Char-Broil 4638220 - Manuals

Page 2 - Not for use with LP gas; DANGER

WARNING FOR YOUR SAFETY1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP Tank not connected for use shall not be stored in the vicinity of this or any otherappliance. FOR YOUR SAFETYIf you smell gas:1. Shut off gas to the a...

Page 6 - To prevent scratching, lay grill on packing material to assemble.; laying grill; ON ITS BACK

1 2 0000000000 0000000 This label contains the model and serial number for your grill. Youshould also write this information on page 2 of this manual in the“Warranty Information” box. Remove end of rating label located on yourgrill’s back panel (see parts list to identify)and apply to your warranty ...

Page 7 - Stand grill upside down and; text facing; Arrange briquets as shown below.

1ST 2ND Do not let briquetscover burner port holes. BACK OF GRILL 4 3 BA CK OF GRILL BACK PANEL BACK PANEL 1. Stand grill upside down and attach back panel to legs andbrace with four bolts and nuts. 2. Facing back of grill, depress buttons and snap leg extenderassembly into right legs andwheel assem...

Page 9 - CAUTION

8 7 Qty. 4 1. Install side shelves by sliding shelf tubes over ends of leg tubes. Press firmly so that holes are aligned. Secure with one push-fastener on each leg. 1. Hang grease clip from center of grill bottom. Use an empty soup can to hang from grease clip. (not included) • Failure to install ca...

Page 11 - Connecting Your Grill to the Natural Gas Source; Coat pipe nipple with gas resistant dope. Screw socket onto; • Connection to gas source must be done by a certified; WARNING; • Do not use hard metal piping of any kind to connect this

Connecting Your Grill to the Natural Gas Source 1. Coat pipe nipple with gas resistant dope. Screw socket onto gas manifold at gas source (A). 2. Connect unattached end of natural gas hose to socket. Push sleeve back on socket (B) and insert plug until sleeve snapsforward, locking plug into socket. ...

Page 12 - Leak Testing Valve and Hose; bubbles appear, there is a leak. Turn gas off at; Safety Tips; be attached to grease clip and emptied; For Safe Use of Your Grill and to Avoid; Before Your First Cookout; • Light burners, check to make sure they are lit, close the lid; Never remove opening

WARNING • Do not use grill until leak checked.• If leak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, immediately close LP tank Valve and call LP gas supplier or your fire department! Leak Testing Valve and Hose 1.2. Check to make sure grill is connecte...

Page 13 - Match Lighting; Troubleshooting Section; HIGH; See following pages for specific

Ignitor Lighting s s Do not lean over grill while lighting.Open lid. Do not lean over grill while lighting. Open lid. 1. Turn on gas at gas source. 2. Turn LEFT knob to IGNITE. 3. Push IGNITOR Button rapidly to light. Be sure burner lights and stays lit. 4. If burner does not light turn knob(s) to O...

Page 14 - Cleaning the Burner Assembly; Turn gas off at control knobs and gas source.

Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill. 1.2. Remove cooking grate and drip vaporiser bar. 3. Discard used briquets before removing burner and briquetgrate. 4. Under grill remove grease cup and disco...

Page 15 - Cooking Chart; Food Safety; “Cleaning Burner

Cooking Chart Cooking times and temperatures may vary according to specificrecipes, cooking conditions or barbecue equipment used. Takethese factors into consideration to insure best results. If you usethe indirect cooking method (lighting only one burner and placingfood on opposite side of cooking ...

Page 16 - Troubleshooting; Problem

Troubleshooting Problem Burner will not lightusing ignitor. Burner(s) will notmatch light. Flames blow out. Flare-up. Persistent greasefire (can damagethe appearance ofsteel panels andaluminum castingson the grill). Flashback...(fire in burner tube(s) Possible Cause Wire and/or electrodecovered with...