrors when towing a trailer,turn the mirror bypushing the mirror head toward the front of the vehicle. 2. Turn the mirror head so that it swings further outboard andadjust the mirror surface as needed.

2-50 NOTICE: Holding a cigarette lighter in with your handwhile it is heating can make it overload,damaging the lighter and the heating element.Just push the lighter all the way in and let go.When it’s done, it will pop back by itself. To remove the front ashtray, pull up on the tab with akey or sim...

2-51 Accessory Power Outlet You can plug accessory electrical equipment into anaccessory power outlet. Just pull on the outlet cover to remove it and follow the proper installationinstructions that are included with any electricalequipment that you install. The accessory power outlet is located on t...

2-52 The Instrument Panel - Your Information System The main components of your instrument panel are the following: A. Lamp ControlB. Air VentsC. Instrument Panel ClusterD. Comfort Controls System E. Audio SystemF. Turn Signal/Multifunction LeverG. HornH. Convenience Tray I. Cigarette LighterJ. Cuph...

2-53 Instrument Panel Cluster United States version shown, Canada similar Your instrument panel cluster is designed to let you know at a glance how your vehicle is running. You’ll know how fast you’re going, how much fuel you’re using, and many other things you’ll need to know to drive safely and ec...

2-54 Speedometer Your speedometer lets you see your speed in both miles per hour (mph) and kilometers per hour (km/h).Your odometer shows how far your vehicle has beendriven, in either miles (used in the United States) orkilometers (used in Canada). You may wonder what happens if your vehicle needs ...

2-55 Trip Odometer The trip odometer cantell you how far yourvehicle has beendriven since you lastset the trip odometer to zero. To reset the trip odometer, fully press the reset buttonlocated near the trip odometer readout. The trip odometer can show either total miles or tripmiles using this butto...

2-56 When one of the warning lights comes on and stays onwhen you are driving, or when one of the gages showsthere may be a problem, check the section that tells youwhat to do about it. Please follow this manual’s advice.Waiting to do repairs can be costly -- and even dangerous. So please get to kno...

2-57 If the air bag readiness light stays on after you start thevehicle or comes on when you are driving, your air bagsystem may not work properly. Have your vehicleserviced right away. CAUTION: If the air bag readiness light stays on after youstart your vehicle, it means the air bag systemmay not b...

2-58 Voltmeter When your engine is notrunning, but the ignition ison (in the RUN position),this gage shows yourbattery’s state of charge in DC volts. When the engine is running, the gage shows thecondition of the charging system. Readings between the low and high warning zones indicate the normalope...

2-59 Brake System Warning Light When the ignition is on, the brake system warning lightwill come on when you set your parking brake. The lightwill stay on if your parking brake doesn’t release fully.If it stays on after your parking brake is fully released, it means you have a brake problem. Your ve...

2-61 Malfunction Indicator Lamp (ServiceEngine Soon Light in the United States or Check Engine Light in Canada) (4.3L, 5.0L & 5.7L Engines and 8.1L California Gasoline Engine) United States Canada Your vehicle is equipped with a computer whichmonitors operation of the fuel, ignition and emission...

2-62 NOTICE: Modifications made to the engine, transmission,exhaust, intake or fuel system of your vehicle orthe replacement of the original tires with otherthan those of the same Tire Performance Criteria(TPC) can affect your vehicle’s emission controlsand may cause the SERVICE ENGINE SOON orCHECK ...

2-63 If the Light Is Flashing The following may prevent more serious damage toyour vehicle:D Reducing vehicle speed.D Avoiding hard accelerations.D Avoiding steep uphill grades.D If you are towing a trailer, reduce the amount of cargo being hauled as soon as it is possible. If the light stops flashi...

2-64 Have you recently changed brands of fuel? If so, be sure to fuel your vehicle with quality fuel. See “Fuel” in the Index. Poor fuel quality will causeyour engine not to run as efficiently as designed. You may notice this as stalling after start - up, stalling when you put the vehicle into gear,...

2-65 Malfunction Indicator Lamp (ServiceEngine Soon Light) (Check Engine Light)(8.1L Gasoline Engine -- Except California) United States Canada If this light comes on or flashes while you are driving,two things may happen. First, you won’t notice any difference in engineperformance, but your tail pi...

2-66 Oil Pressure Gage The oil pressure gage showsthe engine oil pressure inpsi (pounds per square inch)when the engine is running. Canadian vehicles indicate pressure in kPa (kilopascals). Oil pressure may vary with engine speed, outsidetemperature and oil viscosity, but readings above thelow press...

2-67 Security Light This light will come onbriefly when you turn theignition key to START. The light will stay on until the engine starts. If the lightflashes, the Passlock R System has entered a tamper mode. If the vehicle fails to start, see “Passlock” in the Index. If the light comes on continuou...

2-68 Fuel Gage United States Canada The fuel gage, when the ignition is on, tells you abouthow much fuel you have left in your tank. The gage will first indicate empty before you are out offuel, and you should get more fuel as soon as possible. Listed are four situations you may experience with your...

3-2 Comfort Controls This section tells you how to make your air system workfor you. With these systems, you can control the heating, coolingand ventilation in your vehicle. System Controls If your vehicle does not have air conditioning, yourcontrols will look like this. Fan Knob The knob on the lef...

3-3 Mode Knob The right knob changes the airflow setting. (Vent): This setting directs air through the instrument panel vents. (Bi - Level): This setting divides airflow between the heater floor vents and instrument panel vents. (Floor): This setting directs air through the floor vents. (Floor/Defog...

3-4 Fan Knob The knob on the left side of the control panel regulatesthe fan speed. The knob has four speed positions. Toincrease airflow, turn the knob toward HI. To decreaseairflow, turn it toward LO. To turn the fan off, turn themode knob on the far right to OFF. Temperature Knob The middle knob ...

3-5 Rear Heater (Without Air Conditioning) (If Equipped) If you have a rear heater (without rear air conditioning),the thumbwheel for this feature is located on theinstrument panel. To increase and decrease the flow of heated air to therear floor vents, turn the thumbwheel marked HEAT tothe desired ...

3-6 For warmer air, turn the knob toward the red area, andfor cooler air, turn the knob toward the blue area. To regulate the location of the airflow, adjust the centerknob on the control panel. Turn the knobcounterclockwise for upper vent airflow or clockwisefor headliner vent air flow. Generally, ...

3-7 Air Conditioning Before using your vehicle’s air conditioning, open thewindows to clear the vehicle of hot air. This reduces thetime it takes for your vehicle to cool down. Then keepyour windows closed for the air conditioner to work atits best. You can use MAX A/C with the temperature knob in t...

3-9 Ventilation System For mild outside temperatures when little heating or coolingis needed, use vent to direct outside air through your vehicle.Air will flow through the instrument panel vents. Your vehicle’s flow - through ventilation system supplies outside air to the inside of your vehicle when...

3-10 Ventilation Tips D Keep the hood and front air inlet free of ice, snow, or any other obstruction (such as leaves). The heaterand defroster will work far better, reducing thechance of fogging the inside of your windows. D When you enter a vehicle in cold weather, turn the fan to HI for a few mom...

3-11 Setting the Clock for Systems with RadioData System Your radio may have a button marked with an H or HR to represent hours and an M or MIN to represent minutes. Press and hold the hour button until the correct hourappears. AM or PM will appear on the display formorning or afternoon hours. Press...

3-12 Finding a Station AM FM: Press this button to switch between AM, FM1and FM2. The display shows your selection. TUNE: Turn this knob to tune in radio stations. SEEK SEEK : Press the right or left arrow to seek to the next or previous station and stay there.The radio will seek to stations with a ...

3-14 To adjust balance or fade to the middle position, selectBAL or FAD. Then press and hold AUDIO for morethan two seconds until you hear a beep. L and a zero orF and a zero will appear on the display. To adjust bothtone controls and both speaker controls to the middleposition, end out of audio mod...

3-15 Finding a Station AM FM: Press this button to switch between AM, FM1and FM2. The display shows your selection. TUNE: Turn this knob to choose radio stations. SEEK SEEK : Press the right or left arrow to seek to the next or previous station and stay there.The radio will seek to stations with a s...

3-17 To adjust balance or fade to the middle position, selectBAL or FAD. Then press and hold AUDIO for morethan two seconds until you hear a beep. L and a zero orF and a zero will appear on the display. To adjust bothtone controls and both speaker controls to the middleposition, end out of audio mod...

3-22 Adjusting the Speakers (Balance/Fade) AUDIO: To adjust the balance between the right andleft speakers, press and release AUDIO until BALappears on the display. Then press and hold the up arrowto move the sound to the right speakers or the downarrow to move the sound to the left speakers. R and ...

3-24 Compact Disc Messages If the disc comes out, it could be for one of thefollowing reasons:D If you’re driving on a very rough road. When the road becomes smooth the disc should play. D If it’s very hot. When the temperature returns to normal, the disc should play. D The disc is upside down.D It ...

3-26 Setting Preset Stations The six numbered pushbuttons let you return to your favorite stations. You can set up to 18 stations(six AM, six FM1 and six FM2) by performing thefollowing steps: 1. Turn the radio on. 2. Press AM FM to select the band. 3. Tune in the desired station. 4. Press AUTO TONE...

3-27 To return the bass and treble to the manual mode, press and release the AUDIO knob. If your vehicle has the Bose radio, your audio systemallows you to choose from four different equalizationsettings: talk, driver, normal and spatial. These settingscan be used while listening to the radio or the...

3-30 INFO (Information): If the current station has amessage, the information icon will appear on thedisplay. These text messages are from the RDSbroadcaster to the listening public and may be generalinformation such as artist and song title, call in phonenumbers, etc. Press this button to see the m...

3-31 Playing a Cassette Tape Your tape player is built to work best with tapes that areup to 30 to 45 minutes long on each side. Tapes longerthan that are so thin they may not work well in thisplayer. The longer side with the tape visible should faceto the right. If the ignition is on, but the radio...

3-32 4 FWD (Forward): Press this pushbutton to advancequickly to another part of the tape. Press this pushbuttonagain to return to playing speed. The radio will play thelast selected station while the tape advances. The stationfrequency and FWD will appear on the display. Youmay select stations duri...

3-33 Cassette Tape Messages CHK TAPE (Check Tape): If CHK TAPE appears onthe radio display, the tape won’t play because of one ofthe following errors.D The tape is tight and the player can’t turn the tape hubs. Remove the tape. Hold the tape with the open end down and try to turn the right hubcounte...

3-37 Setting Preset Stations The six numbered pushbuttons let you return to your favorite stations. You can set up to 18 stations(six AM, six FM1 and six FM2) by performing thefollowing steps: 1. Turn the radio on. 2. Press AM FM to select the band. 3. Tune in the desired station. 4. Press AUTO EQ t...

3-38 Adjusting the Speakers (Balance/Fade) AUDIO: To adjust the balance between the right andleft speakers, push the AUDIO knob until BAL appearson the display. Turn the knob to adjust the sound to theleft or right speakers. The middle position balances thesound between the speakers. To adjust the f...

3-40 RDS Messages ALERT!: This type of announcement warns of nationalor local emergencies. You will not be able to turn offalert announcements. ALERT! appears on the displaywhen an alert announcement plays. When an alertannouncement comes on the current radio station, youwill hear it, even if the vo...

3-42 Playing a Specific Loaded Compact Disc For every CD loaded, a number will appear on the radiodisplay. To play a specific CD, first press the CD AUXbutton to start playing a CD. Then press the numberedpushbutton that corresponds to the CD you want to play.A small bar will appear under the CD num...

3-43 RPT (Repeat): With repeat, you can repeat one track oran entire disc. To use repeat, do the following:D To repeat the track you are listening to, press and release the RPT button. RPT will appear on thedisplay. Press RPT again to turn it off. D To repeat the disc you are listening to, press and...

3-44 P - TYPE (Program Type): Press this knob to see how long the current track has been playing. To change whatis normally shown on the display (track or elapsedtime), press the knob until you see the display you want,then hold the knob until the display flashes. AM FM: Press this button to play th...

3-46 Compact Disc Messages CHECK CD: If this message appears on the radiodisplay, it could be due to one of the following reasons:D The road is too rough. The disc should play when the road is smoother. D The disc is dirty, scratched, wet or upside down.D The air is very humid. If so, wait about an ...

3-47 Understanding Radio Reception AM The range for most AM stations is greater than for FM,especially at night. The longer range, however, cancause stations to interfere with each other. AM can pickup noise from things like storms and power lines. Tryreducing the treble to reduce this noise if you ...

3-48 Care of Your Cassette Tape Player A tape player that is not cleaned regularly can causereduced sound quality, ruined cassettes or a damagedmechanism. Cassette tapes should be stored in theircases away from contaminants, direct sunlight andextreme heat. If they aren’t, they may not operateproper...

4-2 Defensive Driving The best advice anyone can give about driving is: Drive defensively. Please start with a very important safety device in yourvehicle: Buckle up. See “Safety Belts” in the Index. Defensive driving really means “be ready for anything.”On city streets, rural roads or freeways, it ...

4-3 Drunken Driving Death and injury associated with drinking and driving isa national tragedy. It’s the number one contributor to the highway death toll, claiming thousands of victimsevery year. Alcohol affects four things that anyone needs to drive a vehicle:D JudgmentD Muscular CoordinationD Visi...

4-5 But the ability to drive is affected well below a BAC of 0.10 percent. Research shows that the driving skills of many people are impaired at a BAC approaching0.05 percent, and that the effects are worse at night. Alldrivers are impaired at BAC levels above 0.05 percent.Statistics show that the c...

4-9 Remember: Anti - lock doesn’t change the time you need to get your foot up to the brake pedal or always decreasestopping distance. If you get too close to the vehicle infront of you, you won’t have time to apply your brakesif that vehicle suddenly slows or stops. Always leaveenough room up ahead...

4-10 The traction you can get in a curve depends on thecondition of your tires and the road surface, the angle at which the curve is banked, and your speed. Whileyou’re in a curve, speed is the one factor you can control. Suppose you’re steering through a sharp curve. Then you suddenly accelerate. B...

4-11 An emergency like this requires close attention and aquick decision. If you are holding the steering wheel atthe recommended 9 and 3 o’clock positions, you canturn it a full 180 degrees very quickly without removingeither hand. But you have to act fast, steer quickly, andjust as quickly straigh...

4-12 Passing The driver of a vehicle about to pass another on atwo - lane highway waits for just the right moment, accelerates, moves around the vehicle ahead, then goesback into the right lane again. A simple maneuver? Not necessarily! Passing another vehicle on a two - lane highway is a potentiall...

4-13 D Check your mirrors, glance over your shoulder and start your left lane change signal before moving outof the right lane to pass. When you are far enoughahead of the passed vehicle to see its front in yourinside mirror, activate your right lane change signaland move back into the right lane. (...

4-14 If your vehicle starts to slide, ease your foot off theaccelerator pedal and quickly steer the way you want the vehicle to go. If you start steering quickly enough,your vehicle may straighten out. Always be ready for asecond skid if it occurs. Of course, traction is reduced when water, snow, ic...

4-16 Driving in Rain and on Wet Roads Rain and wet roads can mean driving trouble. On a wetroad, you can’t stop, accelerate or turn as well becauseyour tire - to - road traction isn’t as good as on dry roads. And, if your tires don’t have much tread left, you’ll geteven less traction. It’s always wi...

4-17 Driving too fast through large water puddles or evengoing through some car washes can cause problems, too.The water may affect your brakes. Try to avoid puddles.But if you can’t, try to slow down before you hit them. CAUTION: Wet brakes can cause accidents. They won’t workas well in a quick sto...

4-18 Hydroplaning doesn’t happen often. But it can if yourtires do not have much tread or if the pressure in one ormore is low. It can happen if a lot of water is standing onthe road. If you can see reflections from trees, telephonepoles or other vehicles, and raindrops “dimple” thewater’s surface, ...

4-19 City Driving One of the biggest problems with city streets is theamount of traffic on them. You’ll want to watch out forwhat the other drivers are doing and pay attention totraffic signals. Here are ways to increase your safety in city driving:D Know the best way to get to where you are going. ...

4-20 Freeway Driving Mile for mile, freeways (also called thruways, parkways,expressways, turnpikes or superhighways) are the safestof all roads. But they have their own special rules. The most important advice on freeway driving is: Keepup with traffic and keep to the right. Drive at the samespeed ...

4-21 The exit speed is usually posted. Reduce your speed according to your speedometer, notto your sense of motion. After driving for any distanceat higher speeds, you may tend to think you are goingslower than you actually are. Before Leaving on a Long Trip Make sure you’re ready. Try to be well re...

4-22 Highway Hypnosis Is there actually such a condition as “highway hypnosis”?Or is it just plain falling asleep at the wheel? Call ithighway hypnosis, lack of awareness, or whatever. There is something about an easy stretch of road withthe same scenery, along with the hum of the tires on theroad, ...

4-24 Winter Driving Here are some tips for winter driving:D Have your vehicle in good shape for winter.D You may want to put winter emergency supplies in your vehicle. Include an ice scraper, a small brush or broom, a supplyof windshield washer fluid, a rag, some winter outerclothing, a small shovel...

4-26 If You’re Caught in a Blizzard If you are stopped by heavy snow, you could be in aserious situation. You should probably stay with yourvehicle unless you know for sure that you are near helpand you can hike through the snow. Here are somethings to do to summon help and keep yourself and your pa...

4-27 CAUTION: Snow can trap exhaust gases under your vehicle.This can cause deadly CO (carbon monoxide) gasto get inside. CO could overcome you and killyou. You can’t see it or smell it, so you might notknow it is in your vehicle. Clear away snow fromaround the base of your vehicle, especially anyth...

4-28 Loading Your Vehicle The Certification/Tire label is found on the rear edge ofthe driver’s door. The label shows the size of youroriginal tires and the inflation pressures needed to obtainthe gross weight capacity of your vehicle. This is calledGross Vehicle Weight Rating (GVWR). The GVWRinclud...

4-29 CAUTION: Things you put inside your vehicle can strike and injure people in a sudden stop or turn, or in a crash.D Put things in the cargo area of your vehicle. Try to spread the weight evenly. D Never stack heavier things, like suitcases, inside the vehicle so that some of them areabove the to...

4-30 Trailering Package If your vehicle is equipped with the trailering package,there is also a load rating which includes the weight ofthe vehicle and the trailer it tows. This rating is calledthe Gross Combination Weight Rating (GCWR). When you weigh your trailer, be sure to include theweight of e...

4-31 NOTICE: Pulling a trailer improperly can damage yourvehicle and result in costly repairs not covered byyour warranty. To pull a trailer correctly, followthe advice in this part, and see your dealer forimportant information about towing a trailerwith your vehicle. Additional rear axlemaintenance...

4-32 If You Do Decide To Pull A Trailer If you do, here are some important points:D There are many different laws, including speed limit restrictions, having to do with trailering. Make sureyour rig will be legal, not only where you live butalso where you’ll be driving. A good source for thisinforma...

4-35 Maximum trailer weight is calculated assuming thedriver and one passenger are in the towing vehicle and it has all the required trailering equipment. The weightof additional equipment, passengers and cargo in thetowing vehicle must be subtracted from the abovemaximum trailer weights. You can as...

4-36 Total Weight on Your Vehicle’s Tires Be sure your vehicle’s tires are inflated to the upperlimit for cold tires. You’ll find these numbers on theCertification label at the rear edge of the driver’s door orsee “Loading Your Vehicle” in the Index. Then be sureyou don’t go over the GVW limit for y...

4-37 Safety Chains You should always attach chains between your vehicleand your trailer. Cross the safety chains under the tongueof the trailer to help prevent the tongue from contactingthe road if it becomes separated from the hitch.Instructions about safety chains may be provided by the hitch manu...

4-38 Driving with a Trailer CAUTION: If you have a rear - most window open and you pull a trailer with your vehicle, carbon monoxide(CO) could come into your vehicle. You can’t seeor smell CO. It can cause unconsciousness ordeath. See “Engine Exhaust” in the Index. To maximize your safety when towin...

4-40 Turn Signals When Towing a Trailer When you tow a trailer, your vehicle has to have extrawiring and a heavy - duty turn signal flasher (included in the optional trailering package). The arrows on your instrument panel will flashwhenever you signal a turn or lane change. Properlyhooked up, the t...

4-42 Trailer Wiring Harness The optional heavy - duty trailer wiring package is a seven - wire harness assembly. The four - wire portion of the harness assembly is stored under the vehicle, alongthe driver’s side rear corner of the frame rail. Thethree - wire portion of the harness assembly is store...

5-3 Jump Starting If your battery has run down, you may want to useanother vehicle and some jumper cables to start yourvehicle. Be sure to follow the steps below to do it safely. CAUTION: Batteries can hurt you. They can be dangerous because:D They contain acid that can burn you. D They contain gas ...

5-5 4. Open the hoods and locate the batteries. Find the positive (+) and negative ( - ) terminal locations on each vehicle. You should always use the remotenegative ( - ) jump starting terminal provided instead of any other engine or body part for theground connection. CAUTION: Using a match near a...

5-9 Jumper Cable Removal A. Heavy, Unpainted Metal Engine Part or Remote Negative ( - ) Terminal B. Good Battery or Remote Positive (+) and Remote Negative ( - ) Terminals C. Dead Battery or Remote Positive (+) Terminal To disconnect the jumper cables from both vehicles, do the following: 1. Disconn...

5-10 Engine Overheating (Gasoline Engine) You will find a coolant temperature gage on yourvehicle’s instrument panel. If you have a diesel engine, you will also find a low coolant light on yourinstrument panel. If your vehicle has a diesel engine, see “EngineOverheating” in the Diesel Engine Supplem...

5-11 CAUTION: Steam from an overheated engine can burn youbadly, even if you just open the hood. Stay awayfrom the engine if you see or hear steam comingfrom it. Just turn it off and get everyone awayfrom the vehicle until it cools down. Wait untilthere is no sign of steam or coolant before youopen ...

5-17 How to Add Coolant to the Radiator 1. You can remove the radiator pressure cap when the cooling system, including the radiator pressure capand upper radiator hose, is no longer hot. Turn thepressure cap slowly counterclockwise until it firststops. (Don’t press down while turning the pressure ca...

5-20 Engine Fan Noise Your vehicle has a clutched engine cooling fan. Whenthe clutch is engaged, the fan spins faster to providemore air to cool the engine. In most everyday drivingconditions, the fan is spinning slower and the clutch isnot fully engaged. This improves fuel economy andreduces fan no...

5-21 Changing a Flat Tire If a tire goes flat, avoid further tire and wheel damageby driving slowly to a level place. Turn on your hazardwarning flashers. CAUTION: Changing a tire can cause an injury. The vehiclecan slip off the jack and roll over you or otherpeople. You and they could be badly inju...

5-22 Removing the Spare Tire and Tools Your spare tire is stored underneath the rear of yourvehicle. You will use the ratchet and extension to lowerthe spare tire. A flat rear tire reduces clearance to remove the sparetire. If there is less than 12 inches (30.48 cm) betweenthe ground and the rear bu...

5-24 The ratchet has a DOWN side and an UP side. Attach the ratchet, with the DOWN side facing you, tothe extension. The extension has a socket end and a flatchisel end. Put the flat end of the extension on an angle through thehole in the rear door frame, above the bumper. Be surethe flat end connec...

5-25 When the tire has been lowered, tilt the retainer at theend of the cable and pull it through the wheel opening. NOTICE: To help avoid vehicle damage, do not drive thevehicle before the cable is restored. Jacking Tool Storage A. Socket B. Jack Handle C. Ratchet D. Jacking Tool Storage Box E. Jac...

5-26 The tools you’ll be using include the jack (A), jackhandle extension (B), jack handle (C), socket (D) andthe ratchet (E). Removing the Wheel Covers and LockingWheel Nuts 1. You will need to take off the wheel nut caps to reach your wheel nuts. When using the ratchet and socket,make sure the DOW...

5-30 CAUTION: Raising your vehicle with the jack improperlypositioned can damage the vehicle and even make the vehicle fall. To help avoid personalinjury and vehicle damage, be sure to fit the jacklift head into the proper location before raisingthe vehicle. 5. Raise the vehicle by turning the ratch...

5-33 11. Put the wheel cover back on, or put the center cap and plastic wheel nut caps back on. Remove anywheel blocks. Remember that the jack, jacking equipment and tiremust be properly stored in their original storage positionbefore you begin driving again. The next part will showyou how. Storing ...

5-36 If You’re Stuck: In Sand, Mud, Ice or Snow In order to free your vehicle when it is stuck, you willneed to spin the wheels, but you don’t want to spin your wheels too fast. The method known as “rocking”can help you get out when you’re stuck, but you mustuse caution. CAUTION: If you let your tir...

6-2 Service Your dealer knows your vehicle best and wants you tobe happy with it. We hope you’ll go to your dealer forall your service needs. You’ll get genuine GM parts andGM - trained and supported service people. We hope you’ll want to keep your GM vehicle all GM.Genuine GM parts have one of thes...

6-3 CAUTION: You can be injured and your vehicle could bedamaged if you try to do service work on avehicle without knowing enough about it.D Be sure you have sufficient knowledge, experience, the proper replacement partsand tools before you attempt any vehiclemaintenance task. D Be sure to use the p...

6-4 In Canada, look for the “Auto Makers’Choice” label on the pump. Canada Only California Fuel If your vehicle is certified to meet California EmissionStandards (see the underhood emission control label), it isdesigned to operate on fuels that meet Californiaspecifications. If this fuel is not avai...

6-7 When you put the fuel cap back on, turn it to the right(clockwise) until you hear a clicking sound. Make sureyou fully install the cap. The diagnostic system candetermine if the fuel cap has been left off or improperlyinstalled. This would allow fuel to evaporate into theatmosphere. See “Malfunc...

6-8 Checking Things Under the Hood CAUTION: If your vehicle has air conditioning, the auxiliaryengine fan under the hood can start up andinjure you even when the engine is not running.Keep hands, clothing and tools away from anyunderhood electric fan. CAUTION: Things that burn can get on hot engine ...

6-10 Engine Compartment Overview When you lift the hood, you’ll see these items: A. BatteryB. Coolant Recovery TankC. Engine Oil Dipstick D. Engine Oil FillE. Transmission Fluid DipstickF. Engine Air Cleaner/Filter G. Power Steering ReservoirH. Brake Master CylinderI. Windshield Washer Fluid

6-11 Before closing the hood, be sure all the filler caps are on properly. Then lift the hood to relieve pressure on the hood prop.Remove the hood prop from the slot in the hood andreturn the prop to its retainer. Then let the hood downand close it firmly. Noise Control System The following informat...

6-12 Engine:D Removal or rendering engine speed governor (if equipped) inoperative so as to allow engine speed to exceed manufacturer specifications. Fan and Drive:D Removal of fan clutch (if equipped) or rendering clutch inoperative. D Removal of the fan shroud (if equipped).Air Intake:D Removal of...

6-13 Pull out the dipstick and clean it with a paper towel orcloth, then push it back in all the way. Remove it again,keeping the tip down, and check the level. When to Add Engine Oil If the oil is at or below the ADD mark, then you’ll needto add at least one quart of oil. But you must use theright ...

6-14 What Kind of Engine Oil to Use Oils recommended for your vehicle can be identified bylooking for the starburst symbol. This symbol indicates that the oil has been certified bythe American Petroleum Institute (API). Do not use anyoil which does not carry this starburst symbol. If you change your...

6-15 As in the chart shown previously, SAE 5W - 30 is best for your vehicle. However, you can use SAE 10W - 30 if it’s going to be 0 _F ( - 18 _C) or above. These numbers on an oil container show its viscosity, or thickness. Do not useother viscosity oils, such as SAE 20W - 50. NOTICE: Use only engi...

6-16 When to Change Engine Oil If any one of these is true for you, use the short trip/citymaintenance schedule:D Most trips are less than 5 miles (8 km). This is particularly important when outside temperatures arebelow freezing. D Most trips include extensive idling (such as frequent driving in st...

6-19 Automatic Transmission Fluid If your vehicle has a diesel engine, see “AutomaticTransmission Fluid” in the Diesel Supplement. When to Check and Change A good time to check your automatic transmission fluidlevel is when the engine oil is changed. Change both the fluid and filter every 50,000 mil...

6-20 To get the right reading, the fluid should be at normal operating temperature, which is 180 _F to 200 _F (82_C to 93_C). Get the vehicle warmed up by driving about 15 miles(24 km) when outside temperatures are above 50 _F (10 _C). If it’s colder than 50_F (10_C), drive the vehicle in DRIVE (D) ...

6-22 How to Add Fluid Refer to the Maintenance Schedule to determine whatkind of transmission fluid to use. See “RecommendedFluids and Lubricants” in the Index. Add fluid only after checking the transmission fluidwhile it is hot. (A cold check is used only as areference.) If the fluid level is low, ...

6-23 Rear Axle When to Check Lubricant Refer to the Maintenance Schedule to determine howoften to check the lubricant. See “ScheduledMaintenance Services” in the Index. How to Check Lubricant To get an accuratereading, the vehicleshould be on a level surface. If the level is below the bottom of the ...

6-24 A 50/50 mixture of clean, drinkable water andDEX - COOL R coolant will: D Give freezing protection down to - 34 _F ( - 37 _C). D Give boiling protection up to 265_F (129_C).D Protect against rust and corrosion.D Help keep the proper engine temperature.D Let the warning lights and gages work as ...

6-25 NOTICE: If you use an improper coolant mixture, yourengine could overheat and be badly damaged.The repair cost wouldn’t be covered by yourwarranty. Too much water in the mixture canfreeze and crack the engine, radiator, heater coreand other parts. If you have to add coolant more than four times...

6-26 Adding Coolant If you need more coolant, add the proper DEX - COOL R coolant mixture at the coolant recovery tank. CAUTION: Turning the radiator pressure cap when theengine and radiator are hot can allow steam and scalding liquids to blow out and burn youbadly. With the coolant recovery tank, y...

6-27 Radiator Pressure Cap The radiator pressure cap islocated near the center ofthe engine compartment. NOTICE: Your radiator cap is a pressure - type cap and must be tightly installed to prevent coolant lossand possible engine damage from overheating. Be sure the arrows on the cap line up with the...

6-28 When to Check Power Steering Fluid It is not necessary to regularly check power steeringfluid unless you suspect there is a leak in the system oryou hear an unusual noise. A fluid loss in this systemcould indicate a problem. Have the system inspected and repaired. How to Check Power Steering Fl...

6-29 NOTICE: D When using concentrated washer fluid, follow the manufacturer’s instructions foradding water. D Don’t mix water with ready - to - use washer fluid. Water can cause the solution to freezeand damage your washer fluid tank andother parts of the washer system. Also,water doesn’t clean as ...

6-30 The other reason is that fluid is leaking out of the brakesystem. If it is, you should have your brake system fixed,since a leak means that sooner or later your brakes won’twork well, or won’t work at all. So, it isn’t a good idea to “top off” your brake fluid.Adding brake fluid won’t correct a...

6-31 What to Add When you do need brake fluid, use only DOT - 3 brake fluid. Refer to “Recommended Fluids and Lubricants”in the Index. Use new brake fluid from a sealedcontainer only. Always clean the brake fluid reservoir cap and the areaaround the cap before removing it. This will help keepdirt fr...

6-32 Brake Wear Your vehicle has front disc brakes and rear drum brakes. Disc brake pads have built - in wear indicators that make a high - pitched warning sound when the brake pads are worn and new pads are needed. The sound maycome and go or be heard all the time your vehicle ismoving (except when...

6-33 Brake Pedal Travel See your dealer if the brake pedal does not return tonormal height, or if there is a rapid increase in pedaltravel. This could be a sign of brake trouble. Brake Adjustment Every time you make a brake stop, your disc brakesadjust for wear. If your brake pedal goes down farther...

6-34 Vehicle Storage If you’re not going to drive your vehicle for 25 days or more, remove the black, negative ( - ) cable from the battery. This will help keep your battery fromrunning down. CAUTION: Batteries have acid that can burn you and gasthat can explode. You can be badly hurt if youaren’t c...

6-36 4. Reinstall the new bulb into the socket and return it to the headlamp assembly. Front Parking/Turn Signal Lamps To replace the front parking/turn signal lamps, do the following: 1. Remove the outer screws from the parking/turn signal lamp lens assembly. (There are either two orfour screws, de...

6-37 2. Remove the lamp from the grille. 3. Squeeze the tab on the side of the bulb assembly while turning it counterclockwise. 4. Remove the bulb assembly from the back of the lens and replace the bulb. 5. Turn the socket clockwise to reinstall it in the lens assembly. Reinstall the screws on the p...

6-38 2. Unclip the bottom of the lamp from the grille. 3. Pull the bulb straight out to remove it. Install the new bulb. 4. Reverse these steps to reinstall the lamp. Taillamps 1. Open the rear door. 2. Push the socket protector until you can see the fasteners.

6-39 3. Remove the nuts with a deep socket wrench. 4. Remove the hidden upper nuts.

6-42 2. Press down on the blade assembly pivot locking tab. Pull down on the blade assembly to release it fromthe wiper arm hook. 3. The insert has two notches at one end that are locked by bottom claws of the blade assembly. At thenotched end, pull the insert from the blade assembly. 4. To install ...

6-43 Inflation -- Tire Pressure The Certification/Tire label, which is on the rear edge ofthe driver’s door, shows the correct inflation pressuresfor your tires when they’re cold. “Cold” means yourvehicle has been sitting for at least three hours or drivenno more than 1 mile (1.6 km). NOTICE: Don’t ...

6-44 How to Check Use a good quality pocket - type gage to check tire pressure. You can’t tell if your tires are properly inflatedsimply by looking at them. Radial tires may lookproperly inflated even when they’re underinflated. Be sure to put the valve caps back on the valve stems. They help preven...

6-46 When It’s Time for New Tires One way to tell when it’stime for new tires is tocheck the treadwearindicators, which willappear when your tires haveonly 1/16 inch (1.6 mm) orless of tread remaining.Some commercial trucktires may not havetreadwear indicators. You need a new tire if any of the foll...

6-47 Buying New Tires To find out what kind and size of tires you need, look atthe Certification/Tire label. The tires installed on your vehicle when it was new hada Tire Performance Criteria Specification (TPC Spec)number on each tire’s sidewall. When you get new tires,get ones with that same TPC S...

6-48 Uniform Tire Quality Grading Quality grades can be found where applicable on the tiresidewall between tread shoulder and maximum sectionwidth. For example: Treadwear 200 Traction AA Temperature A The following information relates to the systemdeveloped by the United States National HighwayTraff...

6-49 Temperature -- A, B, C The temperature grades are A (the highest), B, and C,representing the tire’s resistance to the generation ofheat and its ability to dissipate heat when tested undercontrolled conditions on a specified indoor laboratorytest wheel. Sustained high temperature can cause thema...

6-50 Wheel Replacement Replace any wheel that is bent, cracked, or badly rustedor corroded. If wheel nuts keep coming loose, the wheel,wheel bolts and wheel nuts should be replaced. If thewheel leaks air, replace it (except some aluminumwheels, which can sometimes be repaired). See yourdealer if any...

6-51 Whenever a wheel, wheel bolt or wheel nut is replacedon a dual wheel setup, check the wheel nut torque after100, 1,000 and 6,000 miles (160, 1 600 and 10 000 km)of driving. For proper torque, see “Wheel Nut Torque”in the Index. See “Changing a Flat Tire” in the Index for more information. Used ...

6-52 Appearance Care Remember, cleaning products can be hazardous. Someare toxic. Others can burst into flame if you strike amatch or get them on a hot part of the vehicle. Some aredangerous if you breathe their fumes in a closed space.When you use anything from a container to clean yourvehicle, be ...

6-53 Here are some cleaning tips:D Always read the instructions on the cleaner label.D Clean up stains as soon as you can -- before they set. D Carefully scrape off any excess stain.D Use a clean cloth or sponge, and change to a clean area often. A soft brush may be used if stains are stubborn. D If...

6-54 Cleaning Vinyl Use warm water and a clean cloth.D Rub with a clean, damp cloth to remove dirt. You may have to do it more than once. D Things like tar, asphalt and shoe polish will stain if you don’t get them off quickly. Use a clean clothand a vinyl/leather cleaner. See your dealer for this pr...

6-55 Cleaning Glass Surfaces Glass should be cleaned often. GM Glass Cleaner or aliquid household glass cleaner will remove normaltobacco smoke and dust films on interior glass. See“Appearance Care and Materials” in the Index. NOTICE: Don’t use abrasive cleaners on glass, because theymay cause scrat...

6-56 Cleaning the Outside of Your Vehicle The paint finish on your vehicle provides beauty, depthof color, gloss retention and durability. Washing Your Vehicle The best way to preserve your vehicle’s finish is to keep it clean by washing it often with lukewarm or cold water. Don’t wash your vehicle ...

6-57 Foreign materials such as calcium chloride and othersalts, ice melting agents, road oil and tar, tree sap, birddroppings, chemicals from industrial chimneys, etc., candamage your vehicle’s finish if they remain on paintedsurfaces. Wash the vehicle as soon as possible. Ifnecessary, use non - abr...

6-58 Cleaning Tires To clean your tires, use a stiff brush with a tire cleaner. NOTICE: When applying a tire dressing always take care towipe off any overspray or splash from all paintedsurfaces on the body or wheels of the vehicle.Petroleum - based products may damage the paint finish and tires. Sh...

6-59 Underbody Maintenance Chemicals used for ice and snow removal and dustcontrol can collect on the underbody. If these are notremoved, accelerated corrosion (rust) can occur on the underbody parts such as fuel lines, frame, floor pan and exhaust system even though they have corrosion protection. ...

6-61 Vehicle Identification Number (VIN) This is the legal identifier for your vehicle. It appears ona plate in the front corner of the instrument panel, on thedriver’s side. You can see it if you look through thewindshield from outside your vehicle. The VIN alsoappears on the Vehicle Certification ...

6-62 Electrical System Add-On Electrical Equipment NOTICE: Don’t add anything electrical to your vehicleunless you check with your dealer first. Someelectrical equipment can damage your vehicleand the damage wouldn’t be covered by yourwarranty. Some add - on electrical equipment can keep other compo...

6-63 Instrument Panel Fuse Block The fuse block access dooris on the instrument panelabove the hood release lever on the driver’s side of the vehicle. You can remove the cover by turning the fastener counterclockwise. You can remove fuses with a fuse extractor. The fuseextractor is mounted to the fu...

6-66 Engine Compartment Fuse Block The fuse block is in the engine compartment on thedriver’s side of the vehicle. NAME CIRCUITS PROTECTED SPARE Spare Fuse A.I.R. Air Pump BLOWER Front Blower Motor ABS Electronic Brake Control Module IGN B Ignition Switch IGN A Starter Relay, Ignition Switch BATT In...

6-68 Replacement Bulbs LAMP OR BULB QTY NUMBER Sealed Beam Headlamps 2 H6054 Composite Low - Beam Headlamps 2 6052 Composite High - Beam Headlamps 2 9005 Front Sidemarker Lamp 2 194 Front Parking and Turn Lamp 4 2357NA Rear Parking Lamp 2 3057 Rear Stop and Turn Lamp 2 3057 Back - up Lamp 2 3156 Bac...

6-69 Capacities and Specifications All capacities are approximate. When adding, be sure to fill to the appropriate level or as recommended in this manual. See refrigerant charge label under the hood for charge capacity information and requirements. Engine Identification -- Gasoline Engines Engine “V...

6-70 Wheel Nut Torque MODEL TORQUE All 140 lb - ft (190 N·m) Cooling System Capacity ENGINE VIN QTY Without Rear Heater QTY With Rear Heater “VORTEC” 4300 V6 W 11.0 quarts (10.4 L) 14.0 quarts (13.2 L) “VORTEC” 5000 V8 M 17.0 quarts (16.0 L) 20.0 quarts (18.9 L) “VORTEC” 5700 V8 R 17.0 quarts (16.0 ...

6-71 Fuel Tank Capacity TYPE QUANTITY MODEL TYPE Standard Tank 31.0 U.S. gallons (117.3 L) Passenger and Cargo Standard Tank 35.0 U.S. gallons (132.5 L) Cab and Chassis Optional Tank* 55.0 U.S. gallons (208.1 L) Cab and Chassis *159 inch wheelbase or 177 inch wheelbase only Air Conditioning Refriger...

6-72 Normal Maintenance Replacement Parts Replacement Parts Replacement part numbers listed in this section are based on the latest information available at the time of printing,and are subject to change. If a part listed in this manual is not the same as the part used in your vehicle when it wasbui...

7-2 Have you purchased the GM Protection Plan? The Plansupplements your new vehicle warranties. See yourWarranty and Owner Assistance booklet or your dealerfor details. Introduction Your Vehicle and the Environment Proper vehicle maintenance not only helps to keep yourvehicle in good working conditi...

7-3 How This Section is Organized This maintenance schedule is divided into five parts: “Part A: Scheduled Maintenance Services” explainswhat to have done and how often. Some of theseservices can be complex, so unless you are technicallyqualified and have the necessary equipment, you shouldlet your ...

7-4 Part A: Scheduled Maintenance Services Using Your Maintenance Schedule We at General Motors want to help you keep yourvehicle in good working condition. But we don’t knowexactly how you’ll drive it. You may drive very shortdistances only a few times a week. Or you may drivelong distances all the...

Scheduled Maintenance 7-5 Short Trip/City Definition Follow the Short Trip/City Scheduled Maintenance ifany one of these conditions is true for your vehicle:D Most trips are less than 5 miles (8 km). This is particularly important when outside temperatures are below freezing. D Most trips include ex...

Scheduled Maintenance 7-6 Short Trip/City Intervals Every 24,000 Miles (40 000 km): Diesel Engine Only: Fuel Cap Replacement, if driving in dusty conditions. Every 30,000 Miles (50 000 km): Diesel Engine Only: Engine Air Cleaner Filter Replacement. Fuel Filter Replacement. Every 50,000 Miles (83 000...

Scheduled Maintenance 7-7 Long Trip/Highway Definition Follow this scheduled maintenance only if none of the conditions from the Short Trip/City ScheduledMaintenance are true. Do not use this schedule if thevehicle is used for trailer towing, driven in a dusty area or used off paved roads. Use the S...

Scheduled Maintenance 7-8 Long Trip/Highway Intervals Every 30,000 Miles (50 000 km): Fuel Filter Replacement. Diesel Engine Only: Engine AirCleaner Filter Replacement. Front Wheel BearingRepack (or at each brake relining, whichever occurs first). Every 50,000 Miles (83 000 km): Automatic Transmissi...

Short Trip/City Scheduled Maintenance 7-9 The services shown in this schedule up to 100,000 miles(166 000 km) should be repeated after 100,000 miles(166 000 km) at the same intervals for the life of this vehicle. The services shown at 150,000 miles(240 000 km) should be repeated at the same interval...

Short Trip/City Scheduled Maintenance 7-10 3,000 Miles (5 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. j Lubricate chassis components (or every 3 months, whichever occurs first). (See footnote #.) j Check axle fluid level and add fl...

Short Trip/City Scheduled Maintenance 7-13 j Diesel Engine Only: Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and othercomponents are tight. Also check to be sure that the air cleaner housing isproperly seated and the co...

Short Trip/City Scheduled Maintenance 7-16 30,000 Miles (50 000 km) (Continued) j Diesel Engine Only: Replace engine air cleaner filter. An Emission Control Service.Gasoline Engine Only: See “Engine Air Cleaner Filter Restriction IndicatorCheck” in the Index. j Vehicles With GVWR Above 10,000 lbs. o...

Short Trip/City Scheduled Maintenance 7-23 j Gasoline Engine Only: Conduct evaporative control system inspection. Check all fuel and vapor lines and hoses for proper hook - up, routing and condition. Check that the purge valve works properly (if equipped). Replace as needed.An Emission Control Servi...

Short Trip/City Scheduled Maintenance 7-26 75,000 Miles (125 000 km) (Continued) j Diesel Engine Only: Inspect engine air cleaner filter if you are driving in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote [.) Gasoline Engine Only: See “Engine Air Cleaner F...

Short Trip/City Scheduled Maintenance 7-32 100,000 Miles (166 000 km) j Gasoline Engine Only: Inspect spark plug wires. An Emission Control Service. j Gasoline Engine Only: Replace spark plugs. An Emission Control Service. j Change automatic transmission fluid and filter if the vehicle has a diesel ...

Long Trip/Highway Scheduled Maintenance 7-33 The services shown in this schedule up to 100,000 miles(166 000 km) should be repeated after 100,000 miles(166 000 km) at the same intervals for the life of this vehicle. The services shown at 150,000 miles(240 000 km) should be repeated at the same inter...

Long Trip/Highway Scheduled Maintenance 7-35 j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.) j Diesel Engine Only: Check the air intake system installation to assure that gaskets are properly sealed and that al...

Long Trip/Highway Scheduled Maintenance 7-41 j Gasoline Engine Only: Inspect Evaporative Control System. Check all fuel and vapor lines and hoses for proper hook - up, routing and condition. Check that the purge valve works properly, if equipped. Replace as needed. An Emission Control Service. (See ...

Long Trip/Highway Scheduled Maintenance 7-46 100,000 Miles (166 000 km) j Gasoline Engine Only: Inspect spark plug wires. An Emission Control Service. j Gasoline Engine Only: Replace spark plugs. An Emission Control Service. j Change automatic transmission fluid and filter if the vehicle has a diese...

7-48 Part B: Owner Checks and Services Listed in this part are owner checks and services whichshould be performed at the intervals specified to helpensure the safety, dependability and emission controlperformance of your vehicle. Be sure any necessary repairs are completed at once.Whenever any fluid...

7-49 At Least Twice a Year Restraint System Check Make sure the safety belt reminder light and all yourbelts, buckles, latch plates, retractors and anchorages areworking properly. Look for any other loose or damagedsafety belt system parts. If you see anything that mightkeep a safety belt system fro...

7-50 Weatherstrip Lubrication Silicone grease on weatherstrips will make them lastlonger, seal better, and not stick or squeak. Applysilicone grease with a clean cloth. During very cold,damp weather more frequent application may berequired. See “Recommended Fluids and Lubricants” in the Index. Autom...

7-51 Starter Switch Check CAUTION: When you are doing this check, the vehicle couldmove suddenly. If it does, you or others could beinjured. Follow the steps below. 1. Before you start, be sure you have enough room around the vehicle. 2. Firmly apply both the parking brake and the regular brake. See...

7-52 Ignition Transmission Lock Check While parked, and with the parking brake set, try to turnthe ignition key to LOCK in each shift lever position.D The key should turn to LOCK only when the shift lever is in PARK (P). D The key should come out only in LOCK. Parking Brake and Automatic Transmissio...

7-53 Part C: Periodic Maintenance Inspections Listed in this part are inspections and services whichshould be performed at least twice a year (for instance,each spring and fall). You should let your dealer’sservice department or other qualified service center do these jobs. Make sure any necessary r...

7-54 Fuel System Inspection Inspect the complete fuel system for damage or leaks. Engine Cooling System Inspection Inspect the hoses and have them replaced if they arecracked, swollen or deteriorated. Inspect all pipes,fittings and clamps; replace as needed. Clean the outsideof the radiator and air ...

7-59 Maintenance Record DATE ODOMETER READING SERVICED BY MAINTENANCE PERFORMED

8-2 Customer Satisfaction Procedure Your satisfaction and goodwill are important to yourdealer and to Chevrolet. Normally, any concerns withthe sales transaction or the operation of your vehicle will be resolved by your dealer’s sales or servicedepartments. Sometimes, however, despite the bestintent...

8-4 You may contact the BBB using the toll - free telephone number or write them at the following address: BBB Auto LineCouncil of Better Business Bureaus, Inc.4200 Wilson BoulevardSuite 800Arlington, VA 22203 - 1804 Telephone: 1 - 800 - 955 - 5100 This program is available in all 50 states and the ...

8-5 Canada General Motors of Canada LimitedCustomer Communication Centre, 163-0051908 Colonel Sam DriveOshawa, Ontario L1H 8P7 1-800-263-3777 (English)1-800-263-7854 (French)1-800-263-3830 (For Text Telephone devices (TTYs))Roadside Assistance: 1-800-268-6800 All Overseas Locations Please contact th...

8-6 Chevrolet Roadside Assistance Program To enhance Chevrolet’s strong commitment to customersatisfaction, Chevrolet is excited to announce theestablishment of the Chevrolet Roadside AssistanceCenter. As the owner of a 2002 Chevrolet, membershipin Roadside Assistance is free. Roadside Assistance is...

8-8 For prompt assistance when calling, please have thefollowing available to give to the advisor:D Vehicle Identification Number (VIN)D License plate numberD Vehicle colorD Vehicle locationD Telephone number where you can be reachedD Vehicle mileageD Description of problem Canadian Roadside Assista...

8-9 If the dealer requests that you simply drop the vehicleoff for service, you are urged to do so as early in thework day as possible to allow for same day repair. Transportation Options Warranty service can generally be completed while youwait. However, if you are unable to wait Chevrolet helpsmin...

8-10 Courtesy Transportation is available only atparticipating dealers and all program options, such asshuttle service, may not be available at every dealer.Please contact your dealer for specific information aboutavailability. All Courtesy Transportation arrangementswill be administered by appropri...

8-11 REPORTING SAFETY DEFECTS TO THE CANADIAN GOVERNMENT If you live in Canada, and you believe that your vehiclehas a safety defect, you should immediately notifyTransport Canada, in addition to notifying GeneralMotors of Canada Limited. You may write to: Transport Canada330 Sparks StreetTower COtt...

8-12 SERVICE PUBLICATIONS ORDERING INFORMATION Service Manuals Service Manuals have the diagnosis and repairinformation on engines, transmission, axle, suspension,brakes, electrical, steering, body, etc. Transmission, Transaxle, Transfer CaseUnit Repair Manual This manual provides information on uni...