Char-Broil 7101366 - Manuals

Page 2 - Indicates an imminently hazardous situation; WARNING; Indicates an potentially hazardous situation; CAUTION; DANGER; CAUTION

2 • 07101366 Installation Safety Precautions • Use Oil-Less Turkey Fryer, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. • Oil-Less Turkey Fryer installation must conform with local codes, or in their absence of local codes, with either the National Fuel Gas Code...

Page 3 - TABLE OF CONTENTS; Do not attempt to repair or alter the; To insure your satisfaction; Call Grill Service Center for Help and Parts; Model Number

TABLE OF CONTENTS For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Grill Service Center. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Safety Sym...

Page 4 - USE AND CARE; LP Cylinder Filling; LP Cylinder Removal, Transport and Storage

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property da...

Page 5 - Connecting Regulator to the LP Cylinder; LP Cylinder Exchange

WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto . (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn LP cy...

Page 6 - Leak Testing Valves, Hose and Regulator; immediately

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...

Page 7 - Keep fuel supply hose away from any heated surfaces.

24” . 3 ft 3 f t. WARNING 07101366 • 7 CAUTION • Putting out grease fires by closing the lid is not possible. This a ppliance is well ventilated for safety reasons. • Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn knobs and LP cylinder off. • Do not le...

Page 9 - VERY IMPORTANT: Burner tube must re-engage over valve; Cleaning the Burner Assembly; Turn gas off at control knob and LP cylinder and

Cleaning the Burner Assembly (Continued) 7. Clean inner burner as recommended below, shown E . We suggest three ways to clean the burner tube. Use the oneeasiest for you. (A) Bend a stiff wire (a light weight coat hanger works well) into a small hook. Run hook through burner tube severaltimes. (B) U...

Page 10 - Food Safety; For more information call: USDA Meat and Poultry Hotline at; How To Tell If Meat Is Cooked Thoroughly; ppliance; Grease Tray; “For Best Results”

10 • 07101366 Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. To keep food safe from harmful bacteria, follow these four basic steps: Clean: Wash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry. Separate: ...

Page 14 - Grease tray

4 • Turn fryer upright on its legs. Push on control knob and ignitor knob (A). • If not already assembled, slide handle springs onto side handles (B). • Attach side handles to fryer body using two #10-24x1/2" screws on each handle (C). Qty: 4 #10-24x1/2" Screw A B C #10-24x1/2" Screw Con...

Page 15 - Cooking Pot

6 • Place cooking pot and roaster basket into fryer body and storage lid on top. • When cooking hang storage lid on handle as shown. Once seasoning is complete, the fryer is now ready for use. We recommend cooking foods on the “Low” setting, until you get familiar with your fryer. NOTE: Before cooki...

Page 17 - continued

Troubleshooting ( continued ) Possible Cause • Rotary knob rotates without clicking. • Sparking between ignitor and electrode. • See “GAS ISSUES:” on previous page. • Match will not reach. • Improper method of match-lighting. • Out of gas. • Excess flow valve tripped. • Vapor lock at coupling nut/LP...

Page 18 - LIMITED WARRANTY

Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the rig...

Page 20 - STOP; Should you encounter a problem with our product; Do not return this product to the store.; WE CAN HELP; GRILL SERVICE CENTER; Oil-Less Turkey Fryer Safety Checklist; Read and understand owners manual.; Thank You for Your Purchase!

© 2007 Char-Broil, LLC Printed in China • Columbus, GA 31902 • STOP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. O...